Lexus RX300 (MCU15). Manual — part 447
A/T Oil Cooler
Pipe
A14989
RH Fender
Apron
Seal
Hold Down
Clamp
Air Cleaner Cap
Air Filter
Battery
Insulator
Air Cleaner
Case
Battery
Tray
Accelerator
Cable
Cruise Control Actuator
EVAP Hose
A/T Oil Cooler
Hose
z Non–reusable part
25 (250, 18)
N·m (kgf·cm, ft·lbf) : Specified torque
Battery
A/C Compressor
Alternator Drive Belt
Adjusting Bar Bracket
Alternator
Drive Belt
Radiator Lower
Hose
PS Hose
Engine Under Cover
Brake Booster
Vacuum Hose
PS Hose
Alternator
Engine Room
J/B Cover
Fuel Inlet
Hose
Vacuum
Hose
Radiator Upper
Hose
Heater
Hose
V–Bank Cover
80 (810, 59)
Front Upper
Suspension Brace
Master Cylinder Reservoir
Purge Hose
VSV for Active
Control Engine Mount
EM–72
–
ENGINE MECHANICAL
ENGINE UNIT
LEXUS RX300 (RM785E)
A14990
z Non–reusable part
49 (500, 36)
294 (3,000, 217)
127 (1,300, 94)
RH Drive Shaft
Tie Rod End
LH Drive Shaft
z
Lower Suspension Arm
N·m (kgf·cm, ft·lbf) : Specified torque
64 (650, 47)
32 (320, 23)
Engine Moving
Control Rod
No. 2 RH Engine
Mounting Bracket
z Gasket
z Gasket
Front Exhaust Pipe
62 (630, 46)
56 (570, 41)
LH Fender Liner
RH Fender Liner
LH Rear Lower Brace
RH Rear Lower Brace
RH Front
Lower Brace
LH Front
Lower Brace
181 (1,850, 134)
181 (1,850, 134)
32 (330, 24)
A/T Shift Control Cable
Stabilizer Bar link
39 (400, 29)
35 (360, 26)
Intermediate Shaft Assembly
64 (650, 47)
Retainer
No. 2 Front Exhaust Pipe
z Gasket
z Gasket
62 (630, 46)
z
Front Propeller Shaft
74 (750, 54)
56 (570, 41)
–
ENGINE MECHANICAL
ENGINE UNIT
EM–73
LEXUS RX300 (RM785E)
A05700
z Non–reusable part
80 (820, 59)
48 (490, 35)
64 (650, 47)
64 (650, 47)
64 (650, 47)
Front Engine
Mounting Insulator
Rear Engine
Mounting
Bracket
Engine Mounting Absorber
N·m (kgf·cm, ft·lbf) : Specified torque
PS Pump Drive Belt
PS Oil Pressure Switch
Connector
43 (440, 32)
48 (490, 35)
Front Frame Assembly
PS Vane Pump
PS Pressure Tube
87 (890, 64)
80 (820, 59)
PS Gear Assembly
Front Stabilizer
19 (195, 14)
181 (1,850, 134)
EM–74
–
ENGINE MECHANICAL
ENGINE UNIT
LEXUS RX300 (RM785E)
EM1KW–01
A05693
Gummed Tape
A05687
A05608
–
ENGINE MECHANICAL
ENGINE UNIT
EM–75
LEXUS RX300 (RM785E)
REMOVAL
1.
REMOVE ENGINE UNDER COVER
2.
DRAIN ENGINE COOLANT
3.
DRAIN ENGINE OIL
4.
REMOVE HOOD
5.
REMOVE OUTER COWL TOP PANEL ASSEMBLY
(a)
Remove the 3 nuts and wiper arm and blade assemblies.
(b)
Apply gummed tape at the bottom of the front windshield
glass to protect it.
(c)
Remove the head to cowl top seal.
(d)
Remove the clip, and remove the cowl top ventilator lou-
ver. Remove the RH and LH ventilator louvers.
(e)
Disconnect the wiper motor connector and wire.
(f)
Remove the 5 bolts and wiper motor with the wiper link.
(g)
Remove the 9 bolts and outer cowl top panel.
6.
REMOVE BATTERY AND TRAY
7.
REMOVE V–BANK COVER
(See page EM–33)
8.
REMOVE AIR CLEANER CAP AND AIR CLEANER
CASE
(a)
Disconnect the air flow meter connector and wire clamp.
(b)
Disconnect the EVAP hose from EVAP pipe
(c)
Disconnect the PCV hose from LH cylinder head cover
(d)
Disconnect the 2 clamps, and disconnect the air cleaner
cap from the air cleaner case.
(e)
Loosen the 2 hose clamps, and disconnect the air cleaner
hose from the throttle body.
(f)
Disconnect the accelerator cable from the clamp.
(g)
Remove the air cleaner cap with the hose.
(h)
Remove the air filter.
(i)
Remove the 3 bolts and air cleaner case.
9.
REMOVE CRUISE CONTROL ACTUATOR
(a)
Disconnect the cable from the throttle body.
(b)
Disconnect the connector and clamp.
(c)
Remove the 2 bolts, nut and actuator.
10.
REMOVE FRONT UPPER SUSPENSION BRACE
(a)
Remove the bolt and disconnect the brake master cylin-
der reservoir.
(b)
Disconnect the engine wire.
(c)
Disconnect the 2 heater hoses.
(d)
Remove the 4 nuts and front upper suspension brace.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст