Iveco Daily. Manual — part 380
84
ELECTRIC/ELECTRONIC SYSTEM
D
AILY
Base - May 2004
Near the positive terminal of the battery there is a diagnostic
connector. It is fastened by 2 screws to a special bracket fitted
on the body and access to it is gained by unscrewing the
protective cap; suitably connected to the diagnostic system
(IWT, MODUS), it allows quick identification of the cause of
faults in the various electronic devices.
The diagnosis connector on F1 engine vehicles is located on
the conveyor unit lower party on the passenger side.
The table on the following page shows the correspondence
between the various electronic systems and the connector
pins referring to them.
9
22
29
35
38
36
30
23
17
10
4
1
3
16
38-PIN DIAGNOSTIC CONNECTOR
DENTIFICATION OF THE PINS OF THE 38-PIN
DIAGNOSTIC CONNECTOR
The connector shown is seen from the pin side.
NOTE
Figure 86
Figure 87
8620
8621
ELECTRIC/ELECTRONIC SYSTEM
85
D
AILY
System
Pin
Function
EDC/EGR/Methane
1
2
L
K
ABS/EBD/ABD
3
4
L
K
Air Bag/Retarder
6
K
Tachometer (connector A cell 2 instrument cluster)
8
K
Supply +15/A services
11
Input
Immobilizer/Central door locking/Alarm
12
K
Climate control system
13
14
L
K
Self-levelling suspension
15
16
L
K
Engine timing signal (connector B pin 28 EDC control unit)
Engine timing earth (battery -)
23
24
-
Screening
Supply +30
27
Battery +V
Engine rpm
28
RPM
Vehicle speed
29
-
Earth
30
-
- With EDC16: pins 1/23 are not connected.
- Can Line pin 21/22.
The unused pins are not indicated.
86
ELECTRIC/ELECTRONIC SYSTEM
D
AILY
Base - May 2004
52
Figure 88
8631
ELECTRIC/ELECTRONIC SYSTEM
87
D
AILY
Identification of fuses
N
F
N
Functions
N.
Functions
N.
Functions
1.
Additional heater
30
2.
Immobilizer/Warming/EDC
5
3.
-
-
4.
Instrument cluster (+30)
5
5.
Instrument cluster (+15)
5
6.
Stalk unit (rear fog guard, flasher)
5
7.
Stalk unit (low beams)
10
8.
Stalk unit (high beams)
15
9.
Stalk unit (side lights)
15
10.
Windscreen wiper
15
11.
Stalk unit (direction indicators/hazard warning lights)
15
12.
Stalk unit (horns)
15
13.
Reversing light
5
14.
Side light, clearance, no. plate light
5
15.
Side light cluster lighting
5
16.
Left low beam headlamp
10
17.
Right low beam headlamp
10
18.
Left high beam headlamp
10
19.
Right high beam headlamp/headlamp aming
10
20.
Interior lighting/radio/cigar lighter
10
20.
Interior lighting/radio
10
21.
Electric windscreen defrosting unit
30
21.
Cigar lighter
15
22.
Heated fuel filter
15
23.
EDC electronic control unit
25
24.
EDC
10
25.
Stop lights
5
26.
13-pin current socket
15
27.
13-pin current socket
15
28.
13-pin current socket
10
29.
38-pin diagnostic connector
5
30.
Fog lamps
10
31.
Climate control, additional heater, engine cooling
5
31.
Compressor, timer, engine fan
10
32.
Climate control
5
33.
Additional heater
20
34.
Headlamp washer
20
35.
Rear differential lock
5
36.
ABS, EBD, ABD failure warning light
5
37.
ABS
5
39.
Heated mirrors
10
39.
Heated mirrors, heated rear-screen, heated windscreen
15
40.
Power windows
30
40.
Power windows (left)
20
41.
Heated rear-screen, heated windscreen
10/
20
42.
Self-levelling suspensions
5
43.
Air bag failure warning light
5
44.
Self-levelling suspensions (Wabco)
40
45.
Air-bag
5
46.
-
-
46.
Power windows (right)
20
47.
Electric fuel pump
10
48.
Door locking/alarm
30
49.
Door locking/alarm
5
50.
Rear differential lock
30
51.
Total power takeoff
10
52.
Front differential lock (4x4)
30
53.
Self-levelling suspensions Techniek)
30
54.
Electric hatch (van and 6+1)
15
55.
Rototranslating door
15
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст