Geely EC718, EC718RV, EC715, EC715RV. Manual part — 320
Geely EC718, EC718RV, EC715, EC715RV. Manual part - 320
FE06-0119b
1.
Remove the battery negative cable. Refer to
.
2.
Lift and support the vehicle. Refer to
.
3.
Remove the wheels. Refer to
4.
Remove the tires.
5.
Remove the TPMS sensor.
Installation Procedure:
FE06-0120b
1.
Install the TPMS sensor.
Note
Make sure that the sealing rubber and steel ring
sensor are installed properly to ensure tires sealing.
2.
Install the tires.
3.
Carry out tires balancing detection and correction.
4.
Install the wheels.
5.
Lower the vehicle.
6.
Connect the battery negative cable.
Brake System
TPMS
6-113
6.7.8 Special Tools and Equipment
6.7.8.1 Trigger Tool
FE06-1007b
6-114
TPMS
Brake System
7 Steering System
7.1 Warnings and Notices. . . . . .7-2
7.1.1 Warnings and Notices. . . . . . . . . . ...7-2
7.2 Hydraulic Power Steering System. .7-
3
7.2.1 Specifications. . . . . . . . . . ...7-3
7.2.2 Description and Operation. . . . . . 7-5
7.2.2.1 Description and Operation. . . . . . . . ..7-5
7.2.3 System Working Principle. . . . . . .7-6
7.2.3.1 Hydraulic Power Rack and Pinion Steering Working
Principle. . . . . . . . . . . . . . . . . . ..7-6
7.2.3.2 Power Steering Pump Assembly Working Principle
7-8
7.2.4 Component Locator. . . . . . . . ..7-9
7.2.4.1 Component Locator. . . . . . . . . . . 7-9
7.2.5 Disassemble View. . . . . . . . ..7-10
7.2.5.1 Disassemble View. . . . . . . . . . . 7-10
7.2.5.2 Steering Disassemble View. . . . . . . ..7-11
7.2.5.3 Power Steering Pump Assembly Disassemble View
. . . . . . . . . . . . . . . . . . . . . .7-12
7.2.6 Schematic. . . . . . . . . . . ...7-13
7.2.6.1 Schematic. . . . . . . . . . . . . . .7-13
7.2.7 Diagnostic Information and Procedures. .7-
14
7.2.8 Removal and Installation. . . . . . 7-18
7.2.8.1 Drive Belt Inspection. . . . . . . . . . 7-18
7.2.8.2 Power Steering Fluid Level Inspection. . . .7-18
7.2.8.3 Steering Fluid Pressure Inspection. . . . ..7-19
7.2.8.4 rower Steering Effort Check. . . . . . . .7-21
7.2.8.5 Steering Tie Rod Ball Joint Inspection. . . .7-22
7.2.8.6 Power Steering Outlet Pipe Replacement. . 7-22
7.2.8.7 Power Steering System Bleeding. . . . . .7-26
7.2.8.8 Check Power Steering Fluid. . . . . . . .7-27
7.2.8.9 Power Steering Pipe Assembly with Fluid Reservoir
Replacement. . . . . . . . . . . . . . . . 7-27
7.2.8.10 Power Steering Pump Assembly Replacement..7-
28
7.2.8.11 Steering Bar and Ball Joint Replacement. ...7-30
7.2.8.12 Power Steering Dust Cover Replacement. ..7-32
7.2.8.13 Power Steering Gear Assembly Replacement...7-
33
7.3 Steering Wheel and Steering Column. .
7-38
7.3.1 Specifications. . . . . . . . . . .7-38
7.3.1.1 Fastener Tightening Specifications. . . . ..7-38
7.3.2 Description and Operation. . . . . ..7-39
7.3.2.1 Description and Operation. . . . . . . . 7-39
7.3.3 Component Locator. . . . . . . . 7-40
7.3.3.1 Component Locator. . . . . . . . . . ..7-40
7.3.4 Disassemble View. . . . . . . . ..7-41
7.3.4.1 Disassemble View. . . . . . . . . . . 7-41
7.3.5 Diagnostic Information and Procedures. .7-
42
7.3.6 Removal and Installation. . . . . . 7-44
7.3.6.1 Steering Wheel Free Space Check. . . . ..7-44
7.3.6.2 Upper and Lower Intermediate Shaft Universal
Joints Inspection. . . . . . . . . . . . . . ...7-44
7.3.6.3 Steering Wheel Replacement. . . . . . ...7-44
7.3.6.4
Replacement. . . . . . . . . . . . . . . . 7-46
Steering System
Table of Contents
7-1
7.1 Warnings and Notices
7.1.1 Warnings and Notices
Anti-Corrosion Materials
Warning!
Notice: If the power steering system has been serviced,
an accurate fluid level reading cannot be obtained unless
air is bled from the steering system. The air in the fluid
may cause pump cavitation noise and may cause pump
damage over a period of time.
Power Steering Hose Disconnected
Warning!
Notice: Do not start the vehicle with any power steering
gear inlet or outlet hoses disconnected. When
disconnected, plug or cap all openings of components.
Failure to do so could result in contamination or loss of
power steering fluid and damage to the system.
Steering Wheel in the Full Turn Position
Warning!
Notice: Do not hold the steering wheel in the full turn
position longer than 5 s, as damage to the steering pump
may result.
Using Proper Power Steering Fluid
Warning!
Notice: When adding fluid or making a complete fluid
change, always use DEXRON¢. Failure to use the
proper fluid will cause hose and seal damage and fluid
leaks.
7-2
Warnings and Notices
Steering System
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст