Dodge Ram Truck 1500-2500-3500. Manual — part 160
NO SIGNAL FROM RIGHT FRONT SENSOR — 22 (CONTINUED)
For a complete wiring diagram Refer to Section 8W.
•
When Monitored:
Ignition on.
•
Set Condition:
One sensor is unable to reach 4 MPH while the remaining sensors are indicating above 8 MPH.
Possible Causes
INTERMITTENT LEFT FRONT WHEEL SPEED SENSOR DTC
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORT TO GROUND
RIGHT FRONT WHEEL SPEED SENSOR (-) CIRCUIT SHORT TO GROUND
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT OPEN
RIGHT FRONT WHEEL SPEED SENSOR (-) CIRCUIT OPEN
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO VOLTAGE
RIGHT FRONT WHEEL SPEED SENSOR (-) CIRCUIT SHORTED TO VOLTAGE
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO THE RIGHT FRONT WHEEL SPEED
SENSOR (-) CIRCUIT
TONE WHEEL
EXCESSIVE LEFT FRONT WHEEL SPEED SENSOR AIR GAP
WHEEL BEARING
RIGHT FRONT WHEEL SPEED SENSOR
CONTROLLER ANTI-LOCK BRAKE
Diagnostic Test
1.
DTC IS ACTIVE
Turn the ignition on.
With the DRBIII
T
, clear DTCs.
Turn the ignition off.
Turn the ignition on.
With the DRBIII
T
, read DTCs.
Does the DRBIII
T
display the DTC??
Yes
>> Go To 2
No
>> Go To 15
2.
WHEEL SPEED SENSOR INSPECTION
Turn the ignition off.
Inspect the Wheel Speed Sensor for proper mounting.
Inspect the Wheel Speed Sensor harness and connector.
Inspect the Wheel Speed Sensor for excessive debris on the sensor.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 3
5 - 68
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
DR/DH
NO SIGNAL FROM RIGHT FRONT SENSOR — 22 (CONTINUED)
3.
TONE WHEEL DAMAGED/MISSING
Inspect the Tone Wheel in accordance with the Service Information.
NOTE: The Tone Wheel Teeth should be perfectly square, not bent or nicked.
Were any problems found?
Yes
>> Replace the Tone Wheel in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 4
4.
EXCESSIVE WHEEL SPEED SENSOR AIR GAP
Measure the Wheel Speed Sensor Air Gap in accordance with the Service Information.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 5
5.
WHEEL BEARING LOOSE/BINDING
Inspect the wheel bearings for excessive run out or improper clearance in accordance with the Service Information.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 6
6.
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT
SHORTED TO GROUND
Turn the ignition off.
Disconnect the Right Front Wheel Speed Sensor harness connector.
Disconnect the Controller Anti-lock Brake harness connector.
NOTE: Check connector - Clean/repair as necessary.
Measure the resistance between the Right Front Wheel Speed Sensor
(+) circuit and ground.
Is the resistance above 5.0 ohms?
Yes
>> Go To 7
No
>> Repair the Right Front Wheel Speed Sensor (+) circuit for
a short to ground.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
DR/DH
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
5 - 69
NO SIGNAL FROM RIGHT FRONT SENSOR — 22 (CONTINUED)
7.
RIGHT FRONT WHEEL SPEED SENSOR (-) CIRCUIT SHORTED TO GROUND
Measure the resistance between the Right Front Wheel Speed Sensor
(-) circuit and ground.
Is the resistance above 5.0 ohms?
Yes
>> Go To 8
No
>> Repair the Right Front Wheel Speed Sensor (-) circuit for
a short to ground.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
8.
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT OPEN
Measure the resistance of the Right Front Wheel Speed Sensor (+)
circuit.
Is the resistance below 5.0 ohms?
Yes
>> Go To 9
No
>> Repair the open Right Front Wheel Speed Sensor (+) cir-
cuit.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
5 - 70
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
DR/DH
NO SIGNAL FROM RIGHT FRONT SENSOR — 22 (CONTINUED)
9.
RIGHT FRONT WHEEL SPEED SENSOR (-) CIRCUIT OPEN
Measure the resistance of the Right Front Wheel Speed Sensor (-) cir-
cuit.
Is the resistance below 5.0 ohms?
Yes
>> Go To 10
No
>> Repair the open Right Front Wheel Speed Sensor (-) cir-
cuit.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
10.
RIGHT FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO VOLTAGE
Turn the ignition on.
Measure the voltage of the Right Front Wheel Speed Sensor (+) cir-
cuit.
Is there any voltage present?
Yes
>> Repair Right Front Wheel Speed Sensor (+) circuit for a
short to voltage.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
No
>> Go To 11
DR/DH
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
5 - 71
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст