Jeep Wrangler TJ. Manual — part 196
FLUID CAPACITIES
SPECIFICATIONS - FLUID CAPACITIES
DESCRIPTION
SPECIFICATION
FUEL TANK
19 U.S. Gallons (71.9
Liters)****
ENGINE OIL
Engine Oil - with Filter - 2.4L
3.8 L (4.0 qts.)
Engine Oil - with Filter - 4.0L
5.7 L (6.0 qts.)
ENGINE COOLANT
Cooling System - 2.4 L
8.5 L (9.0 qts.)
Cooling System - 4.0 L
9.9 L (10.5 qts.)
POWER STEERING SYSTEM
Power steering fluid capacities are dependent on engine/
chassis options as well as steering gear/cooler options.
Depending on type and size of internal cooler, length and
inside diameter of cooler lines, or use of an auxiliary cooler,
these capacities may vary. Refer to 19, Steering for proper
fill and bleed procedures.
AUTOMATIC TRANSMISSION
Service Fill - 42RLE
3.8 L (8.0 pts)
O-haul Fill - 42RLE
8.3 L (17.6 pts.)
Dry fill capacity Depending on type and size of internal
cooler, length and inside diameter of cooler lines, or use of
an auxiliary cooler, these figures may vary. (Refer to 21 -
TRANSMISSION/AUTOMATIC - 42RLE/FLUID -
STANDARD PROCEDURE)
TRANSFER CASE
NV231
1.0 L (2.2 pts.)
NV241
2.0 L (4.2 pts.)
MANUAL TRANSMISSION
NSG 370 Approximate dry fill
or fill to bottom edge of the fill
plug hole.
1.5 L (3.17 pts.)
FRONT AXLE ± .03 L (1 oz.)
181 FBI (Model 30)
1.2 L (2.5 pts.)
216 RBI (Model 44)
1.89 L (4.0 pts.)
REAR AXLE ± .03 L (1 oz.)
194 RBI (Model 35)
1.66 L (3.5 pts.)*
216 RBI (Model 44)
1.89 L (4.0 pts.)*
* With Trac-lok add 118 ml (4.0 oz.) of Limited Slip Additive.
****Nominal refill capacities are shown. A variation may be
observed from vehicle to vehicle due to manufacturing
tolerance and refill procedure.
MAINTENANCE SCHEDULES
DESCRIPTION
MAINTENANCE SCHEDULES
There are two maintenance schedules that show
the required service for your vehicle.
First is Schedule
(B(. It is for vehicles that are
operated under the conditions that are listed below
and at the beginning of the schedule.
• Day or night temperatures are below 32°F (0°C)
• Stop and go driving
• Excessive engine idling
• Driving in dusty conditions
• Short trips of less than 10 miles (16.2 km)
• More than 50% of your driving is at sustained
high speeds during hot weather, above 90°F (32°C)
• Trailer towing
• Taxi, police, or delivery service (commercial ser-
vice)
• Off-road or desert driving
• If equipped for and operated with E-85
(ethanol) fuel.
NOTE: If ANY of these apply to you then change
your engine oil every 3,000 miles (5 000 km) or 3
months, whichever comes first and follow “Sched-
ule B” of the “Maintenance Schedules” section of
this manual.
NOTE: If ANY of these apply to you then flush and
replace
your
engine
coolant/anti-freeze
every
102,000 miles (163 000 km) or 60 months, whichever
comes first, and follow “Schedule B” of the “Main-
tenance Schedules” section of this manual.
NOTE: Most vehicles are operated under the condi-
tions listed for Schedule “B.”
Second is Schedule “A”. It is for vehicles that are
not operated under any of the conditions listed under
Schedule “B.”
Use the schedule that best describes your driving
conditions. Where time and mileage are listed, follow
the interval that occurs first.
CAUTION: Failure to perform the required mainte-
nance items may result in damage to the vehicle.
TJ
LUBRICATION & MAINTENANCE
0 - 7
At Each Stop for Fuel
• Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil
level while the vehicle is on level ground will
improve the accuracy of the oil level reading. Add oil
only when the level is at or below the ADD or MIN
mark.
• Check the windshield washer solvent, add as
required.
Once a Month
• Check the tire pressure and look for unusual
wear or damage.
• Inspect the battery and clean and tighten the
terminals as required.
• Check the fluid levels of the coolant reservoir,
brake master cylinder, power steering, and transmis-
sion, and add as needed.
• Check all lights and all other electrical items for
correct operation.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
• Inspect brake hoses.
• Check the coolant level, hoses, and clamps.
• Rotate the tires.
• Inspect manual transmission fluid level - if
equipped.
• After completion of off-road operation, the
underside
of
the
vehicle
should
be
thoroughly
inspected. Examine threaded fasteners for looseness.
Schedule “B”
Follow this schedule if you usually operate your
vehicle under one or more of the following conditions.
• Day or night temperatures are below 0°C (32°F)
• Stop and go driving
• Excessive engine idling
• Driving in dusty conditions
• Short trips of less than 16.2 km (10 miles)
• More than 50% of your driving is at sustained
high speeds during hot weather, above 32°C (90°F)
• Trailer towing
• Taxi, police, or delivery service (commercial ser-
vice)
• Off-road or desert driving
• If equipped for and operated with E-85
(ethanol) fuel.
NOTE: If ANY of these apply to you then change
your engine oil every 3,000 miles (5 000 km) or 3
months, whichever comes first and follow “Sched-
ule B” of the “Maintenance Schedules” section of
this manual.
NOTE: If ANY of these apply to you then flush and
replace
your
engine
coolant/anti-freeze
every
102,000 miles (163 000 km) or 60 months, whichever
comes first, and follow “Schedule B” of the “Main-
tenance Schedules” section of this manual.
Miles
3,000
6,000
9,000
12,000
15,000
(Kilometers)
(5 000)
(10 000)
(14 000)
(19 000)
(24 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
Inspect the engine air filter element, replace if
necessary.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
0 - 8
LUBRICATION & MAINTENANCE
TJ
MAINTENANCE SCHEDULES (Continued)
Miles
18,000
21,000
24,000
27,000
30,000
(Kilometers)
(29 000)
(34 000)
(38 000)
(43 000)
(48 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
X
Inspect the engine air filter element, replace if
necessary.
X
Inspect the PCV Valve, and replace if necessary.
L
X
Replace the spark plugs.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
Inspect the transfer case fluid, add if necessary.
X
Miles
33,000
36,000
39,000
42,000
45,000
(Kilometers)
(53 000)
(58 000)
(62 000)
(67 000)
(72 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
Inspect the engine air filter element, replace if
necessary.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
Inspect the drive belt and replace as needed.
X
TJ
LUBRICATION & MAINTENANCE
0 - 9
MAINTENANCE SCHEDULES (Continued)
Miles
48,000
51,000
54,000
57,000
60,000
(Kilometers)
(77 000)
(82 000)
(86 000)
(91 000)
(96 000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
X
Inspect the engine air filter element, replace if
necessary.
X
Inspect the PCV Valve, and replace if necessary.
L
X
Inspect the ignition cables, and replace if
necessary (2.4L Only).
X
Replace the spark plugs.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
X
Inspect the brake linings.
X
X
Drain and refill the front and rear axle fluid‡
X
X
Drain and refill the automatic transmission fluid, and
change filter.
X
Inspect the drive belt and replace as needed. Not
required if belt was previously.
X
Drain and refill the transfer case fluid.
X
Flush and replace the engine coolant/anti-freeze at 60
months, if not done at 102,000 miles (163 000 km).
X
Miles
63,000
66,000
69,000
72,000
75,000
(Kilometers)
(101 000)
(106 000)
(110 000)
(115 000)
(120 000)
Change the engine oil and engine oil filter, if
not replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
Inspect the engine air filter element, replace
if necessary.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball
joints.
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
Inspect the drive belt and replace as needed.
Not required if belt was previously replaced.
X
0 - 10
LUBRICATION & MAINTENANCE
TJ
MAINTENANCE SCHEDULES (Continued)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст