Volkswagen Golf / Golf GTI / Jetta. Manual — part 344
01-38
V.A.G 1551
print-out
Possible cause
Repair
00283
Left front ABS
wheel speed
sensor -G47-
Signal outside
tolerances
1)
Open circuit, short to positive or
Ground, or loose contact in
connections between left front
ABS wheel speed sensor -G47-
and ABS Control Module (w/EDL)
-J104-
- Check wiring and
connections using wiring
diagram
- Perform electrical checks
from
Page 01-102
Electrical interference from other
sources (high frequency radiation
e.g. non-insulated ignition cable)
- Read measured value
block
Page 01-61
Display group number 001
Damaged rotor or left front ABS
wheel speed sensor -G47-
Excessive air gap between left
front ABS wheel speed sensor-
G47- and rotor (signal not OK.)
Repair Manual, Brake
System, Repair Group 45;
Removing and installing
parts of ABS system on front
and rear axles
- Check left front ABS
wheel speed sensor -G47-
and rotor for damage
- Replace rotor/speed
sensor
1)
Type of DTC, this DTC is only recognized above 20 km/h (13 mph) (carry out test
drive).
ABS ITT Mk 20 IE On Board Diagnostic (OBD) program
01-39
V.A.G 1551
print-out
Possible cause
Repair
00283
Left front ABS
wheel speed
sensor -G47-
Mechanical
malfunction
1)
Excessive air gap
between left front ABS
wheel speed sensor -
G47- and rotor (signal
not OK.)
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on front
and rear axles
- Check installation of left front ABS
wheel speed sensor -G47- and rotor
- Read measured value block
Page
01-61
Display group number 002
- Perform output Diagnostic Test
Mode (DTM)
Page 01-74
If the malfunction occurs again:
Outlet valve in ABS
hydraulic unit -N55-
faulty
Repair Manual, Brake System,
Repair Group 45; Hydraulic unit, brake
booster/brake master cylinder -
Assembly overview; Removing and
installing control module and hydraulic
unit
- Replace ABS hydraulic unit -N55-
1)
Type of DTC, this DTC is only recognized above 20 km/h (13 mph) (carry out test
drive).
ABS ITT Mk 20 IE On Board Diagnostic (OBD) program
01-40
V.A.G
1551 print-
out
Possible cause
Repair
00285
Right front
ABS wheel
speed
sensor -
G45-
Open circuit, short to positive or
Ground, or loose contact in
connections between right front
ABS wheel speed sensor -G45-
and ABS Control Module
(w/EDL) -J104-
- Check wiring and connections
using wiring diagram
- Perform electrical checks
from
Page 01-102
Damaged rotor or speed sensor
-G45
Speed sensor windings -G45-
faulty
Repair Manual, Brake System,
Repair Group 45; Removing and
installing parts of ABS system on
front and rear axles
- Check right front ABS wheel
speed sensor -G45- and rotor for
damage
- Replace rotor/right front ABS
wheel speed sensor -G45-
If the malfunction occurs again:
ABS Control Module (w/EDL) -
J104- faulty
Repair Manual, Brake System,
Repair Group 45; Hydraulic unit,
brake booster/brake master cylinder
- Assembly overview; Removing
and installing control module and
hydraulic unit
- Replace ABS Control Module
(w/EDL) -J104-
ABS ITT Mk 20 IE On Board Diagnostic (OBD) program
01-41
V.A.G 1551
print-out
Possible cause
Repair
00285
Right front ABS
wheel speed
sensor -G45-
Signal outside
tolerances
1)
Open circuit, short to positive or
Ground, or loose contact in
connections between right front
ABS wheel speed sensor -G45-
and ABS Control Module (w/EDL)
-J104-
- Check wiring and
connections using wiring
diagram
- Perform electrical checks
from
Page 01-102
Electrical interference from other
sources (high frequency radiation
e.g. non-insulated ignition cable)
- Read measured value
block
Page 01-61
Display group number 001
Damaged rotor or right front ABS
wheel speed sensor -G45-
Excessive air gap between right
front ABS wheel speed sensor-
G45- and rotor (signal not OK)
Repair Manual, Brake
System, Repair Group 45;
Removing and installing
parts of ABS system on
front and rear axles
- Check right front ABS
wheel speed sensor -G45-
and rotor for damage
- Replace rotor/speed
sensor
1)
Type of DTC, this DTC is only recognized above 20 km/h (13 mph) (carry out test
drive).
ABS ITT Mk 20 IE On Board Diagnostic (OBD) program
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст