Mitsubishi Eclipse. Manual — part 374
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.0L>
13B-39
STEP 7. Check for open circuit and harness damage
between volume airflow sensor connector B-14 (terminal
No. 7) and ECM connector C-51 (terminal No. 19) <M/T> or
PCM connector C-52 (terminal No. 19) <A/T>.
Q: Is the harness wire in good condition?
YES : Replace the ECM or PCM. Then go to Step 9.
NO : Repair it. Then go to Step 9.
AK300078
3
4
5
1
2
6
7
CONNECTOR: B-14
AB
B-14 (B)
HARNESS
CONNECTOR:
COMPONENT SIDE
AK300443
2
3
4
5
6
7
8
9
11
12
13
14
15
16
17
18
19
20
30
21
22
23
24
25
26
27
28
29
31
32
33
34
35
1
10
CONNECTOR: C-51 <M/T>
C-51 (GR)
AB
HARNESS CONNECTOR:
COMPONENT SIDE
AK300458
2
3
4
5
6
7
8
9
11
12
13
14
15
16
17
18
19
20
30
21
22
23
24
25
26
27
28
29
31
32
33
34
35
1
10
CONNECTOR: C-52 <A/T>
C-52 (GR)
AB
HARNESS CONNECTOR:
COMPONENT SIDE
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.0L>
13B-40
STEP 8. Replace the volume airflow sensor.
(1) Replace the volume airflow sensor.
(2) Carry out a test drive with the drive cycle pattern. Refer to
Diagnostic Function
− OBD-II Drive Cycle − Procedure 6 −
Other Monitor
(3) Check the diagnostic trouble code (DTC).
Q: Is DTC P0101 set?
YES : Replace the ECM or PCM. Then go to Step 9.
NO : The inspection is complete.
STEP 9. Test the OBD-II drive cycle.
(1) Carry out a test drive with the drive cycle pattern. Refer to
Diagnostic Function
− OBD-II Drive Cycle − Procedure 6 −
Other Monitor
(2) Check the diagnostic trouble code (DTC).
Q: Is DTC P0101 set?
YES : Retry the troubleshooting.
NO : The inspection is complete.
AK300078
3
4
5
1
2
6
7
CONNECTOR: B-14
AB
B-14 (B)
HARNESS
CONNECTOR:
COMPONENT SIDE
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.0L>
13B-41
DTC P0102: Volume Airflow Circuit Low Input
AK301583
65
43
50
42
49
41
48
60 61
64
46 47
58 59
67 68
45
56
66
52
51
44
53
62
54
63
57
55
1 2 3 4 5 6 7
RED
RED-
WHITE
RED-
WHITE
RED-
WHITE
GREEN-BLUE
BR
O
W
N
WHITE-GREEN
B-14
BATTERY
VOLUME AIRFLOW
SENSOR
5 V
19<M/T>*1
19<A/T>*3
7
4
5
3
ENGINE CONTROL MODULE (ECM) <M/T>
OR
POWERTRAIN CONTROL MODULE (PCM) <A/T>
MFI
RELAY
1
2
4
3
34<M/T>*1
16<A/T>*3
61<M/T>*2
65<A/T>*4
C-51 <M/T>, C-52 <A/T>
(MU803784)
C-58 <M/T>
(MU803782)
C-55 <A/T>
(MU803781)
NOTE
*1: ECM connector C-51 <M/T>
*2: ECM connector C-58 <M/T>
*3: PCM connector C-52 <A/T>
*4: PCM connector C-55 <A/T>
2
3 4
5 6
7 8
9
11 12 13 14 15 16 17 18 19 20
30
21 22 23
24 25
26 27 28 29
3132 33
34 35
1
10
42 43
48 49 50 51 52 53 54 55 56 57
46
45
44
58 59
60 61 62 63
64 65 66
47
41
Volume Airflow Sensor Circuit
3 4
1 2
A-18X
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.0L>
13B-42
.
CIRCUIT OPERATION
• The volume airflow sensor power is supplied from
the MFI relay (terminal No. 4), and the ground is
provided on the ECM (terminal No. 34) <M/T> or
PCM (terminal No. 16) <A/T>.
• 5-volt power is applied to the volume airflow sen-
sor output terminal (terminal No. 3) from the ECM
(terminal No. 61) <M/T> or PCM (terminal No. 65)
<A/T>. The volume airflow sensor generates a
pulse signal when the output terminal and ground
are opened/closed (opened/short).
.
TECHNICAL DESCRIPTION
• While the engine is running, the volume airflow
sensor outputs a pulse signal which corresponds
to the volume of air flow.
• The ECM <M/T> or PCM <A/T> checks whether
the frequency of this signal output by the volume
airflow sensor while the engine is running is at or
above the set value.
.
DESCRIPTIONS OF MONITOR METHODS
Volume airflow sensor output voltage is out of speci-
fied range.
.
MONITOR EXECUTION
Continuous
.
MONITOR EXECUTION CONDITIONS (Other
monitor and Sensor)
Other Monitor (There is no temporary DTC stored
in memory for the item monitored below)
• Not applicable
Sensor (The sensor below is determined to be
normal)
• Not applicable
.
AK300121
MFI RELAY
CONNECTOR: A-18X
AB
A-18X
AK300053
CONNECTOR: B-14
VOLUME AIRFLOW
SENSOR
AB
B-14 (B)
AK300091
CONNECTORS: C-51, C-58 <M/T>
ECM
AB
C-51 (GR)
C-58 (GR)
AK300244
CONNECTORS: C-52, C-55 <A/T>
AB
PCM
C-52 (GR)
C-55 (GR)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст