Mazda Training manual — part 33
Powertrain Transmissions
Manual Transmissions
•
Depending on the installation position of the engine different types of manual
transmissions are used. Vehicles with transversally installed engine feature a MTX
(Manual Transaxle) and vehicles with longitudinally installed engine a MT (Manual
Transmission). The basic difference between MTX and MT is that the MTX has a
differential integrated in the transmission housing, while the MT has an external
differential at the rear axle.
•
The MTX and MT fitted in the current Mazda models have the following features:
–
Five or six speeds
–
Two shafts or three shafts (the latter ones in coaxial or non-coaxial arrangement)
–
Single-cone, double-cone or triple-cone synchronizer mechanism
–
Operated via cable or directly by shift lever
–
Hydraulic clutch actuation
–
Conventional or dual-mass flywheel
•
The following MTX are fitted in the current Mazda models:
Model / MTX
iB5
F35M-R
G35M-R
J65M-R
G66M-R
A26M-R
A26MX-R
Mazda2 (DY)
X
Mazda3
X
X
X
X
Mazda3 MPS
X
Mazda5
X
X
Mazda6
X
X
X
Mazda6 MPS
X
Mazda CX-7
X
L1001.4_T02002
•
The following MT are fitted in the current Mazda models:
Model / MT
M15M-D
R15M-D
S15M-D
S15MX-D
P66M-D
Y16M-D
Mazda MX-5
X
X
Mazda RX-8
X
X
Mazda BT-50
X
X
L1001.4_T02003
NOTE: All the manual transmissions are very similar in operation and servicing. Therefore,
this section only shows some samples of current manual transmissions.
Curriculum Training
02-3
Transmissions Powertrain
F35M-R Transmission
•
The F35M-R transmission is a two-shaft five-speed MTX, which is operated via cables. It
is only fitted in the Mazda3 models with Z-type engine.
Overview
L1001.4_02020
1
Input shaft
3
Differential
2 Output
shaft
02-4 Curriculum
Training
Powertrain Transmissions
Service Procedures
Transmission Oil Inspection
•
For transmission oil inspection on the F35M-R transmission the distance between upper
edge of the hole in the transmission housing and oil level must be measured as shown
below (refer to the workshop manual for details).
NOTE: Since the oil inspection and oil replacement procedures may differ depending on the
transmission type or may be revised concerning the oil capacity and/or oil
specification, always refer to the respective workshop manual.
L1001.4_02022
1
Distance
3
Vehicle front
2
Hole in the transmission housing
Curriculum Training
02-5
Transmissions Powertrain
A26M(X)-R Transmission
•
The A26M(X)-R transmission is a three-shaft (non-coaxial arranged) six-speed MTX,
which is operated via cables.
•
The A26M-R transmission is fitted in the Mazda3, Mazda5 and Mazda6 models with
RF-T engine, and in the Mazda3 MPS models. The A26MX-R transmission with bolted-
on transfer case is fitted in the Mazda6 MPS and Mazda CX-7 models.
NOTE: When replacing or refilling the transmission oil and/or the separate transfer oil only
use the specified type of oil (refer to the workshop manual for details).
Overview
L1001.4_02021
1
Output shaft no. 2
4
Differential
2
Input shaft
5
Output shaft no. 1
3
Transfer case (A26MX-R)
02-6 Curriculum
Training
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст