Mitsubishi Montero Sport (2004+). Manual — part 536
HEADLIGHT
TSB Revision
CHASSIS ELECTRICAL
54-131
NOTE: After inspecting junction block connector D-14 and
intermediate connector E-42, inspect the wire. If junction block
connector D-14 and intermediate connector E-42 are dam-
aged, repair or replace them. Refer to GROUP 00E, Harness
Connector Inspection
.
Q: Are the harness wires between driver's side door switch
connector E-33 (terminal No.2) and ETACS-ECU
connector D-11 (terminal No.9) in good condition?
YES : Go to Step 8.
NO : Repair the harness wires. Then check that the
malfunction is eliminated.
STEP 8. Check for continuity of the key reminder switch.
(1) Remove the driver's side under cover.
(2) Remove the column covers, lower and upper.
(3) Disconnect wiring connector D-16 from the key reminder
switch and measure at the key reminder switch side.
(4) Follow the table below to measure the resistance between
terminal numbers 4 and 6.
Q: Does the measured resistance value correspond with
this range?
YES : Go to Step 9.
NO : Replace the key reminder switch. Then check that the
malfunction is eliminated.
STEP 9. Check the input signal from the key reminder
switch.
Check that the tone alarm stops sounding when terminal num-
ber 6 is grounded.
Q: Does the tone alarm stop sounding?
YES : Go to Step 10.
NO : Go to Step 12.
IGNITION KEY
POSITION
IGNITION KEY
REMINDER
SWITCH
CONNECTOR D-16
TERMINAL NO.
SPECIFIED
CONDITION
Pulled out
4
− 6
Less than 2 ohms
Inserted
4
− 6
Open circuit
AC002730
AC002731AE
D-16
HARNESS CONNECTOR:
COMPONENT SIDE
HEADLIGHT
TSB Revision
CHASSIS ELECTRICAL
54-132
STEP 10. Check key reminder switch connector D-16 for
damage for loose, corroded or damaged terminals, or
terminals pushed back in the connector.
Q: Is key reminder switch connector D-16 in good
condition?
YES : Go to step 11.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
STEP 11. Check the harness wire between key reminder
switch connector D-16 (terminal No.4) and body ground.
Q: Is the resistance wire between key reminder switch D-16
(terminal No.4) and body ground in good condition?
YES : There is no action to be taken.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
AC202060
4
5
3
1
6
7
2
AC202060
4
5
3
1
6
7
2
HEADLIGHT
TSB Revision
CHASSIS ELECTRICAL
54-133
STEP 12. Check the harness wire between key reminder
switch connector D-16 (terminal No.6) and ETACS-ECU
connector D-11 (terminal No.8).
1
2
4
5
3
6
8
9
7
10
11
13
14
12
16
17
201918
15
AC201086
AC202060
4
5
3
1
6
7
2
8
19
7
6
5
16
15
17 18
4
3
2
10 11 12 13
1
9
14
AC201910
CONNECTOR: C-72
AB
C-72 (B)
HEADLIGHT
TSB Revision
CHASSIS ELECTRICAL
54-134
NOTE: After checking intermediate connector C-72 and D-13,
check the wires. If intermediate connector C-72 and D-13 are
damaged, repair or replace them. Refer to GROUP 00E, Har-
ness Connector Inspection
.
Q: Is the harness wire between key reminder switch D-16
(terminal No.6) and ETACS-ECU connector D-11
(terminal No.8) in good condition?
YES : Go to Step 13.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
STEP 13. Measure the voltage at the input signal from the
ignition switch.
(1) Remove the ETACS-ECU and measure at the junction
block side (connector D-11).
(2) Turn the ignition switch "ON".
(3) Measure the voltage between terminal number 3 and body
ground.
• The measured value should be approximately 12 volts
(battery positive voltage).
Q: Does the measured voltage correspond with this range?
YES : Check that the malfunction is eliminated.
NO : Go to Step 14.
STEP 14. Check ETACS-ECU connector D-11 for damage
for loose, corroded or damaged terminals, or terminals
pushed back in the connector.
Q: Is ETACS-ECU connector D-11 in good condition?
YES : Go to step 15.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
AC201084
JUNCTION
BLOCK (REAR)
D-11
COMPONENT SIDE
AB
CONNECTOR: D-11
1
2
3
4
5
7
9
10
6
8
11
12
AC004032
AC
D-11
HARNESS CONNECTOR:
COMPONENT SIDE
AC201084
JUNCTION
BLOCK (REAR)
D-11
COMPONENT SIDE
AB
CONNECTOR: D-11
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст