Honda Odyssey 2004. Manual — part 64
*01
S0X4A00A32200043461FEAT00
*01
S0X4A00A32200000000FEAT00
Engine Oil Temperature 176°F (80°C)
Engine Oil Pressure
At Idle:
70 kPa (0.7 kgf/cm , 10 psi)
minimum
At 3,000 rpm: 490 kPa (5.0 kgf/cm , 71 psi)
minimum
2
2
8-4
8-4
Engine Lubrication
Oil Pressure Switch Test
Oil Pressure Test
B
C
A
A
1. Remove the YEL/RED wire (A) from the engine oil
pressure switch (B).
2. Check for continuity between the positive terminal
(C) and the engine (ground). There should be
continuity with the engine stopped. There should
be no continuity with the engine running.
3. If the switch fails to operate, check the engine oil
level. If the engine oil level is OK, check the engine
oil pressure.
If the oil pressure warning light stays on with the
engine running, check the engine oil level. If the oil
level is correct:
1. Remove the engine oil pressure switch and install
an oil pressure gauge (A).
2. Start the engine. Shut it off immediately if the
gauge registers no oil pressure. Repair the problem
before continuing.
3. Allow the engine to reach operating temperature
(fan comes on at least twice). The pressure should
be:
4. If oil pressure is NOT within specifications, inspect
these items:
• Check the oil screen for clogging.
• Inspect the oil pump (see page 8-9).
03/07/29 09:13:44 61S0X050_080_0004
*01
S0X4A00A32200043701KBAT00
*01
S0X4A00A32200043301KBAT00
Change interval
Every 7,500 miles (12,000 km) or 12 months
(Normal conditions)
Every 3,750 miles (6,000 km) or 6 months
(Severe conditions).
Capacity
4.0
(4.2 US qt) at oil change.
4.4
(4.6 US qt) at oil change including filter.
5.0
(5.3 US qt) after engine overhaul.
Special Tools Required
8-5
8-5
Engine Oil Replacement
Engine Oil Filter Replacement
B
A
39 N·m (4.0 kgf·m, 29 lbf·ft)
B
A
NOTE: Under normal conditions, the oil filter should be
replaced at every other oil change. Under severe
conditions, the oil filter should be replaced at each oil
change.
1. Warm up the engine.
2. Remove the drain bolt (A), and drain the engine oil.
3. Reinstall the drain bolt with a new washer (B).
4. Refill with the recommended oil (see page 3-2).
5. Run the engine for more than 3 minutes, then check
for oil leakage.
Oil filter wrench 07912-6110001
1. Remove the oil filter with the special tool.
2. Inspect the threads (A) and rubber seal (B) on the
new filter. Wipe off the seat on the engine block,
then apply a light coat of new engine oil to the filter
rubber seal. Use only filters with a built-in bypass
system.
(cont’d)
Do not overtighten.
03/07/29 09:13:45 61S0X050_080_0005
*02
*03
Tighten:
7/8 turn clockwise.
Tightening torque: 22 N·m (2.2 kgf·m, 16 lbf·ft)
8-6
Engine Lubrication
Engine Oil Filter Replacement (cont’d)
07912-6110001
Number when rubber
seal is seated.
Number after tightening.
3. Install the oil filter by hand.
4. After the rubber seal seats, tighten the oil filter
clockwise with the special tool.
5. If eight numbers (1 to 8) are printed around the
outside of the filter, use the following procedure to
tighten the filter.
• Spin the filter on until its seal lightly seats against
the block, and note which number is at the
bottom.
• Tighten the filter by turning it clockwise seven
numbers from the one you noted. For example, if
number 2 is at the bottom when the seal is lightly
seated, tighten the filter until the number 1
comes around to the bottom.
1
2
3
4
5
6
7
8
8
1
2
3
4
5
6
7
6. After installation, fill the engine with oil up to the
specified level, run the engine for more than
3 minutes, then check for oil leakage.
Number when
rubber seal is
seated
Number after
tightening
03/07/29 09:13:45 61S0X050_080_0006
*01
*02
S0X4A00A32200043311KBAT00
8-7
Oil Filter Feed Pipe Replacement
A
1. Remove the oil filter (see page 8-5).
2. Remove the oil filter feed pipe.
3. Install the two 20 x 1.5 mm nuts (A) onto the new oil
filter feed pipe. Hold the nut with a wrench, then
tighten the other nut.
4. Tighten the oil filter feed pipe to the block to
49 N·m (5.0 kgf·m, 36 lbf·ft), then remove the nuts
from the oil filter feed pipe.
5. Install the oil filter (see page 8-5).
03/07/29 09:13:46 61S0X050_080_0007
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст