Acura RSX Honda Integra. Manual — part 73
01
01
S6M6A00A14426149455FAAT01
02
S6M6A00A14426149455FAAT02
−
−
−
−
−
−
−
−
−
−
YES
NO
YES
NO
YES
NO
YES
NO
YES
NO
10-18
10-18
Fan Controls
Radiator Fan Switch Circuit
Troubleshooting (Open)
Radiator Fan Switch Circuit
Troubleshooting (Short)
RADIATOR FAN SWITCH 2P
CONNECTOR
GRN/WHT
BLK
RADIATOR FAN SWITCH 2P
CONNECTOR
RADIATOR FAN SWITCH
2P CONNECTOR
GRN/WHT
1. Disconnect the radiator fan switch 2P connector.
2. Turn the ignition switch ON (II).
3. Measure voltage between radiator fan switch 2P
connector terminal No. 2 and body ground.
Go to step 4.
Repair an open in the wire between radiator
fan switch 2P connector terminal No. 2 and under-
hood fuse/relay box.
4. Turn the ignition switch OFF, and check for
continuity between radiator fan switch 2P
connector terminal No. 1 and body ground.
Replace the radiator fan switch.
Repair an open in the wire between radiator
fan switch 2P connector terminal No. 1 and body
ground. If the wire is OK, check for a poor ground at
G302.
1. Remove the radiator fan relay from the under-hood
fuse/relay box, and test it (see page 22-62).
Go to step 2.
Replace the radiator fan relay.
2. Remove the radiator fan switch, and test it
(see page 10-19).
Go to step 3.
Replace the radiator fan switch.
3. Disconnect ECM/PCM connector B (24P) and the
under-hood fuse relay box 14P connector.
4. Check for continuity between radiator fan switch 2P
connector terminal No. 2 and body ground.
Repair a short in the wire between radiator
fan switch 2P connector terminal No. 2 and under-
hood fuse/relay box.
Replace the under-hood fuse/relay box.
Wire side of
female terminals
Wire side of
female terminals
Wire side of
female terminals
Is ther e batter y voltage?
Is ther e continuity?
Is the r elay OK ?
Is the r adiator f an switch OK ?
Is ther e continuity?
05/06/27 18:07:06 61S6M040_100_0018
01
*01
S6M6A00A14426149451FEAT01
01
S6M6A00A14426149451KBAT02
−
−
−
−
10-19
10-19
Radiator Fan Switch Test
Radiator Fan Switch Replacement
B
1
2
A
Terminal
Operation
SWITCH
ON
OFF
Temperature
196
203 °F
(91
95 °C)
5
15 °F (3
8 °C) lower
than the temperature
when it goes on
1
2
A
24 N·m (2.4 kgf·m, 17 lbf·ft)
B
1. Remove the radiator fan switch from the radiator
(see page 10-19).
2. Suspend the radiator fan switch (A) in a container
of water as shown.
3. Heat the water, and check the temperature with a
thermometer. Do not let the thermometer (B) touch
the bottom of the hot container.
4. Measure the continuity between terminal No. 1 and
terminal No. 2 according to the table.
5. Replace, if necessary, and install the radiator fan
switch (see page 10-19).
1. Drain the engine coolant (see page 10-6).
2. Disconnect the radiator fan switch connector, then
remove the radiator fan switch (A).
3. Install the radiator fan switch with a new O-ring (B).
4. Fill the reserve tank and radiator with engine
coolant, and bleed the air from the cooling system
with the heater valve open (see step 7 on page
10-7).
05/06/27 18:07:07 61S6M040_100_0019
S6M6A000000000J1001ZAAT00
05/06/27 18:07:07 61S6M040_100_0020
S6M6A000000000J1101ZCAT00
Fuel and Emissions
Fuel and Emissions Systems
PGM-FI System
VTEC/VTC
Idle Control System
Fuel Supply System
Intake Air System
Catalytic Converter System
PCV System
EVAP System
. . . . . . . . . . . . ..
. .
. . . . . . .
. . . .
. . . . . . . . . ...
. . . . . ...
. . . . . . . . . . . . ..
. .
. . . . . . .
. . . .
. . . . . . . . . ...
. . . . . ...
Special Tools
. 11-2
General Troubleshooting Information
. 11-3
DTC Troubleshooting Index
. 11-9
Symptom Troubleshooting Index
. 11-16
System Description
. 11-20
How to Set Readiness Codes
. 11-90
. . . . . . ..
. . . . . . . . .
. . . . . . .
. . . . . .
. . . . . . . . .
. . . . . . . ..
. . . . .
. . . . . . . .
. . . . . . . .
. . . . . .
. . . . . . . ..
. . . . . . .
. . . . . . . . . . . ..
. . . . . . . .
. . . . . . ..
. . . . . . . . .
. . . . . . .
. . . . . .
. . . . . . . . .
. . . . . . . ..
. . . . .
. . . . . . . .
. . . . . . . .
. . . . . .
. . . . . . . ..
. . . . . . .
. . . . . . . . . . . ..
. . . . . . . .
Component Location Index
. 11-94
DTC Troubleshooting
. 11-98
MIL Circuit Troubleshooting
. 11-248
DLC Circuit Troubleshooting
. 11-273
Injector Replacement
. 11-277
A/F Sensor Replacement
. 11-279
Secondary HO2S Replacement
. 11-279
CKP Sensor Replacement
. 11-280
ECT Sensor Replacement
. 11-280
CMP Sensor B Replacement
. 11-281
IAT Sensor Replacement
. 11-281
Knock Sensor Replacement
. 11-282
Output Shaft (Countershaft) Speed Sensor
Replacement
. 11-283
ECM/PCM Replacement
. 11-284
. . . . . . ..
. . . . . . . . .
. . . . . . .
. . . . . .
. . .
. . . . . . . . .
. . . . . . . . .
. . . . . . ..
. . . . . . . . .
. . . . . . .
. . . . . .
. . .
. . . . . . . . .
. . . . . . . . .
Component Location Index
. 11-285
DTC Troubleshooting
. 11-286
VTC Oil Control Solenoid Valve
Removal/Test/Installation
. 11-321
CMP Sensor A Replacement
. 11-323
Rocker Arm Oil Control Solenoid
(VTEC Solenoid Valve) Inspection
. 11-323
Rocker Arm Oil Control Solenoid
(VTEC Solenoid Valve) Assembly
Removal/Installation
. 11-324
Rocker Arm Oil Pressure Switch
(VTEC Oil Pressure Switch)
Removal/Installation
. 11-324
. . . . . . ..
. . . . . . . . .
. . . .
. . . . . . . . . .
. . . . . . . . . .
. . . . . . .
. . . . . . . . .
. . . . ...
. . . . . . ..
. . . . . . . . .
. . . .
. . . . . . . . . .
. . . . . . . . . .
. . . . . . .
. . . . . . . . .
. . . . ...
Component Location Index
. 11-325
DTC Troubleshooting
. 11-326
A/C Signal Circuit Troubleshooting
. 11-337
Alternator FR Signal Circuit
Troubleshooting
. 11-339
PSP Switch Signal Circuit
Troubleshooting
. 11-342
Brake Pedal Position Switch Signal
Circuit Troubleshooting
. 11-346
Idle Speed Inspection
. 11-348
ECM/PCM Idle Learn Procedure
. 11-349
. . . . . . ..
. . . .
. . . . . . . .
. . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . ..
. . . . . . . . . . . . .
. . . . . . . . . . . . . ..
. . . . . . . . . . . . ..
. .
. . . . . . . .
. . . . . . . . . . . ..
. . . . . . . .
. . . . . .
. . . . . . . . .
. . . . . . ..
. . . .
. . . . . . . .
. . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . ..
. . . . . . . . . . . . .
. . . . . . . . . . . . . ..
. . . . . . . . . . . . ..
. .
. . . . . . . .
. . . . . . . . . . . ..
. . . . . . . .
. . . . . .
. . . . . . . . .
Component Location Index
. 11-350
Fuel Pump Circuit Troubleshooting
. 11-353
Fuel Pressure Relieving
. 11-360
Fuel Pressure Test
. 11-363
Fuel Tank Draining
. 11-364
Fuel Line Inspection
. 11-365
Fuel Line/Quick-Connect Fitting
Precautions
. 11-368
Fuel Line/Quick-Connect Fitting
Removal
. 11-369
Fuel Line/Quick-Connect Fitting
Installation
. 11-370
Fuel Pressure Regulator Replacement
. 11-373
Fuel Filter Replacement
. 11-374
Fuel Pump/Fuel Gauge Sending Unit
Replacement
. 11-375
Fuel Tank Replacement
. 11-377
Fuel Gauge Sending Unit Test
. 11-379
Low Fuel Indicator Test
. 11-382
. . . . . . ..
. . . . . . . . .
. . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . ...
. . . . . . . . . . . . . . . ..
. . . . . . . . . . . ..
. . . . .
. . . . . . ...
. . . . . . ...
. . .
. . . .
.
. . . . . . . . . . . ..
. . . . ...
. . . . . . ..
. . . . . . . . .
. . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . ...
. . . . . . . . . . . . . . . ..
. . . . . . . . . . . ..
. . . . .
. . . . . . ...
. . . . . . ...
. . .
. . . .
.
. . . . . . . . . . . ..
. . . . ...
Component Location Index
. 11-383
DTC Troubleshooting
. 11-384
Throttle Body Test
. 11-403
Throttle Body Cleaning
. 11-403
Throttle Position Sensor Signal
Inspection
. 11-404
Intake Air Bypass Control Thermal Valve
Test
. 11-405
Intake Air Bypass Control Thermal Valve
Replacement
. 11-406
Air Cleaner Removal/Installation
. 11-407
Air Cleaner Element
Inspection/Replacement
. 11-407
Throttle Cable Adjustment
. 11-408
Throttle Cable Removal/Installation
. 11-409
Throttle Body Removal/Installation
. 11-410
Throttle Body Disassembly/Reassembly
. 11-412
IMT (IMRC) Valve Position Sensor
Replacement
. 11-413
IMT (IMRC) Valve Replacement
. 11-413
. . . . . . . . .
. . . . . . . . .
DTC Troubleshooting
. 11-414
. . . . . . . . .
. . . . . . . . .
. . . . . . . ...
. . . . . . . . .
. . . . . . . . .
. . . . . . . ...
DTC Troubleshooting
. 11-417
PCV Valve Inspection
. 11-419
PCV Valve Replacement
. 11-419
. . . . . . ..
. . . . . . . . .
. . . . . . ...
. . .
. . . . . . . . . . . ..
. . . . . .
. . . . . . . .
. . . . . . . . . . . ..
. . . . . . ..
. . . . . . . . .
. . . . . . ...
. . .
. . . . . . . . . . . ..
. . . . . .
. . . . . . . .
. . . . . . . . . . . ..
Component Location Index
. 11-420
DTC Troubleshooting
. 11-422
EVAP Two Way Valve Test
. 11-468
Fuel Tank Vapor Control Valve Test
. 11-469
Fuel Tank Vapor Control Valve
Replacement
. 11-471
EVAP Canister Replacement
. 11-472
FTP Sensor Replacement
. 11-473
EVAP Canister Vent Shut Valve
Replacement
. 11-474
05/06/27 17:29:28 61S6M040_110_0001
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст