Kia Sedona (2008 year). Instruction — part 265
09853-31000
Headliner clip remover
Removal of the headliner clips
09861-31100
Sealant cut-out tool
Cutting the sealant of the
windshield
(Use with 09861-31200)
09861-31200
Sealant cutting blade
Cutting the sealant of the
windshield
(Use with 09861-31100)
09861-31300
Sealant gun
Application of the sealant to the
windshield
2008 Kia Sedona EX
2008 ACCESSORIES & BODY, CAB Body (Interior & Exterior) - General - Sedona
Microsoft
Monday, May 24, 2010 4:05:08 PM
Page 3
© 2006 Mitchell Repair Information Company, LLC.
TROUBLESHOOTING
TROUBLESHOOTING CHART
09681-31400
Glass holder
Removal and installation of the
windshield
09681-31000
Windshield molding remover
Removal of the windshield
molding
09880-4F000
Hog ring clip installer
Installation of the hog ring clip
Symptom
Suspect Area
Remedy
2008 Kia Sedona EX
2008 ACCESSORIES & BODY, CAB Body (Interior & Exterior) - General - Sedona
Microsoft
Monday, May 24, 2010 4:05:08 PM
Page 4
© 2006 Mitchell Repair Information Company, LLC.
Water leaks from sunroof
Dirt accumulated in drain tube
Clear dirt inside of drain
Clogged drain tube
Blow air into drain to remove dirt
Broken or dislocated drain tube,
defective
Or cracked clip
Check tube installation and Flange
contact
Deteriorated roof lid weatherstrip Replace
Excessive roof lid-to-body
clearance and Improperly fitted
weatherstrip
Adjust
Wind noise around sunroof
Loose or deformed deflector, gaps
In body work
Retighten adjust or replace
Sunroof lid makes a noise when
moving
Foreign particles lodged in guide
rail
Check drive cable and guide Rails
for foreign particles
Loose guide rails and lid
Retighten
Motor runs but sunroof does not
move or moves only partially
Foreign particles lodged in guide
rail
Check drive cable and guide Rails
for foreign particles
Incorrect engagement of motor
pinion With drive cable
Check for loose motor installation
And damaged pinion
Decrease in motor's clutch slipping
force
Adjust
Increased sunroof sliding
resistance Or interference of
sunroof with drive cables,
weatherstrip, etc. due to
maladjustment of sunroof
Adjust or replace
Noise in motor (clutch slipping
Noise from motor when sunroof Is
fully opened or closed is not An
unusual noise)
Incorrect engagement of motor
pinion With drive cable
Check pinion installation and
Retighten motor
Worn out or damaged motor
pinion bearing
Replace motor assembly
Worn out or deformed drive cable Replace
Door glass fails to operate Up and
down
Incorrect window glass installation Adjust position
Damaged or faulty regulator arm
or regulator
Correct or replace
Door does not open or close
completely
Incorrect door installation
Adjust position
Defective door check assembly
Correct or replace
Door hinge requires grease
Apply grease
Hood does not open or close
completely
Striker and latch not properly
aligned
Adjust
Incorrectly installed hood
Adjust
Incorrect hood bumper height
Adjust
Water leak through windshield
end rear window
Defective seal
Fill with sealant
Defective flange
Correct
2008 Kia Sedona EX
2008 ACCESSORIES & BODY, CAB Body (Interior & Exterior) - General - Sedona
Microsoft
Monday, May 24, 2010 4:05:08 PM
Page 5
© 2006 Mitchell Repair Information Company, LLC.
2008 BRAKES
Brake System - General - Sedona
SPECIFICATIONS
BRAKE SYSTEM SPECIFICATIONS
Item
Specification
Master cylinder
Type
Tandem type
I.D. mm (in)
26.99/(1.063)
Piston stroke mm (in)
30 (1.18)
Fluid level warning sensor
Provided
Brake booster
Type
8 + 9 in Tandem
Boosting ratio
9.0: 1
Front brake (Disc)
Type
Floating type with ventilated disc
Disc O.D.
298 mm (11.73 in)
Disc thickness
28 mm (1.10 in)
Pad thickness
10.5 mm (0.41 in)
Cylinder type
Double piston
Cylinder I.D.
Ø48 mm (Ø1.89 in)
Rear Brake (Disc)
Type
Floating type with solid disc
Disc O.D.
302 mm (11.89 in)
Disc thickness
12 mm (0.47 in)
Pad thickness
10 mm (0.39 in)
Cylinder type
Single piston
Cylinder I.D
Ø42.9 mm (Ø1.69 in)
Parking Brake
Type
DIH (Drum in hat)
Actuation
Foot brake
Drum
Ø190 mm (Ø7.48 in)
O.D=Outer Diameter
I.D=Inner Diameter
2008 Kia Sedona
2008 BRAKES Brake System - General - Sedona
2008 Kia Sedona
2008 BRAKES Brake System - General - Sedona
Microsoft
Saturday, May 22, 2010 6:55:01 PM
Page 1
© 2006 Mitchell Repair Information Company, LLC.
Microsoft
Saturday, May 22, 2010 6:55:04 PM
Page 1
© 2006 Mitchell Repair Information Company, LLC.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст