Mitsubishi Montero Sport (2004+). Manual — part 64
HOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
TSB Revision
GENERAL <BODY AND CHASSIS>
00-15
SIMULATION TESTS
NOTE: In case of difficulty in finding the cause of the intermit-
tent malfunction, the data recorder function in the scan tool is
effective.
For these simulation tests, shake, then gently bend, pull, and
twist the wiring of each of these examples to duplicate the inter-
mittent malfunction.
• Shake the connector up-and-down, and right-and-left.
• Shake the wiring harness up-and-down, and right-and-left.
Especially, check the splice points of wiring harnesses care-
fully. Refer to GROUP 80B, SPLICE LOCATION
• Vibrate the part or sensor.
ACX00871 AB
HOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
TSB Revision
GENERAL <BODY AND CHASSIS>
00-16
INSPECTION SERVICE POINTS FOR A BLOWN
FUSE
Remove the blown fuse and measure the resistance between
the load side of the blown fuse and the ground. Close the
switches of all circuits which are connected to this fuse. If the
resistance is almost 0
Ω at this time, there is a short some-
where between these switches and the load. If the resistance is
not 0
Ω, there is no short at the present time, but a momentary
short has probably caused the fuse to blow.
The main causes of a short circuit are the following.
• Harness being clamped by the vehicle body
• Damage to the outer casing of the harness due to wear or
heat
• Water getting into the connector or circuitry
• Human error (mistakenly shorting a circuit, etc.)
ACX00872 AB
BATTERY
FUSE
LOAD
SWITCH
LOAD
SHORT-
CIRCUIT
OCCURRENCE
SECTION
VEHICLE IDENTIFICATION
TSB Revision
GENERAL <BODY AND CHASSIS>
00-17
VEHICLE IDENTIFICATION
VEHICLE IDENTIFICATION
M1001000400672
VEHICLE IDENTIFICATION NUMBER LOCATION
The vehicle identification number (VIN) is located on a plate
attached to the left top side of the instrument panel.
VEHICLE IDENTIFICATION CODE CHART PLATE
All vehicle identification numbers contain 17 digits. The vehicle
number is a code which tells country, make, vehicle type, etc.
NOTE: *: Check digit means a single number, or letter X, used
to verify the accuracy of transcription of vehicle identification
number.
ACX00873 AB
NO. ITEM
CONTENT
1
Country
J: Japan
2
Make
A: Mitsubishi
3
Vehicle type
4: Multi-purpose vehicle
4
Others
GROSS VEHICLE WEIGHT
RATING/BRAKE SYSTEM
L: 4001-5000 lbs/HYDRAULIC
M: 5001-6000 lbs/HYDRAULIC
5
Line
S: MONTERO SPORT RWD
T: MONTERO SPORT 4WD
6
Price class
2: Low
3: Medium
4: High
7
Body
1: 5-Door wagon
8
Engine
R: 3.5L
9
Check digits*
0, 1, 2, 3, -----------9, X
10
Model year
4: 2004 year
11
Plant
J: Nagoya-3
12
Serial number
000001 to 999999
AC103794
1 2 3 4 5 6
7 8
10
9
11
12
J A 4
1
1 2
0 0 0 0 0 1
L S 2
H
P
AE
J
3
VEHICLE IDENTIFICATION
TSB Revision
GENERAL <BODY AND CHASSIS>
00-18
VEHICLE IDENTIFICATION NUMBER LIST
.
VEHICLES FOR USA
.
VEHICLES FOR CANADA
VEHICLE IDENTIFICATION CODE PLATE
M1001005400484
VEHICLES IDENTIFICATION CODE PLATE
The vehicle information code plate is riveted onto the cowl top
outer panel in the engine compartment.
The plate shows model code, engine model, transmission
model and body color code.
For monotone color vehicles, the body color code shall be indi-
cated. For two-tone vehicles, each color code only shall be indi-
cated in series.
VIN (EXCEPT SEQUENCE
NUMBER)
BRAND
ENGINE
DISPLACEMENT
MODEL CODE
JA4LS21R_4J_
MITSUBISHI
MONTERO SPORT
3.5L
K89WGRSEL2M
JA4LS31R_4J_
K89WGRMEL2M
JA4MT21R_4J_
K99WGRSEL2M
JA4MT31R_4J_
K99WGRMEL2M
VIN (EXCEPT SEQUENCE
NUMBER)
BRAND
ENGINE
DISPLACEMENT
MODEL CODE
JA4MT21R_4J_
MITSUBISHI
MONTERO SPORT
3.5L
K99WGRHEL3M
JA4MT31R_4J_
K99WGRXEL3M
NO.
ITEM
CONTENT
1
MODEL K89WG
RSEL2M
K89WG: Vehicle model
RSEL2M: Model series
2
ENGIN
E
6G74
Engine model
3
EXT
CA6A
Exterior code
4
TRANS
AXLE
V4A51
4272
V4A51: Transmission model
4272: Rear differential
reduction
5
COLOR
, INT
OPT
R25 87V 03V
R25: Body color code
87V: Interior code
03V: Equipment code
AC003347
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст