Infiniti G35 (V35) Sedan. Manual — part 600
EC-546
< ON-VEHICLE REPAIR >
[VQ35HR]
EVAP CANISTER
ON-VEHICLE REPAIR
EVAP CANISTER
Exploded View
INFOID:0000000000956916
Removal and Installation
INFOID:0000000000956917
REMOVAL
1.
Lift up the vehicle.
2.
Remove EVAP canister fixing bolt.
3.
Remove EVAP canister.
NOTE:
The EVAP canister vent control valve and EVAP canister system pressure sensor can be removed without
removing the EVAP canister.
INSTALLATION
Install in the reverse order of removal.
NOTE:
Tighten EVAP canister fixing bolt to the specified torque.
DISASSEMBLY
1.
Turn EVAP canister vent control valve counterclockwise.
2.
Remove the EVAP canister vent control valve.
1.
EVAP canister system pressure sen-
sor
2.
O-ring
3.
EVAP canister
4.
O-ring
5.
EVAP canister vent control valve
Refer to
for symbols not described on the above.
JMBIA0049GB
A
: Lock
B
: Unlock
PBIB2730E
EVAP CANISTER
EC-547
< ON-VEHICLE REPAIR >
[VQ35HR]
C
D
E
F
G
H
I
J
K
L
M
A
EC
N
P
O
ASSEMBLY
Assemble in the reverse order of disassembly.
CAUTION:
Always replace O-ring with a new one.
Inspection
INFOID:0000000000956918
Check EVAP canister as follows:
1.
Block port (B).
2.
Blow air into port (A) and check that it flows freely out of port (C).
3.
Release blocked port (B).
4.
Apply vacuum pressure to port (B) and check that vacuum pres-
sure exists at the ports (A) and (C).
5.
Block port (A) and (B).
6.
Apply pressure to port (C) and check that there is no leakage.
PBIB2728E
EM-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
EM
A
EM
N
O
P
CONTENTS
ENGINE MECHANICAL
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting - Engine Noise . . . . ....
Use the Chart Below to Help You Find the C
ause of the Symptom . . . . . . . . . . . ..
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
. ..
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . .....
Draining Engine Coolant . . . . . . . . . . ..
Disconnecting Fuel Piping . . . . . . . . . ...
Removal and Disassembly . . . . . . . . . ..
Inspection, Repair and Replacement . . . . . ..
Assembly and Installation . . . . . . . . . ....
Parts Requiring Angle Tightening . . . . . . ...
Liquid Gasket . . . . . . . . . . . . . . ...
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tools . . . . . . . . . . . ..
Commercial Service Tools . . . . . . . . . ...
ON-VEHICLE MAINTENANCE . . . . .
DRIVE BELTS . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Checking . . . . . . . . . . . . . . . . .
Tension Adjustment . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . ..
Removal and Installation . . . . . . . . . . .
SPARK PLUG . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
CAMSHAFT VALVE CLEARANCE . . . . ..
Inspection and Adjustment . . . . . . . . . ..
COMPRESSION PRESSURE . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
ON-VEHICLE REPAIR . . . . . . . . .
DRIVE BELT AUTO TENSIONER AND IDLER
PULLEY . . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
AIR CLEANER AND AIR DUCT . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
INTAKE MANIFOLD COLLECTOR . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
INTAKE MANIFOLD . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
EXHAUST MANIFOLD . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
FUEL INJECTOR AND FUEL TUBE . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
OIL PAN (LOWER) . . . . . . . . . . ...
Exploded View (2WD) . . . . . . . . . . . .
EM-2
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
IGNITION COIL, SPARK PLUG AND ROCK-
ER COVER . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
TIMING CHAIN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
CAMSHAFT . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
OIL SEAL . . . . . . . . . . . . . . ...
VALVE OIL SEAL . . . . . . . . . . . . . .
VALVE OIL SEAL : Removal and Installation . . .
FRONT OIL SEAL . . . . . . . . . . . . . .
FRONT OIL SEAL : Removal and Installation . ....
REAR OIL SEAL . . . . . . . . . . . . . ...
REAR OIL SEAL : Removal and Installation . . ..
REMOVAL AND INSTALLATION . . . ...
ENGINE ASSEMBLY . . . . . . . . . . .
2WD . . . . . . . . . . . . . . . . . . ...
2WD : Exploded View . . . . . . . . . . . .
2WD : Removal and Installation . . . . . . . .
2WD : Inspection . . . . . . . . . . . . ....
AWD . . . . . . . . . . . . . . . . . . ..
AWD : Exploded View . . . . . . . . . . ....
AWD : Removal and Installation . . . . . . . .
AWD : Inspection . . . . . . . . . . . . ....
DISASSEMBLY AND ASSEMBLY . . . .
ENGINE STAND SETTING . . . . . . . .
Setting . . . . . . . . . . . . . . . . ....
ENGINE UNIT . . . . . . . . . . . . .
Disassembly . . . . . . . . . . . . . . ...
Assembly . . . . . . . . . . . . . . . ....
REAR TIMING CHAIN CASE . . . . . . .
Exploded View . . . . . . . . . . . . . .
Disassembly . . . . . . . . . . . . . . .
Assembly . . . . . . . . . . . . . . . .
OIL PAN (UPPER) AND OIL STRAINER . . ..
2WD . . . . . . . . . . . . . . . . . . ...
2WD : Exploded View . . . . . . . . . . . .
2WD : Disassembly and Assembly . . . . . . .
2WD : Inspection . . . . . . . . . . . . . .
AWD . . . . . . . . . . . . . . . . . . ..
AWD : Exploded View . . . . . . . . . . . .
AWD : Disassembly and Assembly . . . . . . .
AWD : Inspection . . . . . . . . . . . . ..
CYLINDER HEAD . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
CYLINDER BLOCK . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ..
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
HOW TO SELECT PISTON AND BEARING ...
Description . . . . . . . . . . . . . . .
Piston . . . . . . . . . . . . . . . . .
Connecting Rod Bearing . . . . . . . . . .
Main Bearing . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . .
General Specification . . . . . . . . . . ...
Drive Belt . . . . . . . . . . . . . . . ..
Spark Plug . . . . . . . . . . . . . . .
Intake Manifold . . . . . . . . . . . . . ..
Exhaust Manifold . . . . . . . . . . . . ..
Camshaft . . . . . . . . . . . . . . . ...
Cylinder Head . . . . . . . . . . . . . ..
Cylinder Block . . . . . . . . . . . . . ..
Main Bearing . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст