Mazda MX-5 Miata (1997+). Manual — part 82

water when cleaning the horn pad. Solvents or cleaners could adversely affect the air bag cover and cause
improper deployment of the system.

AIR CONDITIONING SERVICING

ANTI-LOCK BRAKE SYSTEM

On models equipped with anti-lock brake systems, ALWAYS observe the following cautions:



DO NOT attempt to bleed hydraulic system without first referring to the appropriate ANTI-LOCK
BRAKE SYSTEM article in the BRAKES Section.



DO NOT mix tire sizes. As long as tires remain close to the original diameter, increasing the width is
acceptable. Rolling diameter must be identical for all 4 tires. Some manufacturers recommend tires of the
same brand, style and type. Failure to follow this precaution may cause inaccurate wheel speed readings.



Use ONLY recommended brake fluids. DO NOT use silicone brake fluids in an ABS-equipped vehicle.

BATTERY WARNING

WARNING:

To avoid injury from accidental air bag deployment, read and carefully
follow all warnings and service precautions. See appropriate AIR BAG
RESTRAINT SYSTEM article in ACCESSORIES/SAFETY EQUIPMENT.

CAUTION: Disconnect negative battery cable before servicing any air bag system,

steering column or passenger side dash component. After any repair, turn
ignition key to the ON position from passenger's side of vehicle in case of
accidental air bag inflation

CAUTION: Avoid breathing R-134a refrigerant and PAG lubricant vapors, exposure

may irritate eyes, nose and throat. To remove R-134a from system use R-
134a recycling equipment that meets SAE J2210 specifications. If
accidental system discharge occurs, ventilate work area before resuming
service.

WARNING:

R-134a service equipment or vehicle A/C systems SHOULD NOT be
pressure tested or leak tested with compressed air. Some mixtures of
air/R134a have shown to be combustible at elevated pressures. These
mixtures are dangerous and may cause fire and/or explosions. See AIR
CONDITIONING SERVICE article in GENERAL INFORMATION section.

CAUTION: The anti-lock brake system contains electronic equipment that can be

susceptible to interference caused by improperly installed or high output
radio transmitting equipment. Since this interference could cause the
possible loss of the anti-lock braking capability, such equipment should
be installed by qualified professionals.

1997 Mazda MX-5 Miata

MAINTENANCE INFORMATION 1997 MAINTENANCE Mazda Maintenance Information

REPLACING BLOWN FUSES

BRAKE PAD WEAR INDICATOR

CATALYTIC CONVERTER

ELECTROSTATIC DISCHARGE SENSITIVE (ESD) PARTS

ENGINE OIL

FUEL SYSTEM SERVICE

WARNING:

When battery is disconnected, vehicles equipped with computers may
lose memory data. When battery power is restored, driveability problems
may exist on some vehicles. These vehicles may require a relearn
procedure. See COMPUTER RELEARN PROCEDURES article in GENERAL
INFORMATION section.

CAUTION: Before replacing a blown fuse, remove ignition key, turn off all lights and

accessories to avoid damaging the electrical system. Be sure to use fuse
with the correct indicated amperage rating. The use of an incorrect
amperage rating fuse may result in a dangerous electrical system
overload.

CAUTION: Indicator will cause a squealing or scraping noise, warning that brake

pads need replacement.

CAUTION: Continued operation of vehicle with a severe malfunction could cause

converter to overheat, resulting in possible damage to converter and
vehicle.

CAUTION: Any modification to the exhaust system on turbo models, which reduces

exhaust backpressure, will lead to lean fuel mixtures and excessive spark
advance. This could cause serious engine damage.

WARNING:

Many solid state electrical components can be damaged by static
electricity (ESD). Some will display a warning label, but many will not.
Discharge personal static electricity by touching a metal ground point on
the vehicle prior to servicing any ESD sensitive component.

CAUTION: Never use non-detergent or straight mineral oil.

1997 Mazda MX-5 Miata

MAINTENANCE INFORMATION 1997 MAINTENANCE Mazda Maintenance Information

HALOGEN BULBS

HEADLIGHT RETRACTOR

RADIATOR CAP

RADIATOR FAN

WARRANTY INFORMATION

BASIC NEW CAR WARRANTY

Basic components are warranted against defects in materials and workmanship for 36 months or 50,000 miles,
whichever occurs first. Tires are covered by a separate warranty offered by tire manufacturer.

ANTI-PERFORATION WARRANTY

Covers body sheet metal panels for 60 months, regardless of mileage, against perforation due to corrosion.

SAFETY RESTRAINT SYSTEM WARRANTY

WARNING:

Relieve fuel system pressure prior to servicing any fuel system
component (fuel injection models).

WARNING:

Halogen bulbs contain pressurized gas which may explode if overheated.
DO NOT touch glass portion of bulb with bare hands. Eye protection
should be worn when handling or working around halogen bulbs.

CAUTION: If headlight retractor freezes during cold weather operation, DO NOT

attempt to force mechanism. Headlights should be kept raised at all times
in cold weather. To raise them, use only headlight retractor switch. DO
NOT use headlight switch.

CAUTION: Always disconnect the fan motor when working near the radiator fan. The

fan is temperature controlled and could start at any time even when the
ignition key is in the OFF position. DO NOT loosen or remove radiator cap
when cooling system is hot.

WARNING:

Keep hands away from radiator fan. Fan is controlled by a thermostatic
switch which may come on or run for up to 15 minutes even after engine
is turned off.

CAUTION: Always refer to customer's copy of warranty information for specific

model application and/or coverage limitations.

1997 Mazda MX-5 Miata

MAINTENANCE INFORMATION 1997 MAINTENANCE Mazda Maintenance Information

Supplemental air bag system, seat belts and related components are warranted for 5 years or 60,000 miles,
whichever comes first, against defects in materials and workmanship.

REPLACEMENT PARTS & ACCESSORIES

Manufacturer-supplied parts and accessories are warranted against defects in material or workmanship for 12
months without regard to mileage. If installed by a Mazda dealer, part or accessory will be repaired or replaced
without charge during warranty period. If not installed by a dealer, part or accessory will be repaired or replaced
without charge for parts, but labor cost will be responsibility of owner.

EMISSION DEFECT WARRANTY (EXCEPT CALIFORNIA)

Warrants that vehicle was designed, built and equipped to conform with applicable Federal emission regulations
at time of sale and that vehicle is free of defects in materials and workmanship which may cause vehicle to fail
to conform with applicable regulations for 5 years or 50,000 miles, whichever occurs first.

EMISSION PERFORMANCE WARRANTY (EXCEPT CALIFORNIA)

Covers all repairs, adjustments and replacements if vehicle fails to conform to applicable emission standards
and such failure results in vehicle owner bearing a penalty or other sanction under local, state or Federal law.
Warranty period is 5 years or 50,000 miles, whichever comes first. After 2 years or 24,000 miles, manufacturer
will make necessary adjustments, repairs and replacements at no cost to owner only when noncompliance is
caused by failure of components which have been installed in vehicle for sole or primary purpose of reducing
vehicle emissions. See copy of warranty for specific components covered.

EMISSION DEFECT WARRANTY (CALIFORNIA)

For 3 years or 50,000 miles, whichever occurs first, any defective emission-related part on vehicle will be
repaired or replaced by manufacturer at no cost to owner. Certain emission-related parts are covered for repair
or replacement for 7 years or 70,000 miles, whichever occurs first. See copy of warranty for specific
components covered.

EMISSION PERFORMANCE WARRANTY (CALIFORNIA)

For 3 years or 50,000 miles, manufacturer will make all necessary repairs and adjustments to ensure vehicle
passes a required Smog Check inspection.

FUSES & CIRCUIT BREAKERS

FUSE PANEL LOCATION

Fuse box is located above driver's left knee, accessible through a removable cover. The main fuse block is
located at the right rear of the engine compartment.

The Trunk Mounted Fuse Panel is located on the right side of the trunk, near the trunk hinge.

1997 Mazda MX-5 Miata

MAINTENANCE INFORMATION 1997 MAINTENANCE Mazda Maintenance Information