Infiniti G35 (V35) Sedan. Manual — part 749
HA-30
< ON-VEHICLE MAINTENANCE >
LUBRICANT
ON-VEHICLE MAINTENANCE
LUBRICANT
Adjustment
INFOID:0000000000959861
LUBRICANT RETURN OPERATION
Adjust the lubricant quantity according to the test group shown below.
1.
CHECK LUBRICANT RETURN OPERATION
Can lubricant return operation be performed?
• A/C system works properly.
• There is no evidence of a large amount of lubricant leakage.
CAUTION:
If excessive lubricant leakage is noted, never perform the lubricant return operation.
Is it successful?
YES
>> GO TO 2.
NO
>> GO TO 3.
2.
PERFORM LUBRICANT RETURN OPERATION, PROCEEDING AS FOLLOWS
1.
Start the engine, and set to the following conditions:
-
Engine speed: Idling to 1,200 rpm
-
A/C switch: ON
-
Blower speed: Max. position
-
Temp. control: Optional [Set so that intake air temperature is 25 to 30
°
C (77 to 86
°
F).]
-
Intake position: Recirculation (REC)
2.
Perform lubricant return operation for about 10 minutes.
3.
Stop the engine.
>> GO TO 3.
3.
CHECK REPLACEMENT PART
Should the compressor be replaced?
YES
>> Refer to "LUBRICANT ADJUSTING PROCEDURE FOR COMPRESSOR REPLACEMENT".
NO
>> Refer to "LUBRICANT ADJUSTING PROCEDURE FOR COMPONENTS REPLACEMENT
EXCEPT COMPRESSOR".
LUBRICANT ADJUSTING PROCEDURE FOR COMPONENTS REPLACEMENT EXCEPT COM-
PRESSOR
After replacing any of the following major components, add the correct amount of lubricant to the system.
Amount of lubricant to be added:
*1: If the refrigerant leak is small, no addition of lubricant is needed.
LUBRICANT ADJUSTING PROCEDURE FOR COMPRESSOR REPLACEMENT
Part replaced
Lubricant to be added to system
Remarks
Amount of lubricant
m
(US fl oz., Imp fl oz.)
Evaporator
75 (2.5, 2.6)
—
Condenser
35 (1.2, 1.2)
—
Liquid tank
10 (0.3, 0.4)
—
In case of refrigerant leak
30 (1.0, 1.1)
Large leak
—
Small leak
*1
LUBRICANT
HA-31
< ON-VEHICLE MAINTENANCE >
C
D
E
F
G
H
J
K
L
M
A
B
HA
N
O
P
1.
Before connecting recovery/recycling recharging equipment to vehicle, check recovery/recycling recharg-
ing equipment gauges. No refrigerant pressure should be displayed. If NG, recover refrigerant from equip-
ment lines.
2.
Connect recovery/recycling recharging equipment to vehicle. Confirm refrigerant purity in supply tank
using recovery/recycling recharging equipment and refrigerant identifier. If NG, refer to
.
3.
Confirm refrigerant purity in vehicle A/C system using recovery/recycling recharging equipment and refrig-
erant identifier. If NG, refer to
HA-16, "Working with HFC-134a (R-134a)"
.
4.
Discharge refrigerant into the refrigerant recovery/recycling equipment. Measure lubricant discharged into
the recovery/recycling equipment.
5.
Drain the lubricant from the old (removed) compressor into a graduated container and recover the amount
of lubricant drained.
6.
Drain the lubricant from the new compressor into a separate, clean container.
7.
Measure an amount of new lubricant installed equal to amount drained from old compressor. Add this
lubricant to new compressor through the suction port opening.
8.
Measure an amount of new lubricant equal to the amount recovered during discharging. Add this lubricant
to new compressor through the suction port opening.
9.
If the liquid tank also needs to be replaced, add another 5 m (0.2 US fl oz., 0.2 Imp fl oz.) of lubricant at
this time.
Do not add this 5 m (0.2 US fl oz., 0.2 Imp fl oz.) of lubricant when replaces the compressor only.
RJIA3578E
HA-32
< ON-VEHICLE MAINTENANCE >
REFRIGERATION SYSTEM
REFRIGERATION SYSTEM
Inspection
INFOID:0000000000959862
PERFORMANCE TEST DIAGNOSIS
*1
"PERFORMANCE CHART" in
*2
*3
HA-11, "BOTH HIGH- AND LOW-
PRESSURE SIDES ARE TOO HIGH
: Symptom Table"
*4
HA-11, "HIGH-PRESSURE SIDE IS
TOO HIGH AND LOW-PRESSURE
SIDE IS TOO LOW : Symptom Table"
*5
HA-12, "HIGH-PRESSURE SIDE IS
TOO LOW AND LOW-PRESSURE
SIDE IS TOO HIGH : Symptom Ta-
ble"
*6
HA-12, "BOTH HIGH- AND LOW-
PRESSURE SIDES ARE TOO LOW
: Symptom Table"
*7
HA-13, "LOW-PRESSURE SIDE
SOMETIMES BECOMES NEGA-
TIVE : Symptom Table"
*8
HA-14, "LOW-PRESSURE SIDE BE-
COMES NEGATIVE : Symptom Ta-
ble"
JSIIA0130GB
REFRIGERATION SYSTEM
HA-33
< ON-VEHICLE MAINTENANCE >
C
D
E
F
G
H
J
K
L
M
A
B
HA
N
O
P
Performance Chart
INFOID:0000000000959863
TEST CONDITION
*1
*2
*3
SJIA1642E
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст