Iveco Stralis AT/AD. Manual — part 276
4
SCHEDULED MAINTENANCE
S
TRALIS
AT/AD
Base - January 2003
M1
M2
M3
M4
Type of operation
Every
80,000 km
1600 hours
Every
160,000 km
3200 hours
Every
240,000 km
4800 hours
Every
480,000 km
9600 hours
Engine
9
Change engine oil
•
•
•
•
7
Change engine oil filters
•
•
•
•
20
Change fuel filter
•
•
•
•
22
Check blow-by filter conditions through clogging indicator
•
•
•
•
25
Check clutch wear fan electro-magnetic joint
•
•
•
•
1-2 Check control belt conditions
•
•
19
Change or clean filter of steering column hydraulic system
•
•
•
•
8
Change air filter of turbo-compressor valve with variable geometry (VGT)
•
•
18
EDC system engine check-up through MODUS or IT2000
•
•
21
Check valve clearance and adjust it if needed
•
•
1
Change control belt of engine auxiliary parts
•
•
2
Change air conditioner compressor control belt
•
•
3
Change air conditioner automatic compressor backstand
•
•
Chassis and mechanical units
17
Change fuel pre-filter
•
•
•
•
13
Change air system drier filter (every year)
•
•
•
•
5
Check clutch hydraulic system fuel level
•
•
•
•
16
Clean mechanical transmission oil breather
•
•
16
Change mechanical transmission oil
•
•
16
Change oil in transmission with ZF Intarder
•
•
16
Change ZF Intarder oil filter
•
•
15
Change rear axle oil
•
•
15
Clean rear axle oil breather
•
•
14
Change rear axle reducer oil
•
•
11
Change axle wheel hub oil
•
•
6
Check headlight orientation
•
•
10
Check drive case and support fastening
•
•
Miscellaneous
•
Chassis general lubrication (every year)
•
•
•
•
•
Transfer operations
•
•
•
•
•
Road test
•
•
•
•
SCHEDULED MAINTENANCE
5
S
TRALIS
AT/AD
OFF-PLANE OPERATIONS
EPI - EVERY 40.000 Km
Or every year, or every 1,000 hours in vehicles for waste collection and carry out the following operations.
16 Change Allison automatic transmission oil and filters
16 Clean Allison automatic transmission oil breather
T1 — EVERY SIX MONTHS
(especially at the beginning of spring) and possibly when a maintenance service is performed, carry out the following operations:
• Check pollen filter conditions. In case of low annual mileage, change them once a year at the beginning of spring.
24 Wash radiator guard grid.
T2 — EVERY YEAR
and possibly before winter when a maintenance service is performed, carry out the following operations:
4
Check antifreeze quantity in engine cooling water
T3 — EVERY YEAR
and possibly before summer when a maintenance service is performed, carry out the following operations:
23 Check possible radiator clogging
T4 — EVERY YEAR
and possibly when a maintenance service is performed, carry out the following operations:
• Change ”Multipower” (if any) total power take-off oil
T5 - EVERY TWO YEARS
and possibly when a maintenance service is performed, carry out the following operations:
23 Change engine coolant
12 Change air filter dry cartridge even if there is no clogging signal
22 Change engine Blow-by filter cartridge even if there is no clogging signal
T6 - EVERY THREE YEARS
and possibly when a maintenance service is performed, carry out the following operations:
5
Change clutch hydraulic control fluid
*
Vehicles with Allison — EuroTronic transmission excluded
6
SCHEDULED MAINTENANCE
S
TRALIS
AT/AD
Base - January 2003
85488
Figure 1
SCHEDULED MAINTENANCE
7
S
TRALIS
AT/AD
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст