Chevrolet Silverado / GMC Sierra. Service manual — part 1224
Fig. 3: Ignition Secondary Trouble Shooting Chart
NOTE:
This is GENERAL information. This article is not intended to be
specific to any unique situation or individual vehicle configuration.
The purpose of this Trouble Shooting information is to provide a list
of common causes to problem symptoms. For model-specific
Trouble Shooting, refer to SUBJECT, DIAGNOSTIC, or TESTING
articles available in the section(s) you are accessing.
2008 Chevrolet Silverado 1500
GENERAL INFORMATION Trouble Shooting - Basic Procedures
2008 Chevrolet Silverado 1500
GENERAL INFORMATION Trouble Shooting - Basic Procedures
Fig. 4: Ignition Primary Trouble Shooting Chart
STARTER TROUBLE SHOOTING
BASIC STARTER TROUBLE SHOOTING CHART
NOTE:
This is GENERAL information. This article is not intended to be
specific to any unique situation or individual vehicle configuration.
The purpose of this Trouble Shooting information is to provide a list
of common causes to problem symptoms. For model-specific
Trouble Shooting, refer to SUBJECT, DIAGNOSTIC, or TESTING
articles available in the section(s) you are accessing.
CONDITION & POSSIBLE CAUSE
CORRECTION
Starter Fails to Operate
Dead battery or bad connections between starter and battery
Check battery charge and
all wires and connections
to starter
Ignition switch faulty or misadjusted
Adjust or replace ignition
switch
Open circuit between starter switch ignition terminal on
starter relay
Check and repair wires
and connections as
necessary
Starter relay or starter defective
See Testing in STARTER
article
Open solenoid pull-in wire
See Testing in STARTER
article
Starter Does Not Operate and Headlights Dim
Weak battery or dead cell
Charge or replace battery
as necessary
Loose or corroded battery connections
Check that battery
connections are clean and
tight
Internal ground in starter windings
See Testing in STARTER
article
Grounded starter fields
See Testing in
STARTERS
Armature rubbing on pole shoes
See STARTER article
Starter Turns but Engine Does Not Rotate
2008 Chevrolet Silverado 1500
GENERAL INFORMATION Trouble Shooting - Basic Procedures
Starter clutch slipping
See STARTER article
Broken clutch housing
See STARTER article
Pinion shaft rusted or dry
See STARTER article
Engine basic timing incorrect
See Ignition Timing in
TUNE-UP article
Broken teeth on engine flywheel
Replace flywheel and
check for starter pinion
gear damage
Starter Will Not Crank Engine
Faulty overrunning clutch
See STARTER article
Broken clutch housing
See STARTER article
Broken flywheel teeth
Replace flywheel and
check for starter pinion
gear damage
Armature shaft sheared or reduction gear teeth stripped
See STARTER article
Weak battery
Charge or replace battery
as necessary
Faulty solenoid
See On-Vehicle Tests in
STARTER article
Poor grounds
Check all ground
connections for tight and
clean connections
Ignition switch faulty or misadjusted
Adjust or replace ignition
switch as necessary
Starter Cranks Engine Slowly
Battery weak or defective
Charge or replace battery
as necessary
Engine overheated
See ENGINE COOLING
SYSTEM article
Engine oil too heavy
Check that proper
viscosity oil is used
Poor battery-to-starter connections
Check that all between
battery and starter are
clean and tight
Current draw too low or too high
See Bench Tests in
STARTER article
Bent armature, loose pole shoes screws or worn bearings
See STARTER article
2008 Chevrolet Silverado 1500
GENERAL INFORMATION Trouble Shooting - Basic Procedures
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст