Mitsubishi Pajero Pinin. Manual — part 216
REAR AXLE –
Axle Shaft
27-14
2.
Use a chisel to cut the shaven part of the bearing inner
retainer, and then remove the bearing inner retainer.
Caution
Be careful not to damage the axle shaft.
A
C
"
WHEEL BEARING REMOVAL
Use the special tool to remove the wheel bearing.
REASSEMBLY SERVICE POINT
"
A
A
BEARING OUTER RETAINER/WHEEL BEARING/
BEARING INNER RETAINER INSTALLATION
1.
Install the bearing outer retainer, wheel bearing and the
bearing inner retainer to the axle shaft in that order, as
shown in the illustration.
2.
Press-fit the bearing inner retainer to the axle shaft.
Caution
Install the wheel bearing as shown in the illustration.
MB991284
Wheel bearing
Metal plate
(Toward the wheel)
Black seal (Toward
the centre of vehicle)
REAR AXLE –
Differential Carrier
27-15
DIFFERENTIAL CARRIER
REMOVAL AND INSTALLATION
Pre-removal Operation
D
Differential Gear Oil Draining
D
Axle Shaft Removal (Refer to P.27-11.)
D
Brake Fluid Draining (Refer to GROUP 35A –
On-vehicle Service.)
Post-installation Operation
D
Brake Fluid Filling and Air Bleeding (Refer to
GROUP 35A – On-vehicle Service.)
D
Axle Shaft Installation (Refer to P.27-11.)
D
Differential Gear Oil Filling (Refer to P.27-7.)
1
49 – 59 Nm
Flange surface of axle housing
59 Nm
49 Nm
25 – 29 Nm
2
3
φ
2 – 3 mm
Sealant:
3M ATD Part No. 8661 or
equivalent
Section A – A
A
A
Removal steps
A
A
" "
A
A
1. Rear propeller shaft connection
A
B
"
2. Differential carrier assembly
3. Vent plug
REMOVAL SERVICE POINTS
A
A
"
REAR PROPELLER SHAFT DISCONNECTION
Make mating marks on the companion flange and the flange
yoke, and then disconnect the propeller shaft from the
companion flange.
Caution
Use a wire, etc. to suspend the propeller shaft from the
body to prevent it from falling.
REAR AXLE –
Differential Carrier
27-16
A
B
"
DIFFERENTIAL CARRIER REMOVAL
Loosen the differential carrier mounting nuts to the end of
each stud bolt, and then strike the lower part of differential
carrier with a piece of timber several times to separate the
differential carrier from the axle housing.
Caution
1.
Do not remove the differential carrier mounting nuts
so that the differential carrier will not fall when
separating it from the axle housing.
2.
Do not strike the companion flange.
INSTALLATION SERVICE POINT
"
A
A
REAR PROPELLER SHAFT CONNECTION
Connect the propeller shaft so that the mating marks on the
flange yoke and the companion flange of differential carrier
are aligned.
INSPECTION BEFORE DISASSEMBLY
For the inspection procedure except for the standard values
below, refer to GROUP 26 – Inspection Before Disassembly.
FINAL DRIVE GEAR BACKLASH
Standard value: 0.08 – 0.13 mm
DIFFERENTIAL GEAR BACKLASH
Standard value: 0.01 – 0.25 mm
REAR AXLE –
Differential Carrier
27-17
DISASSEMBLY
Caution
Do not disassemble the limited slip differential case assembly (helical gear type), because it is
not possible to assemble.
1
2
4
8
9
10
11
12
13
17
18
19
20
21
22
23 24
25
27
26
29
12
13
6
11
3
14
5
16
2
5
6
7
<Conventional differential>
1
2
10
3
28
1
4
6
5
2
5
6
1
15
7
<Helical LSD>
30
Disassembly steps
D
Inspection before disassembly
(Refer to P.27-17.)
1. Locking plate
A
A
"
2. Side bearing nut
3. Bearing cap
A
B
"
4. Differential case assembly
5. Side bearing outer race
A
C
"
6. Side bearing inner race
A
D
"
7. Drive gear
8. Lock pin
9. Pinion shaft
10. Pinion gear
11. Pinion washer
12. Side gear
13. Side gear spacer
14. Differential case
15. Limited slip differential case
assembly
A
E
"
16. Self-locking nut
17. Washer
A
F
"
18. Drive pinion assembly
A
F
"
19. Companion flange
20. Drive pinion front shim
(for drive pinion turning torque
adjustment)
21. Drive pinion spacer
A
G
"
22. Drive pinion rear bearing inner race
23. Drive pinion rear shim
(for drive pinion height adjustment)
24. Drive pinion
A
H
"
25. Oil seal
A
H
"
26. Drive pinion front bearing inner
race
A
H
"
27. Drive pinion front bearing outer
race
A
I
"
28. Drive pinion rear bearing outer race
29. Differential carrier
30. Dynamic damper
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст