Nissan Teana J32. Instruction — part 1203
TM-336
< DISASSEMBLY AND ASSEMBLY >
[CVT: RE0F10A]
TORQUE CONVERTER AND CONVERTER HOUSING OIL SEAL
Unit: mm (in)
NOTE:
Converter housing oil seal pulling direction is used as the refer-
ence.
• After completing installation, check for CVT fluid leakage and CVT
fluid level. Refer to
• Attach the pawl (A) of the torque converter to the drive sprocket
hole (B) on the transaxle assembly side.
CAUTION:
• Rotate the torque converter for installing torque converter.
• Never damage the bushing inside the torque converter
sleeve when installing the converter housing oil seal.
• Never reuse converter housing oil seal.
• Apply CVT fluid to converter housing oil seal.
Inspection
INFOID:0000000003806560
INSPECTION AFTER INSTALLATION
• After inserting a torque converter to the CVT, check distance (A)
within the reference value limit.
Dimension B
1.0
±
0.5 (0.039
±
0.020)
SCIA7909J
SCIA7907J
B
: Scale
C
: Straightedge
Distance A
: Refer to
.
JPDIA0740ZZ
SERVICE DATA AND SPECIFICATIONS (SDS)
TM-337
< SERVICE DATA AND SPECIFICATIONS (SDS)
[CVT: RE0F10A]
C
E
F
G
H
I
J
K
L
M
A
B
TM
N
O
P
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
General Specification
INFOID:0000000003806561
*: Refer to
MA-11, "Fluids and Lubricants"
.
Vehicle Speed When Shifting Gears
INFOID:0000000003806562
Numerical value data are reference values.
(rpm)
CAUTION:
Lock-up clutch is engaged when vehicle speed is approximately 18 km/h (11 MPH) to 90 km/h (56 MPH).
Stall Speed
INFOID:0000000003806563
Line Pressure
INFOID:0000000003806564
kPa (bar, kg/cm
2
, psi)
*: Reference values
Applied model
VQ25DE
CVT model
RE0F10A
CVT assembly
Model code number
1XF8E
Transmission gear ratio
D range
2.349 – 0.394
Reverse
1.750
Final drive
6.120
Recommended fluid
NISSAN CVT Fluid NS-2*
Fluid capacity
8.3 liter (7-1/4 Imp qt)
CAUTION:
• Use only Genuine NISSAN CVT Fluid NS-2. Never mix with other fluid.
• Using CVT fluid other than Genuine NISSAN CVT Fluid NS-2 will deteriorate in driveability and CVT durability, and may dam-
age the CVT, which is not covered by the warranty.
Throttle position
Shift pattern
Engine speed
At 40 km/h (25 MPH)
At 60 km/h (37 MPH)
8/8
“D” position
3,500 – 4,400
4,700 – 5,600
Sport mode
3,500 – 4,400
4,700 – 5,600
“L” position
3,500 – 4,400
4,700 – 5,600
2/8
“D” position
1,300 – 3,100
1,400 – 3,400
Sport mode
2,200 – 3,000
2,800 – 3,600
“L” position
3,300 – 4,200
4,200 – 5,000
Stall speed
2,500 – 2,970 rpm
Engine speed
Line pressure
“R”, “D” positions
At idle
750 (7.50, 7.65, 108.8)
At stall
5,700 (57.00, 58.14, 826.5)
*
TM-338
< SERVICE DATA AND SPECIFICATIONS (SDS)
[CVT: RE0F10A]
SERVICE DATA AND SPECIFICATIONS (SDS)
Solenoid Valves
INFOID:0000000003806565
CVT Fluid Temperature Sensor
INFOID:0000000003806566
Primary Speed Sensor
INFOID:0000000003806567
Secondary Speed Sensor
INFOID:0000000003806568
Step Motor
INFOID:0000000003900491
Torque Converter
INFOID:0000000003806569
Name
Resistance (Approx.)
Pressure control solenoid valve B (secondary pressure solenoid valve)
3.0 – 9.0
Ω
Pressure control solenoid valve A (line pressure solenoid valve)
Torque converter clutch solenoid valve
Lock-up select solenoid valve
17.0 – 38.0
Ω
Name
Condition
CONSULT-III “Data Monitor” (Approx.)
Resistance (Approx.)
CVT fluid temperature sensor
20
°
C (68
°
F)
2.0 V
6.5 k
Ω
80
°
C (176
°
F)
1.0 V
0.9 k
Ω
Name
Condition
Data (Approx.)
Primary speed sensor
When driving [“L” position, 20 km/h (12 MPH)]
950 Hz
Name
Condition
Data (Approx.)
Secondary speed sensor
When driving [“D” position, 20 km/h (12 MPH)]
490 Hz
Name
Resistance (Approx.)
Step motor A
15.0
Ω
Step motor B
15.0
Ω
Step motor C
15.0
Ω
Step motor D
15.0
Ω
Distance between end of converter housing and torque converter
14.4 mm (0.567 in)
VTL-1
VENTILATION, HEATER & AIR CONDITIONER
C
D
E
F
G
H
J
K
L
M
SECTION
VTL
A
B
VTL
N
O
P
CONTENTS
VENTILATION SYSTEM
WITHOUT 7 INCH DISPLAY
FUNCTION DIAGNOSIS . . . . . . . ...
SWITCHES AND THEIR CONTROL FUNC-
TION . . . . . . . . . . . . . . . . .
System Description . . . . . . . . . . . . ...
AIR DISTRIBUTION . . . . . . . . . . .
System Description . . . . . . . . . . . . ...
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . .....
Precaution for Procedure without Cowl Top Cover
. ..
Precautions For Xenon Headlamp Service . . . ...
Working with HFC-134a (R-134a) . . . . . . .....
General Refrigerant Precaution . . . . . . . ....
Refrigerant Connection . . . . . . . . . . .....
Service Equipment . . . . . . . . . . . . ..
COMPRESSOR . . . . . . . . . . . . ..
General Precautions . . . . . . . . . . . ...
FLUORESCENT LEAK DETECTOR . . . . .
General Precautions . . . . . . . . . . . ...
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . ..
Special Service Tool . . . . . . . . . . . ...
Commercial Service Tool . . . . . . . . . .
Sealant or/and Lubricant . . . . . . . . . . .
ON-VEHICLE MAINTENANCE . . . . .
AIR CONDITIONER FILTER . . . . . . . ..
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Replacement . . . . . . . . . . . . . . ...
ON-VEHICLE REPAIR . . . . . . . . .
A/C CONTROL . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
A/C DISPLAY . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
A/C AUTO AMP. . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
AMBIENT SENSOR . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
IN-VEHICLE SENSOR . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
SUNLOAD SENSOR . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
INTAKE SENSOR . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
BLOWER UNIT . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
BLOWER MOTOR . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
INTAKE DOOR MOTOR . . . . . . . . ...
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст