Mitsubishi Colt Ralliart. Manual — part 486
COLUMN SWITCH
CHASSIS ELECTRICAL
54A-89
COLUMN SWITCH
SPECIAL TOOL
M1543000602343
Tool
Number
Name
Application
MB990784
MB990784
Ornament
remover
Removal of column cover
REMOVAL AND INSTALLATION
M1543009100606
AC207716AC
1
2
3
4
1
2
A
A
Section A-A
Claw
NOTE
: Claw positions
Removal steps
•
Steering wheel (Refer to GROUP
37, Steering wheel
.)
1.
Upper column cover
2.
Lower column cover
3.
Lighting switch
4.
Windshield wiper and washer
switch
Removal steps (Continued)
Main
Index
Group
TOC
COLUMN SWITCH
CHASSIS ELECTRICAL
54A-90
INSPECTION
M1543019504607
LIGHTING SWITCH CONTINUITY CHECK
AC103138
Switch position
Tester
connection
Specified
condition
OFF
−
Open
circuit
Automatic lighting switch 3
− 5
Continuity
exists (2
Ω
or less)
Headlamp switch
3
− 6
Continuity
exists (2
Ω
or less)
Tail lamp switch
3
− 7
Continuity
exists (2
Ω
or less)
Passing switch
3
− 8
Continuity
exists (2
Ω
or less)
Dimmer switch
3
− 9
Continuity
exists (2
Ω
or less)
Turn-signal lamp switch
(RH)
3
− 10
Continuity
exists (2
Ω
or less)
Turn-signal lamp switch
(LH)
3
− 11
Continuity
exists (2
Ω
or less)
COLUMN SWITCH (SWITCH BODY) CON-
TINUITY CHECK
1. Remove the lighting switch, wiper and washer
switch.
2. Check that there is continuity of each same termi-
nal number (from Nos. 3 to 11) between each
connectors of column switch body left in the
steering column.
1
6
8
11
10
9
7
5
4
3
2
1
6
8
11
10
9
7
5
4
3
2
AC005499
At lighting
switch side
At wiper/washer
switch side
AE
Column switch
body
Tester
connection
Specified
condition
Lighting switch side
connector
Wiper and washer
switch side
connector
3
− 3
4
− 4
5
− 5
6
− 6
7
− 7
8
− 8
9
− 9
10
− 10
11
− 11
Continuity
exists (2
Ω or
less)
Main
Index
Group
TOC
RADIO AND CD PLAYER
CHASSIS ELECTRICAL
54A-91
RADIO AND CD PLAYER
SPECIAL TOOLS
M1542000602298
Tool
Number
Name
Application
MB990784
MB990784
Ornament remover
Removal of upper centre
panel, consol panel,
lower centre panel,
heater control panel
MB991223
A
D
C
B
AZ
DO NOT USE
MB991223
A: MB991219
B: MB991220
C: MB991221
D: MB991222
Harness set
A: Test harness
B: LED harness
C: LED harness
adapter
D: Probe
For checking voltage
(continuity and value) at
harness and connectors
A: For checking
connector pin contact
voltage
B: For checking power
supply circuits
C: For checking power
supply circuits
D: For connection to
commercially
available tester
MB992006
MB992006
Extra fine probe
Continuity check and
voltage measurement at
harness wire or
connector
TROUBLESHOOTING
TROUBLESHOOTING
M1544000700176
Use these steps to plan your diagnostic strategy. Fol-
low through with each step to ensure that you have
exhausted all possible methods of finding an audio
system fault.
1. Gather information from the customer.
2. Verify that the condition described by the
customer exists.
3. Find the malfunction by following the Symptom
Chart.
4. Verify that the malfunction is eliminated.
STANDARD FLOW OF DIAGNOSIS TROU-
BLESHOOTING
Refer to GROUP 00, How to Use Troubleshoot-
ing/Inspection Service Points
.
Main
Index
Group
TOC
RADIO AND CD PLAYER
CHASSIS ELECTRICAL
54A-92
TROUBLE SYMPTOM CHART
M1544004900558
Symptom
Inspection
Procedure No.
Reference
Page
Power of radio and CD player does not turn ON when the ignition switch
is in the "ACC" position or "ON" position.
1
No sound from one speaker.
2
Noise
Noise appears at certain places when travelling
(AM).
3
Noise ispresent while moving (FM).
4
Mixed with noise, only at night (AM).
5
Broadcasts can be heard but both AM and FM have
a lot of noise.
6
There is more noise on either AM or FM.
7
There is noise when starting the engine.
8
Some noise appears when there is vibration or
shocks during travelling.
9
Noise sometimes appears on FM during travelling.
10
Ever-present noise.
11
Radio
There is noise but no reception for both AM and FM
or no sound from AM, or no sound from FM.
12
Poor reception.
13
Distortion on AM or on both AM and FM.
14
Distortion on FM only.
15
Using the auto select function, too few automatic
stations are selected.
16
Preset stations are erased.
17
CD player
CD can not be inserted.
18
No sound (CD only).
19
CD sound skips.
20
Sound quality is poor.
21
CD cannot be ejected.
22
Main
Index
Group
TOC
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст