Mitsubishi Pajero Pinin. Manual — part 187
AUTOMATIC TRANSMISSION –
Transmission Assembly
23-58
REMOVAL SERVICE POINTS
A
A
"
STARTER MOTOR REMOVAL
Remove the starter motor with the starter motor harnesses
still connected, and secure it inside the engine compartment.
A
B
"
DRIVE PLATE CONNECTION BOLTS REMOVAL
1.
Remove the connection bolts (6 places) while turning the
crankshaft.
2.
Press in the torque converter to the transmission side
so the torque converter does not remain on the engine
side.
INSTALLATION SERVICE POINTS
"
A
A
TRANSMISSION ASSEMBLY INSTALLATION
Press in the torque converter to the transmission side
completely, and then install the transmission assembly to the
engine.
"
B
A
TRANSMISSION MOUNT STOPPER INSTALLATION
1.
Install the transmission mount stopper so that the arrow
faces the direction shown.
NOTE
Disregard F and R stamped as a shared part.
2.
The sizes of the mounting bolts are different. So be sure
not to confuse them.
Bolt
Diameter x Length mm
A
10 x 50
B
10 x 60
C
10 x 40
25.9 mm
Transmission
mount stopper
Front of
vehicle
Transmission
mount insulator
assembly
A
B
B
A
C
Starter motor
4G9 only
Diameter
Length
AUTOMATIC TRANSMISSION –
Transmission Oil Cooler
23-59
TRANSMISSION OIL COOLER
REMOVAL AND INSTALLATION
Pre-removal and Post-installation Operation
D
Transmission Fluid Draining and Supplying
(Refer to P.23-35.)
D
Under Cover Removal and Installation
2
3
4
6
44 Nm
5
1
Removal steps
1. Return hose
2. Feed hose
3. Oil cooler pipe assembly
4. Hose assembly
D
Transmission assembly (Refer to
P.23-56.)
5. Oil return pipe
6. Oil feed pipe
AUTOMATIC TRANSMISSION –
A/T-ECU/4WD Indicator Control Unit
23-60
A/T-ECU
REMOVAL AND INSTALLATION
Caution
Do not strike the G sensor when removing and installing the A/T-ECU.
Pre-removal and Post-installation Operation
Rear Floor Console Removal and Installation
1
2
Removal steps
1. Floor console bracket
2. A/T-ECU
4WD INDICATOR CONTROL UNIT
REMOVAL AND INSTALLATION
Refer to GROUP 22.
23-1
AUTOMATIC
TRANSMISSION
CONTENTS
GENERAL
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outline of Changes
2
. . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING <A/T>
2
. . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст