Lexus ES300 (1997 year). Manual — part 584
SA0F1–01
W03647
–
SUSPENSION AND AXLE
REAR SHOCK ABSORBER
SA–55
1103
1997 LEXUS ES300 (RM511U)
DISPOSAL
1.
FULLY EXTEND SHOCK ABSORBER ROD
2.
DRILL HOLE TO REMOVE GAS FROM CYLINDER
Using a drill, make a hole in the cylinder as shown to remove
the gas inside.
CAUTION:
The gas coming out is harmless, but be careful of chips
which may fly up when drilling.
SA0EZ–02
R00911
SST
R00912
R00823
Outside
SA–56
–
SUSPENSION AND AXLE
REAR SHOCK ABSORBER
1104
1997 LEXUS ES300 (RM511U)
REASSEMBLY
1.
INSTALL LOWER INSULATOR
2.
INSTALL SPRING BUMPER TO PISTON ROD
3.
INSTALL COIL SPRING
(a)
Using SST, compress the coil spring.
SST
09727–30021
NOTICE:
Do not use an impact wrench. It will damage the SST.
(b)
Install the coil spring to the shock absorber.
HINT:
Fit the lower end of the coil spring into the gap of the spring low-
er seat.
4.
INSTALL SUSPENSION SUPPORT
(a)
Install the suspension support to the piston rod and tem-
porarily tighten a new nut.
(b)
Rotate the suspension support and set it in the direction
shown in the illustration.
(c)
Remove the SST.
SST
09727–30021
HINT:
After removing SST, again check the direction of the suspen-
sion support.
SA0F0–01
–
SUSPENSION AND AXLE
REAR SHOCK ABSORBER
SA–57
1105
1997 LEXUS ES300 (RM511U)
INSTALLATION
Installation is in the reverse order of removal (See page
).
AFTER INSTALLATION, CHECK REAR WHEEL ALIGNMENT (See page
SA0F2–02
W03215
W03215
Suspension Member
Suspension Member Lower Stopper
Suspension Member
Lower Stopper
Sub–Assembly
Adjusting
Tube
Suspension Arm Washer
No.2 Lower Suspension Arm
Parking Brake Cable
Strut Rod
Clip
Head Insulator
Gasket
Stabilizer
Bar Link
Parking Brake
Cable Clamp
Stabilizer Bar
Bushing
Bracket
N·m (kgf·cm, ft·lbf) : Specified torque
Non–reusable part
No.2 LOWER SUSPENSION ARM
Exhaust Center Pipe
RH
LH
No.1 Lower Suspension Arm
Adjusting
Tube
Stabilizer Bar Link
Bracket
Bushing
Gasket
38 (390, 28)
51 (520, 38)
56 (570, 41)
56 (570, 41)
181 (1,850, 134)
51 (520, 38)
181 (1,850, 134)
113 (1,150, 83)
5.4 (55, 48 in.·lbf)
39 (400, 29)
113 (1,150, 83)
56 (570, 41)
19 (195, 14)
56 (570, 41)
SA–58
–
SUSPENSION AND AXLE
REAR LOWER SUSPENSION ARM AND STRUT ROD
1106
1997 LEXUS ES300 (RM511U)
REAR LOWER SUSPENSION ARM AND STRUT ROD
COMPONENTS
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст