Honda Element. Manual — part 748
Fig. 23: Identifying Planetary Gears And Internal Ring Gear
Courtesy of AMERICAN HONDA MOTOR CO., INC.
Overrunning Clutch Inspection
14. While holding the drive gear (A), turn the gear shaft (B) counterclockwise. Check that the drive gear
comes out to the other end. If the drive gear does not move smoothly, replace the gear cover assembly.
Fig. 24: Identifying Gear Shaft
Courtesy of AMERICAN HONDA MOTOR CO., INC.
15. While holding the drive gear, turn the gear shaft clockwise. The gear shaft should rotate freely. If the gear
shaft does not rotate smoothly, replace the gear cover assembly.
16. If the starter drive gear is worn or damaged, replace the overrunning clutch assembly, the gear is not
available separately.
Check the condition of the torque converter ring gear to see if the starter drive gear teeth are damaged.
Starter Reassembly
2007 Honda Element EX
2007-08 ENGINE Starting System - Element
17. Install the brush into the brush holder, and set the armature (A) in the brush holder (B).
Fig. 25: Identifying Brush To Brush Holder
Courtesy of AMERICAN HONDA MOTOR CO., INC.
18. While squeezing a spring (C), insert it in the hole on the brush holder, and push it until it bottoms. Repeat
this for the other three springs (D, E, and F).
19. Install the armature and brush holder assembly into the housing.
NOTE:
To seat the new brushes, slip a strip of #500 or #600 sandpaper, with the
grit side up, between the commutator and each brush, and smoothly rotate
the armature. The contact surface of the brushes will be sanded to the
same contour as the commutator.
NOTE:
Make sure the armature stays in the holder.
2007 Honda Element EX
2007-08 ENGINE Starting System - Element
2007-2008 STEERING
Steering - Element
SPECIAL TOOLS
Fig. 1: Identifying Special Tools
Courtesy of AMERICAN HONDA MOTOR CO., INC.
2007 Honda Element EX
2007-2008 STEERING Steering - Element
2007 Honda Element EX
2007-2008 STEERING Steering - Element
COMPONENT LOCATION INDEX
Fig. 2: Identifying Power Steering Component Location
Courtesy of AMERICAN HONDA MOTOR CO., INC.
SYMPTOM TROUBLESHOOTING INDEX
Find the symptom in the chart below, and do the related procedures in the order listed until you find the cause.
SYMPTOM TROUBLESHOOTING INDEX
Symptom
Procedure(s)
Also check for
Hard steering
Troubleshoot the system (see HARD STEERING ).
Modified
suspension
Damaged
suspension
Tire sizes, tire
varieties, and
air pressure
Assist (excessively
light steering at high Check the rack guide adjustment (see RACK GUIDE
Front wheel
alignment (see
2007 Honda Element EX
2007-2008 STEERING Steering - Element
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст