Mitsubishi Galant (2004+). Manual — part 1286
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.8L ENGINE>
13B-837
STEP 3. Measure the power supply voltage at throttle
actuator control motor relay harness side connector B-14X
CAUTION
Because it is not possible to distinguish the top and the
bottom of the throttle actuator control motor relay, inspect
with the triangle mark printed on the relay connector at the
wiring harness, inspect it by using triangle mark on the
junction block as a reference.
(1) Disconnect the connector B-14X and measure at the
harness side.
(2) Measure the voltage between terminal No. 1 and ground.
• Voltage should be battery positive voltage.
Q: Is battery positive voltage (approximately 12 volts)
present?
YES : Go to Step 4.
NO : Check harness connector A-13 at intermediate
connector for damage, and repair or replace as
required. Refer to GROUP 00E, Harness Connector
Inspection
. If intermediate connector A-13 is
in good condition, repair it because of open circuit or
short circuit to ground between relay box (9) and
throttle actuator control motor relay connector B-14X
(terminal No. 1). Then go to Step 14.
1
2
3
4
AK303175
CONNECTOR: B-14X
FRONT OF VEHICLE
B-14X
AB
HARNESS
CONNECTOR:
COMPONENT SIDE
RELAY BOX
AK303186AB
B-14X HARNESS
CONNECTOR:
COMPONFNT SIDE
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.8L ENGINE>
13B-838
STEP 4. Measure the power supply voltage at throttle
actuator control motor relay harness side connector
B-14X.
CAUTION
Because it is difficult to distinguish the top and the bottom
of the throttle actuator control motor relay connector at the
wiring harness, inspect it by using triangle mark on the
junction block as a reference. to
(1) Disconnect the connector B-14X and measure at the
harness side.
(2) Turn the ignition switch to the "ON" position.
(3) Measure the voltage between terminal No. 2 and ground.
• Voltage should be battery positive voltage.
(4) Turn the ignition switch to the "LOCK"(OFF) position.
Q: Is battery positive voltage (approximately 12 volts)
present?
YES : Go to Step 6.
NO : Go to Step 5.
1
2
3
4
AK303175
CONNECTOR: B-14X
FRONT OF VEHICLE
B-14X
AB
HARNESS
CONNECTOR:
COMPONENT SIDE
RELAY BOX
AK303189AB
B-14X HARNESS
CONNECTOR:
COMPONFNT SIDE
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.8L ENGINE>
13B-839
STEP 5. Check harness connector B-17X at MFI relay for
damage.
Q: Is the harness connector in good condition?
YES : Repair harness wire between MFI relay connector
B-17X (terminal No. 4) and throttle actuator control
motor relay connector B-14X (terminal No. 1)
because of open circuit or short circuit to ground.
Then go to Step 14.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
. Then go to Step 14.
1
2
3
4
AK303017
CONNECTOR: B-17X
FRONT OF VEHICLE
B-17X
AB
HARNESS
CONNECTOR:
COMPONENT SIDE
RELAY BOX
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <3.8L ENGINE>
13B-840
STEP 6. Measure the power supply voltage at PCM harness
side connector B-23.
(1) Disconnect the connector B-23 and measure at the harness
side.
(2) Turn the ignition switch to the "ON" position.
(3) Measure the voltage between terminal No. 123 and ground.
• Voltage should be battery positive voltage.
(4) Turn the ignition switch to the "LOCK"(OFF) position.
Q: Is battery positive voltage (approximately 12 volts)
present?
YES : Go to Step 7.
NO : Repair harness wire between throttle actuator control
motor relay connector B-14X (terminal No. 3) and
PCM connector B-23 (terminal No. 123) because of
open circuit or short circuit to ground. Then go to Step
14.
127 126 125 124 123 122 121
133 132 131 130 129 128
140 139 138 137 136 135 134
146 145 144 143 142 141
153 152 151 150 149 148 147
AK303058
HARNESS CONNECTOR:
COMPONENT SIDE
CONNECTOR: B-23
B-23
PCM
AB
AIR CLEANER
127 126 125 124 123 122 121
133 132 131 130 129 128
140 139 138 137 136 135 134
146 145 144 143 142 141
153 152 151 150 149 148 147
AK303182
B-23 HARNESS
CONNECTOR:
COMPONENT SIDE
AB
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст