Volkswagen Touareg (2003 year). Manual — part 25
• Fuses -13- and -14- -arrow- must be removed from their sock‐
ets.
Procedure
WARNING
Fuel supply lines are under pressure! Wear eye protection and
gloves to avoid injuries and skin contact. Before loosening
hose connections, wrap a cloth around the connection. Then
release pressure by carefully pulling hose off connection.
.
Observe rules for cleanliness
– Cut open carpet on left side from point -A- to -B- in the pre-cut
area -arrows-.
– Remove nuts -1- from cover. If necessary, unscrew backrest
mounting -2- or support mounting ⇒ General body repairs,
interior; Rep. gr. 72 ; Rear seats .
– Unscrew locking ring from left flange using wrench -T10202- .
– Completely remove flange on left side of tank.
– Empty fuel filter housing.
– Mark installation position of filter cover -2- using coloured felt
tip marker pen.
– Pull off earth wire -1- and unscrew filter cover -arrows- from
housing.
If filter element is changed, ensure that earth connection contacts
are not bent and have sufficient preloading.
Touareg 2003 ➤
1. Parts of fuel supply system
97
1.4
Schematic diagram of fuel lines and
components in fuel tank
-A- left side of fuel tank
-Arrow- points in direction of travel
-B- Right side of tank
1 - Gravity valve
❑ Left side.
2 - Flange
❑ Left side.
3 - Fuel filter
4 - Gravity valve
❑ Right side.
5 - Supply line
❑ To fuel rail.
6 - Supply line for auxiliary
heater
7 - Flange
❑ Right side.
8 - Fuel pressure regulator
9 - Return line
❑ From fuel pressure reg‐
ulator
❑ To fuel delivery unit on
left and right sides
10 - Supply line for suction-jet
pumps
11 - Fuel delivery unit
❑ Right side.
12 - Suction-jet pump
❑ Right side.
13 - Delivery line
❑ Black
❑ To fuel delivery unit on
left side.
14 - Delivery line
❑ Black
Touareg 2003 ➤
98
15 - Suction-jet pump
❑ Left side.
16 - Fuel delivery unit
❑ Left side.
Installation position of fuel delivery unit flange
Insert left or right flange with marking -arrow- in direction of travel.
1.5
Safety precautions when working on
fuel supply system
Caution
When doing any repair work, especially in the engine compart‐
ment, pay attention to the following due to the cramped condi‐
tions:
♦ Route all the various lines (e.g. for fuel, hydraulics, acti‐
vated charcoal filter system, coolant, refrigerant, brake
fluid and vacuum) and electrical wiring in their original po‐
sitions.
♦ To avoid damage to lines, ensure sufficient clearance to
all moving or hot components.
♦ For safety reasons, fuse nos. -13- and -14- -arrows- must be
removed from the fuse holder before opening the fuel system.
Otherwise, the fuel pump could be activated by the driver's
door contact switch.
♦ Fuse nos. 13 and 14 are located in the E-box fuse holder in
the left plenum chamber.
When removing and installing fuel gauge sender or fuel pump
(fuel delivery unit) from a full or partly full fuel tank, observe the
following:
♦ Even before work commences, the extraction hose of an ac‐
tivated fume extraction system has to be placed in the vicinity
of the assembly opening of the fuel tank to trap any escaping
fumes. If no exhaust gas extraction system is available, a ra‐
dial fan with a displacement greater than 15 m
3
/h can be used
providing that motor is not in air flow.
♦ Prevent skin contact with fuel! Wear fuel-resistant gloves!
1.6
Rules for cleanliness
When working on the fuel supply and injection system, pay careful
attention to the following „5 rules“ for cleanliness:
Touareg 2003 ➤
1. Parts of fuel supply system
99
connecting.
♦ Place removed parts on a clean surface and cover. Use only
lint-free cloths.
♦ Carefully cover opened components or seal if repairs cannot
be carried out immediately.
♦ Install clean components only. Do not remove replacement
parts from packing until immediately before installing. Do not
use parts that have not been stored in their packing (e.g. in
tool boxes etc.).
♦ When system is open: do not work with compressed air if this
can be avoided. Do not move vehicle unless absolutely nec‐
essary.
1.7
Emptying fuel tank
Special tools and workshop equipment required
♦ Fuel extractor -VAS 5190-
♦ Special wrench -T10202-
WARNING
Fuel supply lines are under pressure! Wear eye protection and
gloves to avoid injuries and skin contact. Before loosening
hose connections, wrap a cloth around the connection. Then
release pressure by carefully pulling hose off connection.
Procedure
– Note safety precautions before beginning work
– Open fuel tank filler flap.
Touareg 2003 ➤
100
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст