Jaguar XJ (X350). Manual — part 833

G532445t15 : CHECK THE DMTL HEATER CONTROL CIRCUIT FOR SHORT
CIRCUIT TO GROUND

1. Key off. 2. Measure the resistance between:

DMTL pump connector CV09, harness side

Battery

Pin 02

Negative terminal

Is the resistance less than 10,000 ohms?

-> Yes

REPAIR the short circuit. For additional information, refer to the wiring diagrams. Clear the DTC, test

the system for normal operation.

-> No

GO to Pinpoint Test G532445t16.

G532445t16 : CHECK THE DMTL HEATER CONTROL CIRCUIT FOR SHORT
CIRCUIT TO POWER

1. Measure the resistance between:

DMTL pump connector CV09, harness side

Battery

Pin 02

Positive terminal

Is the resistance less than 10,000 ohms?

-> Yes

REPAIR the short circuit. For additional information, refer to the wiring diagrams. Clear the DTC, test

the system for normal operation.

-> No

GO to Pinpoint Test G532445t17.

G532445t17 : CHECK THE DMTL HEATER CONTROL CIRCUIT FOR HIGH
RESISTANCE

1. Disconnect the ECM electrical connector, EC300. 2. Measure the resistance between:

DMTL pump connector CV09, harness side ECM connector EC300, harness side

Pin 02

Pin 23

Is the resistance greater than 5 ohms?

-> Yes

REPAIR the high resistance circuit. For additional information, refer to the wiring diagrams. Clear the

DTC, test the system for normal operation.

-> No

INSTALL a new DMTL pump. Clear the DTC, test the system for normal operation. If the DTC is

repeated, refer to the warranty policy and procedures manual if an ECM is suspect.

www.

Removal and installation

Evaporative Emission Canister - VIN
Range: G00442->G45703 (17.15.13)

Special Service Tools

Powertrain assembly jack

HTJ1200-2

Removal

All vehicles

1 . Remove the luggage compartment floor covering.

1) Remove the luggage compartment floor covering securing screws.

2) Remove the luggage compartment floor covering.

2 . Remove the left-hand luggage compartment side trim panel.

3 . Remove the left-hand air spring trim panel.

4 . Disconnect the left-hand air spring electrical connector.

5

.

WARNING: Loosen the pipe no more than one full turn to allow the stored air

pressure to vent for a minimum of one minute.

Detach the left-hand air pipe.

www.