Chery S11 / Chery QQ. Manual — part 54
Chery QQ Service Manual
Chapter 3 Maintenance of Car Body Electric Equipment
Maintenance notice proceeding
When check, remove and replace car body electric equipment relating parts, please
pay attention to the proceedings below.
1. Lighting equipment
There is sealed gas in halogen bulb, so please operate carefully. It maybe implode if
drop; when you remove the bulb, take the bulb at the plastic part or metal part of the
bulb, don’t touch glass part.
2. Air bag
Chery S11 equip air bag at the driver and copilot position.
Improper maintenance will
cause the incidental inflation of airbag and serious consequential accidents. So you
should regard the warning content on SRS equipment before maintenance.
3. Acoustics equipment
If remove the negative wire from the battery, the frequency position of AM/FM1/FM2
will disappear, so please remember this position before remove, after grounding wire
has been connected, then comeback to this position.
- 30 -
Chery QQ Service Manual
Section 1 Car Body Electric Equipment Common Fault Clearance
The cause analysis of car body electric equipment common fault can see in table 1.
Table 1 Car body electric equipment fault clearance
Fault system
Fault symptom or phenomenon Possible
fault position
Dipped headlight dose not light
1. Lamplight control relay
2. Headlight change switch
3. Headlight switch
4. Dipped headlight fuse
5. Bulb
6. Harness
High beam dose not light
1. Lamplight control relay
2. High beam fuse
3. Headlight change switch
4. Headlight switch
5. Bulb
6. Harness
Lamplight can not change
1. Lamplight control relay
2.
Headlight change switch
(combination switch)
3. Bulb
4. Harness
5. Combination switch
Small lamp dose not light
1. Headlight switch
2. Bulb
3. Lamplight fuse
4. Harness
Lamplight dose not work
1. Lamplight fuse
2. Lamplight control relay
3. Headlight switch
4. Bulb
5. Harness
Lamplight glitter
1. Bulb
2. Harness (whether contact well)
3. Grounding wire contact not well
Headlight and
small lamp
equipment
Lamplight dim
1. Bulb
2. Harness (whether ground well)
3. Grounding wire contact not well
- 31 -
Chery QQ Service Manual
Only one small lamp light
1. Fuse
2. Harness
3. Bulb
Small lamp dose not work
(headlight is normal)
1. Small lamp fuse
2. Headlight switch
3. Harness
4. Small lamp bulb
Rear combination light dose not
light
1. Harness
2. Bulb
3. Headlight switch
Headlight beam height control
equipment dose not work
1. Headlight switch
2. Beam height control switch
3. Beam height control motor
4. Harness
Operate abnormally
1. Headlight switch
2. Beam height control switch
3. Beam height control motor
4. Fuse
5. Harness
Headlight beam
height control
equipment
(lamplight work
normally)
Operate abnormally(one side)
1. Beam height control motor
2. Fuse
3. Harness
Front foglight dose not light(small
lamp and headlight is normal)
1. Front foglight switch
2. Power supply fuse
3. Front foglight relay
4. Bulb
5. Harness
Front foglight dose not light
(headlight and small light don’t
light)
1. Headlight switch
2. Harness
Front foglight
equipment
Only one foglight dose not light
1. Bulb
2. Harness
Rear foglight dose not light(small
lamp and headlight is normal)
1. Foglight switch
2. Power supply fuse
3. Rear foglight relay
4. Bulb
5. Harness
Rear foglight dose not light
(headlight and small light don’t
light)
1. Headlight switch
2. Harness
Rear foglight
equipment
Rear foglight light, front foglight
dose not light
1. Foglight switch
2. Front foglight relay
3. Harness
4. Bulb
- 32 -
Chery QQ Service Manual
Only one rear foglight dose not
light
1. Bulb
2. Harness
Turning and hazard alarm light
don’t light
1. Hazard alarm light switch
2. Flasher
3. Fuse
4. Harness
Flash frequency is abnormal
1. Bulb
2. Flasher
3. Harness
Hazard alarm light dose not light
(turning is normal)
1. Hazard alarm light fuse
2. Hazard alarm light switch
3. Harness
One side of the hazard alarm light
dose not light
1. Bulb
2. Harness
No turning signal (combination
instrument, wiper and syringe don’t
work)
1. Turning light switch
2. Power supply fuse
3. Harness
No turning signal (combination
instrument, wiper and syringe is
normal)
1. Power supply fuse
2. Flasher
3. Turning switch
4. Harness
One side of the turning signal dose
not light
1. Turning switch
2. Bulb
3. Harness
Turning signal
and hazard alarm
equipment
Only one bulb dose not light
1. Bulb
2. Harness
One lamp dose not light
1. Bulb
2. Harness
All interior light don’t light
1. Car inside fuse
2. Harness
3. Lamplight brightness regulation
switch
Interior light
equipment
Interior light don’t light
1. Fuse
2. Interior light switch
3. Lamplight brightness regulation
switch
4. Bulb
5. Harness
Backup light dose not light
1. Backup light switch
2. Bulb
3. Harness
Backup light
equipment
Backup light always light
1. Backup light switch
2. Harness
- 33 -
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст