Acura TSX / Honda Accord CL. Manual — part 697
disconnect SRS floor harness connector from side impact sensor. Using T30 Torx bit, remove mounting
screws and side impact sensor. See Fig. 27 .
2. To install, reverse removal procedure. Tighten side impact sensor mounting screws to specification. See
TORQUE SPECIFICATIONS . Activate air bag system. See ACTIVATING SYSTEM under
DISABLING & ACTIVATING AIR BAG SYSTEM.
Fig. 27: Identifying Side Impact Sensor
Courtesy of AMERICAN HONDA MOTOR CO., INC.
SRS UNIT
Removal & Installation
1. Before proceeding, see AIR BAG SAFETY PRECAUTIONS . Disable air bag system. See
DISABLING SYSTEM under DISABLING & ACTIVATING AIR BAG SYSTEM. Disconnect right
and left seat belt pretensioner connectors. See SEAT BELT PRETENSIONERS .
2. Remove center console, front panel and cup holder. See CENTER CONSOLE . Remove left and right
center lower cover and heater ducts. Disconnect SRS unit connectors, remove mounting screws and
remove SRS unit. See Fig. 28 .
3. To install, reverse removal procedure. Tighten SRS unit mounting screws to specification. See TORQUE
SPECIFICATIONS . Activate air bag system. See ACTIVATING SYSTEM under DISABLING &
2004 Acura TSX
2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems
ACTIVATING AIR BAG SYSTEM. Initialize OPDS system. See INITIALIZING OCCUPANT
POSITION DETECTION SYSTEM (OPDS) UNIT under DIAGNOSTICS.
Fig. 28: Identifying SRS Unit
Courtesy of AMERICAN HONDA MOTOR CO., INC.
ADJUSTMENTS
CABLE REEL CENTERING
NOTE:
New replacement cable reels are pre-centered.
2004 Acura TSX
2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems
With cable reel installed, rotate cable reel clockwise until it stops. Rotate cable reel counterclockwise about 3
turns until arrow mark on cable reel label points straight up. See Fig. 29 .
Fig. 29: Identifying Cable Reel Arrow Mark
Courtesy of AMERICAN HONDA MOTOR CO., INC.
WIRE REPAIR
DO NOT attempt to modify, splice or repair SRS wiring. If there is an open or damage in SRS wiring or
terminals, replace harness.
TORQUE SPECIFICATIONS
TORQUE SPECIFICATIONS
NOTE:
SRS wiring can be identified by special Yellow outer protective covering.
Application
Ft. Lbs. (N.m)
Brake pedal support member bolt
12 (16)
2004 Acura TSX
2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems
DIAGNOSTICS
SELF-DIAGNOSTIC SYSTEM
SRS includes a self-diagnostic function that checks system for faults in SRS components and related wiring. A
fault exists if AIR BAG warning light on instrument cluster continues to glow more than 6 seconds after
ignition is turned on, or glows or flashes while vehicle is driven.
RETRIEVING DIAGNOSTIC TROUBLE CODE (DTC)
When AIR BAG warning light is on, read DTC by connecting a HDS tester to 16-pin data link connector, and
following tester prompts to read directly from HDS tester, or reading AIR BAG warning light flashes. If AIR
BAG warning light stays on or does not come on, or side air bag cutoff warning light stays on, go to
DIAGNOSTIC TESTS .
Seat belt buckle anchor bolt
24 (32)
Seat belt lower anchor bolt
24 (32)
Seat belt pretensioner Lower mounting bolt
24 (32)
Seat belt shoulder anchor bolt
24 (32)
Steering column mounting bolts & nuts
29 (39)
Steering column yoke bolt
21 (28)
Steering wheel bolt
12 (16)
INCH Lbs. (N.m)
Driver-side air bag module Torx bolts
87 (9.8)
Front impact sensor mounting screws
87 (9.8)
Passenger-side air bag mounting bolts & nuts
87 (9.8)
Rear impact sensor mounting screws
87 (9.8)
Seat belt pretensioner upper mounting bolt
87 (9.8)
Side air bag module mounting bolts
56 (6.3)
Side curtain air bag module mounting bolts
87 (9.8)
Side impact sensor mounting screws
87 (9.8)
SRS unit mounting screws
87 (9.8)
Sun visor retaining screws
30 (3.4)
WARNING:
Accidental air bag deployment is possible. Personal injury may result.
Read and follow all WARNINGS and AIR BAG SAFETY PRECAUTIONS
before working on air bag system or related components.
Accidental air bag deployment is possible. Personal injury may result.
Use only digital multimeter with 10 milliamp or less output rating in
smallest ohmmeter range.
NOTE:
Ensure battery is sufficiently charged prior to performing diagnostic
procedures. A dead or low-charged battery may cause inaccurate test values to
be obtained.
2004 Acura TSX
2004 ACCESSORIES/SAFETY EQUIPMENT Acura - Air Bag Restraint Systems
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст