Dodge Ram Truck 1500-2500-3500. Manual — part 598
FCM-WIPER SPEED RELAY OUTPUT CIRCUIT OPEN
8R - 32
WIPERS/WASHERS - ELECTRICAL DIAGNOSTICS
DR/DH
FCM-WIPER SPEED RELAY OUTPUT CIRCUIT OPEN (CONTINUED)
For the Wiper Washer system circuit diagram (Refer to 8 - ELECTRICAL/WIPERS/WASHERS - SCHEMATICS AND
DIAGRAMS).
For a complete wiring diagram Refer to Section 8W.
•
When Monitored:
With the ignition on
•
Set Condition:
The FCM detects an open condition
Possible Causes
WIPER HIGH/LOW RELAY
FRONT CONTROL MODULE
POWER DISTRIBUTION CENTER
1.
INTERMITTENT CONDITION
Turn the ignition on.
With the DRBIII
T
, clear all FCM DTC’s.
Actuate the Wipers in all speed positions.
With the DRBIII
T
, read the DTC information.
Does the DRBIII
T
read: Wiper Speed Relay
Output Circuit Open?
Yes
>> Go To 2
No
>> The condition that caused the symptom
is currently not present. Inspect the
related wiring for a possible intermittent
condition. Look for any chafed, pierced,
pinched, or partially broken wires.
Perform BODY VERIFICATION TEST -
VER 1.
DR/DH
WIPERS/WASHERS - ELECTRICAL DIAGNOSTICS
8R - 33
FCM-WIPER SPEED RELAY OUTPUT CIRCUIT OPEN (CONTINUED)
2.
WIPER HIGH/LOW RELAY
Turn the ignition off.
Install a substitute relay in place of the Wiper High/Low Relay.
Turn the ignition on.
Activate the Wiper Switch to all speed positions.
With the DRBIII
T
, read DTCs.
Does the DRBIII
T
display: Wiper Speed Relay Output Circuit
Open?
Yes
>> Go To 3
No
>> Replace the Wiper High/Low Relay in accordance with the
Service Information.
Perform BODY VERIFICATION TEST - VER 1.
3.
POWER DISTRIBUTION CENTER
Turn the ignition off.
Remove the Wiper High/Low Relay from the IPM.
Remove the FCM from the IPM.
Measure the resistance of the Wiper High/Low Control circuit in the IPM.
Is the resistance above 5.0 ohms?
Yes
>> Replace the Power Distribution Center (PDC ) in accordance with the Service Information.
Perform BODY VERIFICATION TEST - VER 1.
No
>> Replace the Front Control Module (FCM) in accordance with the Service Information.
Perform BODY VERIFICATION TEST - VER 1.
8R - 34
WIPERS/WASHERS - ELECTRICAL DIAGNOSTICS
DR/DH
MIC-WASH-BEAM INPUT CIRCUIT SHORTED
DR/DH
WIPERS/WASHERS - ELECTRICAL DIAGNOSTICS
8R - 35
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст