Subaru Legacy III (2000-2003 year). Manual — part 526

CS-24

CONTROL SYSTEMS

DRIVE SELECT CABLE

D: ADJUSTMENT

1) Set the drive select lever to HI position.
2) Remove the knob.

3) Remove console box. <Ref. to EI-34, REMOV-
AL, Console Box.>
4) Loosen the nut.

5) Make sure transmission is in HI position. If isn't,
pull on cable to put transmission in HI position.
6) Tighten the nut in the location where the cable
end bolt stops naturally.

Tightening torque:

18 N·m (1.8 kgf-m, 13.0 ft-lb)

7) Make sure to move transmission to HI or LO po-
sition by moving the drive select lever. If it doesn't,
readjust cable.

CS-00190

( A )

CS-00104

CS-00104

CS-25

CONTROL SYSTEMS

GENERAL DIAGNOSTIC TABLE

7. General Diagnostic Table

A: INSPECTION

Symptom

Remedy

Starter does not run.

Adjust select cable and inhibitor switch, or inspect circuit.

Back-up light does not light up.

Adjust select cable and inhibitor switch, or inspect circuit.

CS-26

CONTROL SYSTEMS

GENERAL DIAGNOSTIC TABLE

MEMO:

AUTOMATIC TRANSMISSION

AT

Page

1.

General Description . . . . . . . . . . . . . . . . . . . . . 2

2.

Automatic Transmission Fluid . . . . . . . . . . . . . . . . ...30

3.

Differential Gear Oil. . . . . . . . . . . . . . . . . . . . ...31

4.

Road Test. . . . . . . . . . . . . . . . . . . . . . . . ..32

5.

Stall Test . . . . . . . . . . . . . . . . . . . . . . . . ...33

6.

Time Lag Test . . . . . . . . . . . . . . . . . . . . . . ...35

7.

Line Pressure Test . . . . . . . . . . . . . . . . . . . . . 36

8.

Transfer Clutch Pressure Test . . . . . . . . . . . . . . . . ..38

9.

Automatic Transmission Assembly . . . . . . . . . . . . . . ...39

10.

Transmission Mounting System . . . . . . . . . . . . . . . . 46

11.

Extension Case Oil Seal . . . . . . . . . . . . . . . . . . ...48

12.

Inhibitor Switch. . . . . . . . . . . . . . . . . . . . . . ..49

13.

Front Vehicle Speed Sensor . . . . . . . . . . . . . . . . . .54

14.

Rear Vehicle Speed Sensor. . . . . . . . . . . . . . . . . ..58

15.

Torque Converter Turbine Speed Sensor . . . . . . . . . . . . .59

16.

Control Valve Body . . . . . . . . . . . . . . . . . . . . ...60

17.

Shift Solenoids, Duty Solenoids and ATF Temperature Sensor . . . ...67

18.

Transfer Duty Solenoid and Valve Body . . . . . . . . . . . . ...70

19.

ATF Filter . . . . . . . . . . . . . . . . . . . . . . . . ..73

20.

Transmission Control Module (TCM) . . . . . . . . . . . . . . 76

21.

ATF Cooler Pipe and Hose . . . . . . . . . . . . . . . . . ...78

22.

Air Breather Hose. . . . . . . . . . . . . . . . . . . . . ..83

23.

Oil Charger Pipe. . . . . . . . . . . . . . . . . . . . . . 84

24.

Torque Converter Clutch Assembly . . . . . . . . . . . . . . ..85

25.

Extension Case . . . . . . . . . . . . . . . . . . . . . . .86

26.

Transfer Clutch. . . . . . . . . . . . . . . . . . . . . . ..90

27.

Multi-plate Clutch . . . . . . . . . . . . . . . . . . . . . ..97

28.

Rear Drive Shaft. . . . . . . . . . . . . . . . . . . . . . 99

29.

Reduction Driven Gear. . . . . . . . . . . . . . . . . . . 101

30.

Reduction Drive Gear. . . . . . . . . . . . . . . . . . . ..104

31.

Center Differential Carrier . . . . . . . . . . . . . . . . . ...106

32.

Parking Pawl . . . . . . . . . . . . . . . . . . . . . . ...108

33.

Torque Converter Clutch Case . . . . . . . . . . . . . . . ...109

34.

Oil Pump . . . . . . . . . . . . . . . . . . . . . . . . .112

35.

Drive Pinion Shaft . . . . . . . . . . . . . . . . . . . . ...118

36.

Front Differential. . . . . . . . . . . . . . . . . . . . . ..124

37.

High Clutch and Reverse Clutch . . . . . . . . . . . . . . . .130

38.

Planetary Gear and Low Clutch . . . . . . . . . . . . . . . ..136

39.

2-4 Brake. . . . . . . . . . . . . . . . . . . . . . . . .145

40.

One-way Clutch. . . . . . . . . . . . . . . . . . . . . ...150

41.

Low and Reverse Brake. . . . . . . . . . . . . . . . . . ..155

42.

Transmission Control Device . . . . . . . . . . . . . . . . ..158