Dodge Ram Truck 1500-2500-3500. Manual — part 163
REAR SENSOR SHORTED — 93
5 - 80
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
DR/DH
REAR SENSOR SHORTED — 93 (CONTINUED)
For a complete wiring diagram Refer to Section 8W.
•
When Monitored:
Ignition on.
•
Set Condition:
The CAB detect high voltage on the wheel speed sensor circuit.
Possible Causes
INTERMITTENT REAR FRONT WHEEL SPEED SENSOR DTC
REAR FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO VOLTAGE
REAR FRONT WHEEL SPEED SENSOR (-) CIRCUIT SHORTED TO VOLTAGE
REAR FRONT WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO THE REAR FRONT WHEEL SPEED
SENSOR (-) CIRCUIT
TONE WHEEL
EXCESSIVE REAR FRONT WHEEL SPEED SENSOR AIR GAP
WHEEL BEARING
REAR FRONT WHEEL SPEED SENSOR
CONTROLLER ANTI-LOCK BRAKE
Diagnostic Test
1.
DTC IS ACTIVE
Turn the ignition on.
With the scan tool, clear DTCs.
Turn the ignition off.
Turn the ignition on.
With the scan tool, read DTCs.
Does the DRBIII
T
display the DTC?
Yes
>> Go To 2
No
>> Go To 11
2.
WHEEL SPEED SENSOR INSPECTION
Turn the ignition off.
Inspect the Wheel Speed Sensor for proper mounting.
Inspect the Wheel Speed Sensor harness and connector.
Inspect the Wheel Speed Sensor for excessive debris on the sensor.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 3
DR/DH
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
5 - 81
REAR SENSOR SHORTED — 93 (CONTINUED)
3.
TONE WHEEL DAMAGED/MISSING
Inspect the Tone Wheel in accordance with the Service Information.
NOTE: The Tone Wheel Teeth should be perfectly square, not bent or nicked.
Were any problems found?
Yes
>> Replace the Tone Wheel in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 4
4.
EXCESSIVE WHEEL SPEED SENSOR AIR GAP
Measure the Wheel Speed Sensor Air Gap in accordance with the Service Information.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 5
5.
WHEEL BEARING LOOSE/BINDING
Inspect the wheel bearings for excessive run out or improper clearance in accordance with the Service Information.
Were any problems found?
Yes
>> Repair as necessary in accordance with the Service Information.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 - BRAKES/ELECTRICAL - DIAGNOSIS AND
TESTING)
No
>> Go To 6
6.
REAR WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO
VOLTAGE
Turn the ignition on.
Measure the voltage of the Rear Wheel Speed Sensor (+) circuit.
Is there any voltage present?
Yes
>> Repair Rear Wheel Speed Sensor (+) circuit for a short to
voltage.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
No
>> Go To 7
5 - 82
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
DR/DH
REAR SENSOR SHORTED — 93 (CONTINUED)
7.
REAR WHEEL SPEED SENSOR (-) CIRCUIT SHORTED TO VOLTAGE
Measure the voltage of the Rear Wheel Speed Sensor (-) circuit.
Is there any voltage present?
Yes
>> Repair the Rear Wheel Speed Sensor (-) circuit for a short
to voltage.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
No
>> Go To 8
8.
REAR WHEEL SPEED SENSOR (+) CIRCUIT SHORTED TO THE Rear WHEEL SPEED SENSOR (-)
CIRCUIT
Turn the ignition off.
Measure the resistance between the Rear Wheel Speed Sensor (+)
circuit and the Rear Wheel Speed Sensor (-) circuit at the Controller
Anti-lock Brake harness connector.
Is the resistance below 5.0 ohms?
Yes
>> Repair Rear Wheel Speed Sensor (+) circuit for a short to
the Rear Wheel Speed Sensor (-) circuit.
Perform ABS VERIFICATION TEST - VER 1. (Refer to 5 -
BRAKES/ELECTRICAL - DIAGNOSIS AND TESTING)
No
>> Go To 9
DR/DH
BRAKES - ABS - ELECTRICAL DIAGNOSTICS
5 - 83
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст