Mitsubishi Montero (1991+). Manual — part 182
1987-91 . . . . . . . . . .. 2.3 Qts. (2.2L)
1992-95 . . . . . . . . . .. 2.4 Qts. (2.3L)
Service Labor Times
Application Hours
30,000 (60,000) 50,000
Application Mile Service Mile Service
2.6L 4-Cylinder
Automatic Transmission . 7.9 (8.9) . . . . . 2.6
Manual Transmission . ... 6.9 (7.9) . . . . . 2.6
3.0L V6
Automatic Transmission . 6.1 (10.6) . . . . 2.6
Manual Transmission . ... 5.1 (9.6) . . . . . 2.6
LUBRICATION SPECIFICATIONS TABLE
Application Fluid Specifications
Brake & Clutch Fluid . . . . . . ... DOT 3 Or DOT 4
Engine Coolant . . . . Ethylene-Glycol Antifreeze Coolant
Engine Oil (1)
Minimum Temperature
Greater Than 32
F (0
C) . . SAE 20W-40 Or 20W-50 API SG/CD
Greater Than -10
F (-23
C) .. SAE 10W-30 Or 10W-40 API SG/CD
Maximum Temperature
Less Than 60
F (16
C) . . . SAE 5W-30 Or 5W-40 API SG/CD
Front Axle & Conventional Rear Axle
Minimum Temperature
Greater Than -10
F (-23
C) . . SAE 85W-90, 80W-90 API GL-5
Maximum Temperature
Less Than -30
F (-34
C) . . . . ... SAE 75W API GL-5
Power Steering Fluid . . . . . . ... Dexron-IIE ATF
Rear Axle (With Limited
Slip Differential) . . ... Hypoid Gear Oil (8149630EX) Or
Equivalent
Transmission
Automatic . . . . . . . . . Dexron-IIE ATF
Manual Transaxle &
Transfer Case (4WD) . . ... SAE 75W-85W, 75W-90 API GL-5
(1) - Since temperature ranges for different oil grades overlap,
brief fluctuations in outside temperatures are no cause for
concern.
FLUID CAPACITIES
FLUID CAPACITIES TABLE
Application Quantity
A/C System R-12 Refrigerant
1983-87 . . . . . . . . . . .. 24-26 Ozs.
1988-91 . . . . . . . . . . . . 32 Ozs.
1992-93 . . . . . . . . . . . . 28 Ozs.
A/C System R-134a Refrigerant (1)
1994-95 . . . . . . . . . . .. 21-23 Ozs.
Automatic Transmission
1984-86 . . . . . . . . . ( 2) 7.2 Qts. (6.8L)
1987-93 . . . . . . . . . . 7.6 Qts. (7.2L)
1994 (3.0L SOHC) . . . . . . . 7.6 Qts. (7.2L)
1994 (3.0L DOHC & 3.5L) . . . . . . 9.0 Qts. (8.5L)
1995 . . . . . . . . . . 7.9 Qts. (7.5L)
Cooling System
1983-88 . . . . . . . . . . 8.5 Qts. (8.0L)
1989-95
2.6L . . . . . . . . . ... 9.7 Qts. (9.2L)
3.0L . . . . . . . . . .. 10.0 Qts. (9.5L)
1994
95
3.5L . . . . . . . . . .. 10.0 Qts. (9.5L)
Differential
1983-88 . . . . . . . . . . 1.9 Qts. (1.8L)
1989-93
2.6L . . . . . . . . . ... 1.9 Qts. (1.8L)
3.0L . . . . . . . . . ... 2.7 Qts. (2.6L)
1994
3.0L & 3.5L . . . . . . . . 2.7 Qts. (2.6L)
1995
3.0L . . . . . . . . . ... 2.7 Qts. (2.6L)
3.5L . . . . . . . . . ... 3.3 Qts. (3.2L)
Engine Oil
1983-86 . . . . . . . . . . 6.0 Qts. (5.8L)
1987 . . . . . . . . . . 5.2 Qts. (5.0L)
1988 . . . . . . . . . . 5.0 Qts. (4.8L)
1989-91 . . . . . . . . . . 5.5 Qts. (5.3L)
1992-95 . . . . . . . . . . 5.2 Qts. (4.9L)
Power Steering . . . . . . . . 1.1 Qts. (1.0L)
Fuel Tank
1983-88 . . . . . . . . . 15.9 Gals. (60L)
1989-90
2.6L 2-Door . . . . . . . ... 15.9 Gals. (60L)
3.0L 2-Door . . . . . . . ... 19.9 Gals. (75L)
2.6L & 3.0L 4-Door . . . . . . .. 24 Gals. (92L)
1991-95 . . . . . . . . . .. 24 Gals. (92L)
Manual Transmission
1983-91 . . . . . . . . . . 2.3 Qts. (2.2L)
1992 . . . . . . . . . . 2.4 Qts. (2.3L)
1993-95 . . . . . . . . . . 2.6 Qts. (2.5L)
Transfer Case
1983-91 . . . . . . . . . . 2.3 Qts. (2.2L)
1992-95 . . . . . . . . . . 2.4 Qts. (2.3L)
(1) - Use of R12 in a R134a system will result in SEVERE DAMAGE.
(2) - 1983 model equipped with manual transmission only.
K - SENSOR RANGE CHARTS
1991 Mitsubishi Montero
1991 ENGINE PERFORMANCE
Sensor Operating Range Charts
Chrysler Motors: Colt, Colt 200, Colt Vista,
Ram-50, Stealth, Summit,
Mitsubishi: Eclipse, Galant, Mirage, Montero,
Pickup, 3000GT
INTRODUCTION
Sensor operating range information can help determine if a
sensor is out of calibration. An out-of-calibration sensor may not set
a trouble code, but it may cause driveability problems.
SENSOR OPERATING RANGE CHARTS
NOTE: Unless stated otherwise in test procedure, perform all
voltage tests using a Digital Volt-Ohmmeter (DVOM) with a
minimum 10-megohm input impedance. For connector and
terminal identification, see L - WIRING DIAGRAMS article in
the ENGINE PERFORMANCE Section.
COOLANT TEMP SENSOR RESISTANCE TABLE (1)
Temperature
F (
C) Ohms
Galant, Montero 3.0L, & Pickup 3.0L
32 (0) . . . . . . . . 5900
68 (20) . . . . . . . 2500
104 (40) . . . . . . ... 2700
176 (80) . . . . . . . 300
All Others
32 (0) . . . . . . . . 5900
68 (20) . . . . . . . 2500
104 (40) . . . . . . ... 1100
176 (80) . . . . . . . 300
(1) - Measure resistance across disconnected
sensor terminals.
EGR TEMP SENSOR RESISTANCE TABLE (1) (2)
Temperature
F (
C) Ohms
122 (50) . . . . . . . 60-83
212 (100) . . . . . . .. 11-14
(1) - Measure resistance across disconnected
sensor terminals.
(2) - Specifications apply to all models
except Montero.
INTAKE AIR TEMP SENSOR RESISTANCE TABLE (1)
Temperature
F (
C) Ohms
32 (0) . . . . . . . ... 6000
68 (20) . . . . . . . .. 2700
176 (80) . . . . . . . .. 400
(1) - On Stealth and 3000GT, measure resistance
between terminals No. 5 and 6 of airflow
sensor connector. On all other models measure
resistance between terminals No. 4 and 6 of
airflow sensor connector.
MOTOR POSITION SENSOR RESISTANCE TEST TERMINALS TABLE
Application (1) Terminals (2) Terminals
Colt Vista . . . . 1-3 . . . ... 1-2
Colt, Colt 200, & Summit .. 2-3 . . . ... 3-5
(1) - Measure resistance between terminals of motor
position sensor connector.
(2) - Apply 6 volts between terminals No. 1 and 2 of
idle speed control (ISC) connector. Check
resistance between terminals of motor position
sensor when ISC motor is activated.
MOTOR POSITION SENSOR RESISTANCE TABLE (1)
Condition Ohms
Connector Unplugged . . . . . ... 4000-6000
6 Volts Applied . . . Resistance Changes Smoothly
(1) - See MOTOR POSITION SENSOR RESISTANCE
TEST TERMINALS table for terminal positions.
OXYGEN SENSOR VOLTAGE TABLE (1) (2)
Application Volts
All Models
Lean . . . . . . . . 0.1
Rich . . . . . . . . 1.0
(1) - Measure between sensor terminal No. 1
and ground or between terminals No. 1 and 2.
(2) - Test at normal operating temperature.
O2 SENSOR HEATING ELEMENT RESISTANCE TABLE ( 1)
Application (2) Temperature:
F (
C) Ohms
Eclipse 2.0L Galant 2.0L, Mirage 1.6L . .. 68 (20) . . .. 12
Montero 3.0L, Pickup 3.0L & Ram-50 3.0L . 68 (20) . . .. 20
Stealth & 3000GT 3.0L (3) . . . . .. 68 (20) . . .. 20
(1) - Measure between sensor terminals No. 3 and 4.
(2) - Information on other models not available from manufacturer.
(3) - Stealth and 3000GT turbo models have 2 oxygen sensors.
Measure between sensor terminals No. 2 and 4 on rear sensor.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст