Range Rover. Manual — part 20
LUBRICANTS, FLUIDS AND CAPACITIES
3
INFORMATION
Propeller shaft Front and Rear Lubrication nipples
NLGI - 2 Multi-purpose Lithium based GREASE
. . ..
Door check straps
Rocol SM500 molygrease
. . . . . . . . . . . . . . .
Door locks
Fuchs Renocal FN745
. . . . . . . . . . . . . . . . . .
Brake and clutch reservoirs
Brake fluids having a minimum boiling point of 260
°
C
. . . . . . . . . . . ..
(500
°
F) and complying with FMVSS 116 DOT4
Engine cooling system
Use an ethylene glycol based anti-freeze (containing
. . . . . . . . . . . . . .
no methanol) with non-phosphate corrosion inhibitors
suitable for use in aluminium engines to ensure the
protection of the cooling system against frost and
corrosion in all seasons.
Battery lugs, earthing surfaces where paint
Petroleum jelly.
. . . . . .
has been removed
NOTE: Do not use Silicone Grease
Air conditioning system refrigerant
Refrigerant R134a
. . . . . . . . ...
CAUTION: DO NOT use any other type of
refrigerant.
Air conditioning compressor oil
V8 up to 99MY
Sanden SP10
. . . . . . . . . . . . . .
V8 from 99MY and diesel
Nippon Denso ND-OIL 8
. . . . . . . . . .
ABS sensor bush
Silicone grease: Staborags NBU - Wabco 830
. . . . . . . . . . . . . . . .
502,0634
Wacker chemie 704 - Wabco 830 502,0164
Kluber GL301
LUBRICATION PRACTICE
Use a high quality oil of the correct viscosity range and service classification in the engine during maintenance and
when topping up. The use of oil not to the correct specification can lead to high oil and fuel consumption and
ultimately to damaged components.
Oil to the correct specification contains additives which disperse the corrosive acids formed by combustion and
prevent the formation of sludge which can block the oilways. Additional oil additives should not be used. Always
adhere to the recommended servicing intervals.
WARNING: Many liquids and other substances used in motor vehicles are poisonous. They must
not be consumed and must be kept away from open wounds. These substances, among others,
include anti-freeze windscreen washer additives, lubricants and various adhesives.
09
LUBRICANTS, FLUIDS AND CAPACITIES
NEW RANGE ROVER
4
INFORMATION
CAPACITIES
The following capacity figures are approximate and provided as a guide only. Refer to Section 10 for correct
checking procedure for powertrain oil levels.
Engine sump and filter - Petrol
From dry
6.6 litres
. . . . . . . . . . . . . . . . ..
14.0 US pints
Refill
5.8 litres
. . . . . . . . . . . . . . . . . .
12.3 US pints
Engine sump and filter - Diesel
From dry
9.5 litres
. . . . . . . . . . . . . . . . ..
20 US pints
Refill
8.7 litres
. . . . . . . . . . . . . . . . . .
18.4 US pints
Manual gearbox
From dry
2.7 litres
. . . . . . . . . . . . . . . . ..
5.7 US pints
Refill
2.2 litres
. . . . . . . . . . . . . . . . . .
4.6 US pints
Automatic gearbox
4.6 V8 up to ’99MY
11 litres
. . . . . . . . . . . . ..
23.2 US pints
4.0 V8 (& 4.6 V8 from ’99MY)
9.7 litres
. . . . . . . . .
20.5 US pints
Diesel
9.7 litres
. . . . . . . . . . . . . . . . . ..
20.5 US pints
Transfer box
From dry
2.4 litres
. . . . . . . . . . . . . . . . ..
5.0 US pints
Refill
2.0 litres
. . . . . . . . . . . . . . . . . .
4.2 US pints
Front axle
From dry
1.7 litres
. . . . . . . . . . . . . . . . ..
3.6 US pints
Refill
1.6 litres
. . . . . . . . . . . . . . . . . .
3.4 US pints
Rear axle
From dry
1.7 litres
. . . . . . . . . . . . . . . . ..
3.6 US pints
Refill
1.6 litres
. . . . . . . . . . . . . . . . . .
3.4 US pints
Power steering box and reservoir
1.7 litres
. . . . . . . . .
3.6 US pints
Cooling system
11.3 litres
. . . . . . . . . . . . . . . .
24 US pints
Fuel tank
Petrol
100 litres
. . . . . . . . . . . . . . . . . ...
26.4 US gallons
Diesel
90 litres
. . . . . . . . . . . . . . . . . ..
24 US gallons
Air conditioning system
Refrigerant charge weight
V8 up to 99MY
1250 grammes
. . . . . . . . . . . .
44 oz
V8 from 99MY
1380
±
25 grammes
. . . . . . . . . . . .
49
±
1 oz
Diesel
1100 grammes
. . . . . . . . . . . . . . . .
39 oz
Refrigerant oil in system
V8 up to 99MY
150 cm
3
. . . . . . . . . . . .
0.32 US pint
V8 from 99MY
180 cm
3
. . . . . . . . . . . .
0.38 US pint
Diesel
140 cm
3
. . . . . . . . . . . . . . . .
0.30 US pint
LUBRICANTS, FLUIDS AND CAPACITIES
5
INFORMATION
ANTI-FREEZE
ENGINE TYPE
MIXTURE STRENGTH
PERCENTAGE
PROTECTION
CONCENTRATION
LOWER
TEMPERATURE
LIMIT
V8 Engine
One part anti-freeze
Diesel Engine
One part water
50%
Complete protection
- 33
°
F
Vehicle may be driven away immediately from cold
- 36
°
C
Safe limit protection
- 41
°
C
Coolant in mushy state. Engine may be started and driven away after warm-up
period
- 42
°
F
Lower protection
- 47
°
C
Prevents frost damage to cylinder head, block and radiator. Thaw out before
starting engine
- 53
°
F
CAUTION: Anti-freeze content must never be allowed to fall below 25% otherwise damage to the
engine is liable to occur. Also, anti-freeze content should not exceed 60% as this will greatly
reduce the cooling effect of the coolant.
09
LUBRICANTS, FLUIDS AND CAPACITIES
NEW RANGE ROVER
6
INFORMATION
FUEL REQUIREMENTS
Catalyst vehicles
Vehicles equipped with catalytic converter are designed to use ONLY unleaded fuel. Unleaded fuel must be used
for the emission control system to operate properly. Its use will also reduce spark plug fouling, exhaust system
corrosion and engine oil deterioration.
Using fuel that contains lead will result in damage to the emission control system and could result in loss of
warranty coverage. The effectiveness of the catalysts in the catalytic converters will be seriously impaired if leaded
fuel is used. The vehicle is equipped with an electronic fuel injection system, which includes two oxygen sensors
(4 oxygen sensors on NAS vehicles). Leaded fuel will damage the sensors, and will deteriorate the emission
control system.
Regulations require that pumps delivering unleaded fuel be labelled UNLEADED. Only these pumps have nozzles
which fit the filler neck of the vehicle fuel tank.
RECOMMENDED FUEL
Petrol engines
Use petrol conforming to European standard EN228
Low compression engines
With catalytic converter
91 RON minimum unleaded
. . . . . . . . . . ...
Without catalytic converter
4.0 litre
91 RON minimum unleaded or 91 RON minimum
. . . . . . . . . . . . . . .
leaded
4.6 litre
91 RON minimum unleaded or 91 RON minimum
. . . . . . . . . . . . . . .
leaded
High compression engines
95 RON minimum unleaded
. . . . . . . . . . . ...
NOTE: It is possible to use unleaded fuel with a 91 RON minimum octane rating for high
compression engines, but performance will be adversely affected.
Using fuel with an octane rating lower than stated above could seriously impair vehicle performance.
Diesel engines
Diesel fuel to European standard EN 590; minimum
. . . . . . . . . . . . . . . . Cetane No. 45
In the interests of optimum vehicle performance, the use of oxygenated fuels such as blends of methanol/gasoline
or ethanol/gasoline (e.g. ’Gasohol’) is not recommended. If oxygenated fuels are to be used, be aware of the
following maximum limits for the percentage of fuel additive that is allowed in the relevant markets:
NAS specification:
Methyl Tertiary Butyl Ether (MTBE)
15%
. . . . . . . . .
Ethyl Tertiary Butyl Ether (ETBE)
15%
. . . . . . . . . .
Ethanol (Ethyl or grain alcohol)
10%
. . . . . . . . . .
CAUTION: Wherever possible, avoid using fuel containing Methanol
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст