Mitsubishi Outlander (2013+). Manual — part 716
TROUBLESHOOTING
LOCAL INTERCONNECT NETWORK (LIN)
54B-9
STEP 4. Check the sunroof motor assembly.
Disconnect sunroof motor assembly connector, and
recheck whether diagnosis code No. U1515 is set.
(1) Connect all the relevant ECUs, and disconnect
sunroof motor assembly connector only.
(2) Erase the diagnosis code.
(3) Turn the ignition switch from "LOCK" (OFF) to
"ON" position.
(4) Check whether diagnosis code No. U1515 is set.
NOTE: If diagnosis code No. U1515 is not set,
diagnosis code No. U0169 is set because the
sunroof motor assembly is disconnected. This is
normal.
(5) Turn the ignition switch to the "LOCK" (OFF)
position.
Q: Is diagnosis code No. U1515 set?
YES :
Reconnect the sunroof motor assembly
connector, and go to Step 5.
NO :
Replace the sunroof motor assembly.
STEP 5. Check the lighting control sensor.
Disconnect lighting control sensor connector, and
recheck whether diagnosis code No. U1515 is set.
(1) Connect all the relevant ECUs, and disconnect
lighting control sensor connector only.
(2) Erase the diagnosis code.
(3) Turn the ignition switch from "LOCK" (OFF) to
"ON" position.
(4) Check whether diagnosis code No. U1515 is set.
NOTE: If diagnosis code No. U1515 is not set,
diagnosis code No. U0231 is set because the
sunroof motor assembly is disconnected. This is
normal.
(5) Turn the ignition switch to the "LOCK" (OFF)
position.
Q: Is diagnosis code No. U1515 set?
YES :
Reconnect the lighting control sensor, and
go to Step 6.
NO :
Replace the lighting control sensor.
STEP 6. Recheck for diagnosis code.
Check again if the diagnosis code is set to the
ETACS-ECU.
(1) Erase the diagnosis code.
(2) Turn the ignition switch from "LOCK" (OFF) to
"ON" position.
(3) Check whether diagnosis code No. U1515 is set.
(4) Turn the ignition switch to the "LOCK" (OFF)
position.
Q: Is the diagnosis code set?
YES :
Replace the ETACS-ECU.
NO :
The trouble can be an intermittent
malfunction (Refer to GROUP 00
− How to
Cope with Intermittent Malfunction ).
54C-1
GROUP 54C
CONTROLLER
AREA NETWORK
(CAN)
CONTENTS
SPECIAL TOOL . . . . . . . . . . . . . . . . .
TEST EQUIPMENT . . . . . . . . . . . . . .
SERVICE PRECAUTIONS. . . . . . . . .
PRECAUTIONS ON HOW TO REPAIR THE
CAN BUS LINES . . . . . . . . . . . . . . . .
EXPLANATION ABOUT THE M.U.T.-III CAN
BUS DIAGNOSTICS . . . . . . . . . . . . .
TROUBLESHOOTING . . . . . . . . . . . .
CAN BUS DIAGNOSTICS TABLE . . . . . . .
CAN-RELATED CONNECTOR POSITION
CAN BUS DIAGNOSIS . . . . . . . . . . . . . . . .
Diagnosis Item 1: Communication with no ECUs is
possible (CAN-C). . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 2: Diagnose shorts in the power supply
to CAN-C. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 3: Diagnose shorts in the earth to
CAN-C. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 4: Diagnose shorts between CAN_H
and L lines (CAN-C) . . . . . . . . . . . . . . . . . .
Diagnosis Item 5: Communication with no ECUs is
possible (CAN-C-Mid). . . . . . . . . . . . . . . . .
Diagnosis Item 6: Diagnose shorts in the power supply
to CAN-C-Mid.. . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 7: Diagnose shorts in the earth to
CAN-C-Mid.. . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 8: Diagnose shorts between CAN_H
and L lines (CAN-C-Mid). . . . . . . . . . . . . . .
Diagnosis Item 9: Diagnose when the M.U.T.-III cannot
receive the data sent by ETACS-ECU. . . . .
Diagnosis Item 10: Diagnose when the M.U.T.-III
cannot receive the data sent by SRS-ECU .
Diagnosis Item 11: Diagnose when the M.U.T.-III
cannot receive the data sent by steering wheel sensor.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 12: Diagnose when the M.U.T.-III
cannot receive the data sent by 4WD-ECU <4WD>.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 13: Diagnose the lines between the joint
connectors (CAN-HI and CAN1).. . . . . . . . .
Diagnosis Item 14: Diagnose when the M.U.T.-III
cannot receive the data sent by ABS-ECU <vehicles
without ASC> or ASC-ECU <vehicles with ASC>.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 15: Diagnose when the M.U.T.-III
cannot receive the data sent by EPS-ECU..
Diagnosis Item 16: Diagnose when the M.U.T.-III
cannot receive the data sent by CVT-ECU..
Diagnosis Item 17: Diagnose when the M.U.T.-III
cannot receive the data sent by engine-ECU.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 18: Diagnose when the M.U.T.-III
cannot receive the data sent by KOS-ECU. <Vehicles
with KOS> . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 19: Diagnose when the M.U.T.-III
cannot receive the data sent by OSS-ECU. <Vehicles
with OSS> . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 20: Diagnose when the M.U.T.-III
cannot receive the data sent by CAN box unit <vehicles
with MMCS>. . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 21: Diagnose when the M.U.T.-III
cannot receive the data sent by radio and CD player
<vehicles with radio and CD player>. . . . . .
54C-2
Diagnosis Item 22: Diagnose when the M.U.T.-III
cannot receive the data sent by corner sensor/back
sensor-ECU <vehicles with reversing sensor system>.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis Item 23: Diagnose when the M.U.T.-III
cannot receive the data sent by A/C-ECU. .
Diagnosis Item 24: Diagnose when the M.U.T.-III
cannot receive the data sent by electric tailgate control
unit <vehicles with electric tailgate>. . . . . . .
Diagnosis Item 25: Diagnose when the M.U.T.-III
cannot receive the data sent by combination meter.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CAN-RELATED DIAGNOSIS CODE TABLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOL
CONTROLLER AREA NETWORK (CAN)
54C-3
SPECIAL TOOL
M1548304200983
Tool
Number
Name
Use
ACB05421
MB992745
MB992746
MB992744
MB992747
MB992748
a
b
c
d
e
DO NOT USE
AB
a. MB992744
b. MB992745
c. MB992746
d. MB992747
e. MB992748
a. Vehicle communication
interface-Lite
(V.C.I.-Lite)
b. V.C.I.-Lite main harness
A (for vehicles with CAN
communication)
c. V.C.I.-Lite main harness
B (for vehicles without
CAN communication)
d. V.C.I.-Lite USB cable
short
e. V.C.I.-Lite USB cable
long
CAN bus diagnostics
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст