Mitsubishi 380. Manual — part 302
NOTES
36-1
GROUP 36
PARKING BRAKES
CONTENTS
GENERAL DESCRIPTION. . . . . . . . .
PARKING BRAKE DIAGNOSIS . . . .
INTRODUCTION. . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING STRATEGY . . . . . .
SYMPTOM CHART. . . . . . . . . . . . . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . . . . .
ON-VEHICLE SERVICE. . . . . . . . . . .
PARKING BRAKE LEVER STROKE CHECK
AND ADJUSTMENT . . . . . . . . . . . . . . . . . .
PARKING BRAKE SWITCH CHECK . . . . .
PARKING BRAKE LINING SEATING
PROCEDURE . . . . . . . . . . . . . . . . . . . . . . .
PARKING BRAKE LEVER . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
PARKING BRAKE CABLE. . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
PARKING BRAKE LINING AND
DRUM . . . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
SPECIFICATIONS . . . . . . . . . . . . . . .
FASTENER TIGHTENING SPECIFICATIONS
SERVICE SPECIFICATIONS . . . . . . . . . . .
GENERAL DESCRIPTION
PARKING BRAKES
36-2
GENERAL DESCRIPTION
M1361000100344
The parking brakes are a mechanical rear wheel
brake design and controlled by a lever.
CONSTRUCTION DIAGRAM
PARKING BRAKE DIAGNOSIS
INTRODUCTION
M1361003700282
If the parking brake is faulty, parking brake effort will
become insufficient. The cause may be a malfunc-
tion of parking brake parts or the parking brake pedal
being out of adjustment.
TROUBLESHOOTING STRATEGY
M1361003800290
Use these steps to plan your diagnostic strategy. If
you follow them carefully, you will be sure that you
have exhausted most of the possible ways to find a
parking brakes fault.
1. Gather Information from the customer.
2. Verify that the condition described by the
customer exists.
3. Find the malfunction by following the Symptom
Chart.
4. Verify malfunction is eliminated.
SYMPTOM CHART
M1361004100302
AC306017
AC206222
AB
PARKING BRAKE LEVER
REAR PARKING BRAKE CABLE
FRONT PARKING BRAKE CABLE
SYMPTOM
INSPECTION PROCEDURE
REFERENCE PAGE
Brake drag
−
Refer to GROUP 35A, Basic Brake
System Diagnosis
− Symptom
Chart
.
Insufficient parking brake function
1
ON-VEHICLE SERVICE
PARKING BRAKES
36-3
SYMPTOM PROCEDURES
INSPECTION PROCEDURE 1: Insufficient Parking Brake Function
DIAGNOSIS
STEP 1. Check the excessive parking brake lever
stroke.
Refer to
.
Q: Is the parking brake lever stroke adjusted
properly?
YES :
Go to Step 2.
NO :
Adjust the parking brake lever stroke or
check the parking brake cable routing. Then
go to Step 5.
STEP 2. Check the parking brake cable for
sticking.
Q: Is the parking brake cable stuck?
YES :
Replace the cable. Then go to Step 5.
NO :
Go to Step 3.
STEP 3. Check the brake lining and brake drum
for wear.
Refer to
.
Q: Is the brake lining thickness or brake drum inside
diameter outside of specification?
YES :
Replace the rear brake shoe assembly or
rear brake disc (Refer to
). Then go to
Step 5.
NO :
Go to Step 4.
STEP 4. Check for oil, water, etc., on the lining
contact surfaces.
Q: Is oil, water, etc., on the lining contact surface?
YES :
Replace the part and determine and repair
source/cause of foreign material. Then go to
Step 5.
NO :
Carry out the parking brake lining seating
(Refer to
STEP 5. Retest the system.
Q: Is the malfunction eliminated?
YES :
The procedure is complete.
NO :
Recheck from Step 1.
ON-VEHICLE SERVICE
PARKING BRAKE LEVER STROKE CHECK AND
ADJUSTMENT
M1361000900362
1. Pull the parking brake lever with a force of approximately
200 N (45 pounds) and count the number of notches.
Standard value: 5
− 7 notches
2. If the parking brake lever stroke is not within the standard
value, adjust as described below.
(1) Release the parking brake.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст