Mitsubishi Pajero Pinin. Manual — part 321
SRS –
Side Impact Sensor
52B-3
SIDE IMPACT SENSOR
Caution
1.
Disconnect the negative (–) battery terminal
and wait for 60 seconds or more before
starting work. Also, the disconnected battery
terminal should be insulated with tape.
(Refer to ’00 PAJERO PININ Workshop
Manual <Pub. No. CKRE00E1>
P.52B-4.)
2.
Never attempt to disassemble or repair the
side impact sensors. If faulty, just replace
with new ones.
3.
Do not drop or subject the side impact
sensors to impact or vibration.
If denting, cracking, deformation, or rust are
found in the side impact sensors, replace
it with new ones. Discard the old ones.
4.
After deployment of the air bags, replace
the side impact sensors with new ones.
5.
Never use an ohmmeter on or near the side
impact sensors, and use only the special
test equipment described on ’00 PAJERO
PININ Workshop Manual
<Pub. No. CKRE00E1>
P.52B-7.
REMOVAL AND INSTALLATION
Pre-removal Operation
Turn Ignition Switch to LOCK (OFF) Position.
Disconnect the Negative (–) Battery Terminal.
1
5 Nm
Center pillar
Front of Vehicle
Removal steps
Front seat belt (Refer to GROUP 52A.)
1. Side impact sensor
Installation steps
A
Pre-installation inspection
B
1. Side impact sensor
Front seat belt (Refer to GROUP 52A.)
Negative (–) battery cable connection
C
Post-installation inspection
NOTE
The figure shows the side impact sensor (R.H.).
For service points, refer to Basic Manual.
CHASSIS
ELECTRICAL
Click on the applicable bookmark to selected the required model year
54A-2
CHASSIS
ELECTRICAL
CONTENTS
BATTERY
5
. . . . . . . . . . . . . . . . . . . . . . . . . . .
SERVICE SPECIFICATION
5
. . . . . . . . . . . . . . .
ON-VEHICLE SERVICE
5
. . . . . . . . . . . . . . . . . .
Fluid Level and Specific Gravity Check
5
. . . . . .
Charging
6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Testing Procedure
7
. . . . . . . . . . . . . . . . . . .
IGNITION SWITCH AND IMMOBILIZER
SYSTEM*
8
. . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOL
8
. . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
8
. . . . . . . . . . . . . . . . . . . .
IGNITION SWITCH AND IMMOBILIZER
SYSTEM
13
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
COMBINATION METERS
17
. . . . . . . . . . . .
SERVICE SPECIFICATIONS
17
. . . . . . . . . . . . .
SEALANT
18
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOLS
18
. . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
19
. . . . . . . . . . . . . . . . . . .
CONTINUED ON NEXT PAGE
WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES
WARNING!
(1) Improper service or maintenance of any component of the SRS, or any SRS-related component, can lead to personal
injury or death to service personnel (from inadvertent firing of the air bag) or to the driver and passenger (from
rendering the SRS inoperative).
(2) Service or maintenance of any SRS component or SRS-related component must be performed only at an authorized
MITSUBISHI dealer.
(3) MITSUBISHI dealer personnel must thoroughly review this manual, and especially its GROUP 52B – Supplemental
Restraint System (SRS) before beginning any service or maintenance of any component of the SRS or any SRS-related
component.
NOTE
The SRS includes the following components: SRS-ECU, SRS warning lamp, air bag module, clock spring and interconnecting
wiring. Other SRS-related components (that may have to be removed/installed in connection with SRS service or maintenance)
are indicated in the table of contents by an asterisk (*).
54A-3
ON-VEHICLE SERVICE
24
. . . . . . . . . . . . . . . . . .
Speedometer Check
24
. . . . . . . . . . . . . . . . . . . . . .
Tachometer Check
24
. . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit Check
25
. . . . . . . . . . . . . . . . . .
Fuel Level Warning Switch Check
26
. . . . . . . . .
Engine Coolant Temperature Gauge Unit Check
26
COMBINATION METERS
27
. . . . . . . . . . . . . . . .
OUTSIDE THERMO SENSOR
29
. . . . . .
SERVICE SPECIFICATIONS
29
. . . . . . . . . . . . .
HEADLAMP, FRONT TURN-SIGNAL
LAMP AND FRONT FOG LAMP
30
. . . .
SERVICE SPECIFICATIONS
30
. . . . . . . . . . . . .
SPECIAL TOOL
30
. . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
30
. . . . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE
31
. . . . . . . . . . . . . . . . .
Headlamp Aiming
31
. . . . . . . . . . . . . . . . . . . . . . . .
Headlamp Intensity Measurement
32
. . . . . . . . . .
Front Fog Lamp Aiming
33
. . . . . . . . . . . . . . . . . .
Bulb Replacement
34
. . . . . . . . . . . . . . . . . . . . . . . .
HEADLAMP, FRONT TURN-SIGNAL LAMP
AND FRONT FOG LAMP
35
. . . . . . . . . . . . . . .
SIDE TURN-SIGNAL LAMP
37
. . . . . . . . .
SPECIAL TOOL
37
. . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
37
. . . . . . . . . . . . . . . . . . .
SIDE TURN-SIGNAL LAMP
38
. . . . . . . . . . . . .
ROOM LAMP
38
. . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
38
. . . . . . . . . . . . . . . . . . .
REAR COMBINATION LAMP, REAR
FOG LAMP
38
. . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOLS
38
. . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
38
. . . . . . . . . . . . . . . . . . .
REAR COMBINATION LAMP, REAR FOG
LAMP
39
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HIGH-MOUNTED STOP LAMP
AND LICENCE PLATE LAMP
42
. . . . . . . .
COLUMN SWITCH
43
. . . . . . . . . . . . . . . . . .
RHEOSTAT
44
. . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOL
44
. . . . . . . . . . . . . . . . . . . . . . . .
RHEOSTAT
44
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
HAZARD WARNING LAMP
SWITCH
45
. . . . . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOL
45
. . . . . . . . . . . . . . . . . . . . . . . .
HAZARD WARNING LAMP SWITCH
45
. . . . .
HORN
46
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CIGARETTE LIGHTER
46
. . . . . . . . . . . . . .
ACCESSORY SOCKET
47
. . . . . . . . . . . . .
RADIO AND TAPE PLAYER
48
. . . . . . . . . .
TROUBLESHOOTING
48
. . . . . . . . . . . . . . . . . . .
Quick-reference Troubleshooting Chart
48
. . . . .
RADIO AND TAPE PLAYER
61
. . . . . . . . . . . . .
CD AUTOCHANGER
62
. . . . . . . . . . . . . . . . . . . .
SPEAKER
63
. . . . . . . . . . . . . . . . . . . . . . . . .
ANTENNA
64
. . . . . . . . . . . . . . . . . . . . . . . . .
REAR WINDOW DEFOGGER
65
. . . . . . .
ON-VEHICLE SERVICE
65
. . . . . . . . . . . . . . . . .
Printed-heater Line Check
65
. . . . . . . . . . . . . . . .
Rear Window Defogger Relay Continuity
Check
65
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REAR WINDOW DEFOGGER SWITCH
66
. . .
CONTINUED ON NEXT PAGE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст