Mitsubishi Montero (2004+). Manual — part 1166
SPECIFICATIONS
TSB Revision
POWER STEERING
37A-53
LUBRICANTS
M1372000400264
SEALANTS
M1372000500410
Tie rod swing resistance N (lb) [N
⋅m (in-lb)]
11
− 35 (35.4 − 82.7)
[1.4
− 4.9 (12.4 − 43.4)]
−
Engine idle speed r/min
1,000
± 100
−
Stationary steering effort N (lb)
[Fluctuation allowance N (lb)]
39.2 (8.8) or less
[5.9 (1.33)]
−
Oil pump pressure
MPa (psi)
Oil pump relief pressure
8.3
− 9.0 (1,209 − 1,305) −
Pressure under no-load conditions
0.34(49.3)
−
Steering gear retention hydraulic
pressure
8.3
− 9.0 (1,209 − 1,305) −
Oil pressure switch operating
pressure MPa (psi)
OFF
→ ON
1.5
− 2.0 (217 − 290)
−
ON
→ OFF
1.5
− 2.0 (217 − 290)
−
Gear box total pinion torque N
⋅m (in-lb)
[Change in torque: 0.7 N
⋅m (6.1 in-lb) or less]
0.6
− 1.7 (5.3 − 15.0)
−
Opening dimension of special tool MB991561 mm (in)
2.9 (0.11)
−
Band crimped width mm (in)
2.4
− 2.8 (0.09 − 0.11)
−
ITEM
STANDARD VALUE
LIMIT
ITEM
SPECIFIED LUBRICANT
QUANTITY dm
3
(qt)
Power steering fluid
GENUINE MITSUBISHI POWER
STEERING FLUID
Approximately 0.6
(0.63)
O-ring, oil seal, rack bushing, bearing,
spool assembly, cam ring, rotor
GENUINE MITSUBISHI POWER
STEERING FLUID
As required
ITEM
SPECIFIED SEALANT
REMARK
Steering shaft cover bolt hole on the
toeboard
3M
AAD Part No.8663 Windo-weld
Resealant or equivalent
−
End plug, rack support cover
3M
AAD Part No.8672, 8679, 8678,
8661, 8663 or equivalent
Semi-drying sealant
Bellows
MITSUBISHI GENUINE PART NO.
MZ100116EX
−
NOTES
52B-1
GROUP 52B
SUPPLEMENTAL
RESTRAINT
SYSTEM (SRS)
CONTENTS
GENERAL DESCRIPTION. . . . . . . . .
SERVICE PRECAUTIONS. . . . . . . . .
SRS AIR BAG DIAGNOSIS . . . . . . . .
INTRODUCTION TO DIAGNOSIS . . . . . . .
TROUBLESHOOTING STRATEGY . . . . . .
DIAGNOSTIC FUNCTION . . . . . . . . . . . . .
SRS WARNING LIGHT CHECK . . . . . . . . .
DIAGNOSTIC TROUBLE CODE CHART . .
DIAGNOSTIC TROUBLE CODE
PROCEDURES. . . . . . . . . . . . . . . . . . . . . .
TROUBLE SYMPTOM CHART. . . . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . . . . .
SPECIAL TOOLS. . . . . . . . . . . . . . . .
TEST EQUIPMENT . . . . . . . . . . . . . .
SRS MAINTENANCE . . . . . . . . . . . . .
POST-COLLISION DIAGNOSIS. . . . .
INDIVIDUAL COMPONENT
SERVICE. . . . . . . . . . . . . . . . . . . . . . .
FRONT IMPACT SENSORS. . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
SRS CONTROL UNIT (SRS-ECU) . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
Continued on next page
Battery posts, terminals and related accessories contain lead and lead compounds. WASH HANDS
AFTER HANDLING.
WARNING
WARNING
•
Carefully read and observe the information in the SRS SERVICE PRECAUTIONS prior to any service.
•
For information concerning diagnosis or maintenance, alays observe the procedures in the SRS Diagnosis or the
SRS Maintenance sections, respectively.
•
If any SRS components are removed or replaced in connection with any service procedures, be sure to follow the
procedures in the INDIVIDUAL COMPONENT SERVICE section for the componentnts involved.
•
If you have any questions about the SRS, please contact the MMNA Tech Line.
52B-2
AIR BAG MODULE(S) AND
CLOCK SPRING . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . .
INSPECTION . . . . . . . . . . . . . . . . . . . . . . .
SIDE IMPACT SENSOR . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION . . . . . . . . . . . . . . . . . . . . . . .
SEAT BELTS WITH PRE-
TENSIONER . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
AIR BAG MODULE AND SEAT BELT
PRE-TENSIONER DISPOSAL
PROCEDURES . . . . . . . . . . . . . . . . . .
SPECIFICATIONS . . . . . . . . . . . . . . .
FASTENER TIGHTENING
SPECIFICATIONS. . . . . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст