Dodge Durango (HB). Manual — part 1128
![](/vehicles/wlang/dowa/rowno/jud.png)
3. Remove two fuel tank strap bolts (3) and remove
both tank support straps (4).
HB
FUEL DELIVERY
14 - 23
![](/vehicles/wlang/dowa/rowno/anle.png)
4. Carefully lower tank a few inches and disconnect fuel pump module electrical connector (5) at top of tank. To
disconnect electrical connector: Push upward on red colored tab to unlock. Push on black colored tab while
removing connector.
5. Disconnect fuel line (6) at fuel pump module fitting by pressing on tabs at side of quick-connect fitting.
6. Disconnect NVLD, ORVR and EVAP lines (10) at front of tank.
7. Continue to lower tank for removal.
8. If fuel tank is to be replaced, remove fuel pump module from tank. Refer to Fuel Pump Module Removal/Instal-
lation procedures.
INSTALLATION
1. If fuel tank is to be replaced, install fuel pump module into tank. Refer to Fuel Pump Module Removal/Installation
procedures.
2. Position fuel tank to hydraulic jack.
3. Raise tank until positioned near body.
4. Connect EVAP, ORVR and NVLD lines at front of tank.
5. Connect fuel pump module electrical connector at top of tank.
6. Connect fuel line quick-connect fitting to pump module.
7. Continue raising tank until positioned snug to body.
8. Install and position both tank support straps. Install two fuel tank strap bolts and tighten. Refer to Torque Spec-
ifications.
9. Connect rubber fill and vent hoses to fuel tank fittings and tighten hose clamps.
10. If equipped, install fuel tank skid plate.
11. Lower vehicle.
12. Fill fuel tank with fuel.
13. Start engine and check for fuel leaks near top of module.
FILTER-INLET
DESCRIPTION
Refer to Fuel Pump Module for information.
REGULATOR-FUEL PRESSURE
DESCRIPTION
Refer to Fuel Pump Module for information.
FILTER-FUEL
DESCRIPTION
Refer to Fuel Pump Module for information.
14 - 24
FUEL DELIVERY
HB
![](/vehicles/wlang/dowa/rowno/cor.png)
FUEL INJECTION
TABLE OF CONTENTS
page
page
PEDAL-ACCELERATOR (EXC. CODE XAP)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
. . . . . . . . . . . . . . . . . . . . . . . . . 27
SENSOR-ACCELERATOR PEDAL POSIT
. . . . . . . . . . . . . . . . . . . . . . . . . 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
. . . . . . . . . . . . . . . . . . . . . . . . . 28
SENSOR-CRANKSHAFT POSITION
. . . . . . . . . . . . . . . . . . . . . . . . . 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . 29
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
. . . . . . . . . . . . . . . . . . . . . . . . . 31
INJECTOR-FUEL
. . . . . . . . . . . . . . . . . . . . . . . . . 32
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
. . . . . . . . . . . . . . . . . . . . . . . . . 33
RELAY-FUEL PUMP
. . . . . . . . . . . . . . . . . . . . . . . . . 34
. . . . . . . . . . . . . . . . . . . . . . . . . . . 34
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
. . . . . . . . . . . . . . . . . . . . . . . . . 34
MOTOR-IDLE AIR CONTROL
. . . . . . . . . . . . . . . . . . . . . . . . . 34
. . . . . . . . . . . . . . . . . . . . . . . . . . . 34
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
. . . . . . . . . . . . . . . . . . . . . . . . . 37
SENSOR-INTAKE AIR TEMPERATURE
. . . . . . . . . . . . . . . . . . . . . . . . . 37
. . . . . . . . . . . . . . . . . . . . . . . . . . . 37
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
. . . . . . . . . . . . . . . . . . . . . . . . . 40
SENSOR-MAP
. . . . . . . . . . . . . . . . . . . . . . . . . 40
. . . . . . . . . . . . . . . . . . . . . . . . . . . 41
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
. . . . . . . . . . . . . . . . . . . . . . . . . 44
SENSOR-OXYGEN
. . . . . . . . . . . . . . . . . . . . . . . . . 45
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
. . . . . . . . . . . . . . . . . . . . . . . . . 46
THROTTLE BODY
. . . . . . . . . . . . . . . . . . . . . . . . . 46
. . . . . . . . . . . . . . . . . . . . . . . . . . . 46
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
. . . . . . . . . . . . . . . . . . . . . . . . . 49
CABLE-THROTTLE CONTROL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
. . . . . . . . . . . . . . . . . . . . . . . . . 53
SENSOR-THROTTLE POSITION
. . . . . . . . . . . . . . . . . . . . . . . . . 56
. . . . . . . . . . . . . . . . . . . . . . . . . . . 56
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
. . . . . . . . . . . . . . . . . . . . . . . . . 58
HB
FUEL INJECTION
14 - 25
![](/vehicles/wlang/dowa/rowno/blliedes.png)
PEDAL-ACCELERATOR (EXC. CODE XAP)
REMOVAL
Without APPS
The following procedure applies only to vehicles with-
out the Adjustable Pedal Package (code XAP). It also
applies to vehicles not equipped with an accelerator
pedal position sensor.
The accelerator pedal is serviced as a complete
assembly including the bracket.
The accelerator cable is connected to the upper part
of the accelerator pedal arm by a plastic retainer (clip)
(7). This plastic retainer snaps into the top of the
accelerator pedal arm.
1. From inside the vehicle, hold up accelerator pedal.
Remove plastic cable retainer (clip) (7) and throttle
cable core wire from upper end of accelerator
pedal arm (6). Plastic cable retainer (clip) snaps
into pedal arm.
2. Remove two accelerator pedal mounting bracket
nuts (5). Remove accelerator pedal assembly (4).
With APPS
The following procedure applies only to vehicles with-
out the Adjustable Pedal Package (code XAP). It also
applies to vehicles equipped with an accelerator
pedal position sensor (6).
The accelerator pedal (4) is serviced as a complete
assembly including the bracket.
1. Disconnect electrical connector (1) at APPS (6).
2. Remove two accelerator pedal mounting bracket
nuts (5). Remove accelerator pedal assembly (4).
14 - 26
FUEL INJECTION
HB
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст