Volkswagen Golf / Golf GTI / Golf Variant. Manual — part 29
– Slide the headlamp into the bumper cover guide.
– Uniformly adjust the headlamp gap distribution. Refer to
⇒ “1.4 Headlamp Installation Position, Correcting”,
.
– Push on the bumper cover -1-. Pay attention that it is pushed
in the mounts -2- under the headlamp.
– Perform a function test.
– Check and correct headlamp adjustment, if necessary. Refer
to ⇒ Maintenance ; Booklet 36.1 ; Procedure Descriptions .
Tightening Specifications
♦ Refer to
⇒ “1.1 Overview - Headlamp”, page 92
1.3
Headlamp, Adjusting
1.3.1
Halogen Twin Headlamp, Adjusting
Adjusting the halogen twin headlamp. Refer to ⇒ Maintenance ;
Booklet 36.1 ; Procedure Descriptions .
1.3.2
HID Headlamp, Adjusting
HID headlamp, adjusting. Refer to ⇒ Maintenance ; Booklet 36.1 ;
Procedure Descriptions .
1.3.3
Fog Lamp, Adjusting
Adjusting the fog lamps. Refer to ⇒ Maintenance ; Booklet 36.1 ;
Procedure Descriptions .
1.3.4
Auxiliary Headlamps, Adjusting
Retrofitted auxiliary headlamps must be checked and adjusted
according to the guidelines used for other systems.
1.4
Headlamp Installation Position, Correcting
Procedure
– Loosen the bolts -3 through 6-.
– Uniformly adjust the gap distribution of the headlamp -1- to the
fender.
– Tighten the bolts -5 and 6-.
– Close the hood.
– Uniformly adjust the gap distribution of the banjo bolt for the
bolt -3- and the impact screw -2-.
– Open the hood.
– Tighten the bolt -3- in the bolt.
– Tighten the bolt -4-.
– Perform a function test.
– Check and correct headlamp adjustment, if necessary. Refer
to ⇒ Maintenance ; Booklet 36.1 ; Procedure Descriptions .
Tightening Specifications
1.5
Left/Right Front Turn Signal Bulb -M5- /
-M7- , Removing and Installing
⇒ “1.5.1 Left/Right Front Turn Signal Bulb M5 / M7 , Removing
and Installing, Halogen Dual Headlamp”, page 107
⇒ “1.5.2 Left/Right Front Turn Signal Bulb M5 / M7 , Removing
and Installing, HID Headlamps”, page 108
1.5.1
Left/Right Front Turn Signal Bulb -M5- /
-M7- , Removing and Installing, Halogen
Dual Headlamp
The removal and installation is described for the left side. Re‐
moving and installing on the right side is identical.
Removing
– Turn off the ignition and all electrical equipment.
– Remove the ignition key, if equipped.
– Remove the housing cover -1- from the headlamp.
– Remove the socket with bulb socket -1- from the reflector -2-
in the direction of the -arrow A-.
– Remove the Left Front Turn Signal Bulb - M5- -2- from the
socket -1-.
Installing
Install in the reverse order of removal while paying attention to
the following:
Caution
There is a risk of damaging the headlamp.
♦ Do not touch glass cone of bulb with bare fingers. Fingers
will leave traces of grease on the glass which, when the
bulb is switched on, will evaporate and cloud the glass.
♦ Use clean cloth gloves to insert the bulbs.
♦ During installation, ensure proper seating of the housing
cover. Water getting in the headlamp will cause damage.
– Perform a function test.
– Check and correct headlamp adjustment, if necessary. Refer
to ⇒ Maintenance ; Booklet 36.1 ; Procedure Descriptions .
1.5.2
Left/Right Front Turn Signal Bulb -M5- /
-M7- , Removing and Installing, HID
Headlamps
The removal and installation is described for the left side. Re‐
moving and installing on the right side is identical.
Removing
– Turn off the ignition and all electrical equipment.
– Remove the ignition key, if equipped.
If the left turn signal bulb cannot be removed as described, then
the air filter housing must be removed. Refer to ⇒ Rep. Gr. 23 ;
Air Filter; Air Filter Housing, Removing and Installing or ⇒ Rep.
Gr. 24 ; Air Filter; Air Filter Housing, Removing and Installing .
Vehicles with TDI Engine
If the right turn signal bulb cannot be removed as described, then
the fuel filter must be loosened. The fuel filter is set aside with the
wires connected. Refer to ⇒ Rep. Gr. 20 ; Fuel Filter; Fuel Filter,
Removing and Installing .
All Vehicles
– Turn the housing cover -1- in the direction of -arrow A- and
remove from the headlamp.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст