Jeep XJ. Manual — part 657
• Check fluid levels of coolant reservoir, power
steering, brake master cylinder, and transmission
and add as needed.
• Check all lights and all other electrical items for
correct operation.
At Each Oil Change
• Inspect exhaust system.
• Inspect brake hoses.
• Rotate the tires at each oil change interval
shown on Schedule “A” (7,500 miles) or every other
interval shown on Schedule “B” (6,000 miles).
• Check coolant level, hoses, and clamps.
• After completion of off-road operation, the
underside
of
the
vehicle
should
be
thoroughly
inspected. Examine threaded fasteners for looseness.
EMISSION CONTROL SYSTEM MAINTENANCE
The scheduled emission maintenance listed in bold
type on the Maintenance Schedules, must be done at
the mileage specified to assure the continued proper
functioning of the emission control system. These,
and all other maintenance services included in this
manual, should be done to provide the best vehicle
performance and reliability. More frequent mainte-
nance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
FLUID FILL LOCATIONS AND LUBRICATION
POINTS
The fluid fill/check locations and lubrication points
are located in each applicable group.
SCHEDULE “A”
7,500 Miles (12 000 km) or at 6 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
15,000 Miles (24 000 km) or at 12 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Check manual transmission fluid level.
• Check exhaust system.
22,500 Miles (36 000 km) or at 18 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
30,000 Miles (48 000 km) or at 24 months
• Replace air cleaner element.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Check exhaust system.
37,500 Miles (60 000 km) or at 30 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
45,000 Miles (72 000 km) or at 36 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Check manual transmission fluid level.
• Check exhaust system.
52,500 Miles (84 000 km) or at 42 months
• Check engine coolant level, hoses, and clamps.
• Flush and replace engine coolant. Then flush
and replace every 24 months or 30,000 miles (48 000
km).
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
0s - 8
LUBRICATION & MAINTENANCE
XJ
MAINTENANCE SCHEDULES (Continued)
2001 JEEP CHEROKEE
60,000 Miles (96 000 km) or at 48 months
• Replace air cleaner element.
• Replace ignition cables.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Check exhaust system.
67,500 Miles (108 000 km) or at 54 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
75,000 Miles (120 000 km) or at 60 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Check manual transmission fluid level.
• Check exhaust system.
82,500 Miles (133 000 km) or at 66 months
• Check engine coolant level, hoses, and clamps.
• Flush and replace engine coolant.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
90,000 Miles (144 000 km) or at 72 months
• Replace air cleaner element.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Check exhaust system.
97,500 Miles (156 000 km) or at 78 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
105,000 Miles (168 000 km) or at 84 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Check manual transmission fluid level.
• Check exhaust system.
112,500 Miles (180 000 km) or at 90 months
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate steering linkage (4x4 only).
• Check manual transmission fluid level.
• Check exhaust system.
120,000 Miles (192 000 km) or at 96 months
• Replace air cleaner element.
• Replace ignition cables.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage (4x4 and 4x2).
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Check exhaust system.
Important: Inspection and service should also be
performed any time a malfunction is observed or sus-
pected.
SCHEDULE “B”
Follow Schedule “B” if the vehicle is usually oper-
ated under one or more of the following conditions.
XJ
LUBRICATION & MAINTENANCE
0s - 9
MAINTENANCE SCHEDULES (Continued)
2001 JEEP CHEROKEE
• Frequent short trips driving less than 5 miles
(8 km).
• Frequent driving in dusty conditions.
• Frequent trailer towing.
• Extensive idling.
• More than 50% of driving is at sustained high
speeds during hot weather, above 90°F (32°C).
• Off-road driving.
• Desert operation.
3,000 Miles (5 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
6,000 Miles (10 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage.
• Check manual transmission fluid level.
• Check exhaust system.
9,000 Miles (14 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
12,000 Miles (19 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage.
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Change front and rear axle fluid.
• Check exhaust system.
15,000 Miles (24 000 km)
• Inspect engine air cleaner element, replace
as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
18,000 Miles (29 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage.
• Check manual transmission fluid level.
• Check exhaust system.
21,000 Miles (34 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
24,000 Miles (38 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage.
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Change front and rear axle fluid.
• Check exhaust system.
27,000 Miles (43 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
30,000 Miles (48 000 km)
• Inspect engine air cleaner element, replace
as necessary.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Check exhaust system.
0s - 10
LUBRICATION & MAINTENANCE
XJ
MAINTENANCE SCHEDULES (Continued)
2001 JEEP CHEROKEE
33,000 Miles (53 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
36,000 Miles (58 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage.
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Change front and rear axle fluid.
• Check exhaust system.
39,000 Miles (62 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
42,000 Miles (67 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage.
• Check manual transmission fluid level.
• Check exhaust system.
45,000 Miles (72 000 km)
• Inspect engine air cleaner element, replace
as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
48,000 Miles (77 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage.
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Change front and rear axle fluid.
• Check exhaust system.
51,000 Miles (82 000 km)
• Check engine coolant level, hoses, and clamps.
• Flush and replace engine coolant. Then flush
and replace every 30,000 miles (48 000 km).
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
54,000 Miles (86 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate ball joints.
• Lubricate steering linkage.
• Check manual transmission fluid level.
• Check exhaust system.
57,000 Miles (91 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Lubricate steering linkage.
• Check exhaust system.
60,000 Miles (96 000 km)
• Inspect engine air cleaner element, replace
as necessary.Replace ignition cables.
• Replace spark plugs.
• Inspect drive belt, adjust tension as necessary.
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
• Inspect brake linings.
• Lubricate ball joints.
• Lubricate steering linkage.
• Drain and refill automatic transmission fluid.
• Check manual transmission fluid level.
• Drain and refill transfer case fluid.
• Change front and rear axle fluid.
• Check exhaust system.
63,000 Miles (101 000 km)
• Check engine coolant level, hoses, and clamps.
• Change engine oil.
• Replace engine oil filter.
• Inspect brake hoses.
XJ
LUBRICATION & MAINTENANCE
0s - 11
MAINTENANCE SCHEDULES (Continued)
2001 JEEP CHEROKEE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст