Jeep Grand Cherokee WK. Manual — part 1635
SUNSHADE
REMOVAL
1. Remove the drain channel. (Refer to 23 - BODY/
SUNROOF/CHANNEL-DRAIN - REMOVAL)
2. Push up the front center of the sunshade (1) to pop
out the front two feet.
3. Rotate the sunshade (2) so that the other feet (1)
are removed from the guide track.
23 - 198
SUNROOF - SERVICE INFORMATION
WK
INSTALLATION
1. Verify the sunshade track is free of obstructions
like the trim lace/ring.
2. Start with sunshade (2) at an angle with one foot
(1) in the track.
3. Rotate the sunshade so the other rear foot is in the
track as well as the 2 other feet (3) on the same
side as the first foot.
4. To insert the remaining two feet (2) apply force to
the middle front of sunshade (3) and guide them
into the track.
5. Check that all the feet are in the right track and
verify sunshade operation.
6. Install the drain channel. (Refer to 23 - BODY/
SUNROOF/CHANNEL-DRAIN - INSTALLATION)
SWITCH-SUNROOF
DESCRIPTION
For service information refer to (Refer to 8 - ELECTRICAL/POWER TOP/SWITCH - DIAGNOSIS AND TESTING).
WK
SUNROOF - SERVICE INFORMATION
23 - 199
TRIM LACE
REMOVAL
1. Remove trim lace (2) by holding one end of the
trim lace at the butt joint and pulling horizontally
into the opening until lace is completely loose from
the headliner/sunroof joint.
INSTALLATION
1. Place butt joint of trim lace into position starting at
the drivers side middle of the opening at the butt
joint notch in the u-frame.
2. Push lace into position.
3. Ensure that the corner radii is fully engage.
4. Once the trim lace is attached to sunroof module
using a trim stick C-4755 or equivalent, begin tuck-
ing the headliner under the lip on the trim lace
working all the way around the opening. When
installing a new trim lace, begin tucking the head-
liner under the lip as the tear cord (1) is removed
working all the way around the opening.
23 - 200
SUNROOF - SERVICE INFORMATION
WK
BODY STRUCTURE
TABLE OF CONTENTS
page
page
GAP AND FLUSH
OPENING DIMENSIONS
. . . . . . . . . . . . . . . 203
SEALER LOCATIONS
. . . . . . . . . . . . . . . . . 207
STRUCTURAL ADHESIVE LOCATIONS
WELD LOCATIONS
. . . . . . . . . . . . . . . . . . . 227
WK
BODY STRUCTURE
23 - 201
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст