Nissan Pathfinder (2010 year). Instruction — part 440
HA-54
< ON-VEHICLE REPAIR >
REFRIGERANT PRESSURE SENSOR
REFRIGERANT PRESSURE SENSOR
Removal and Installation for Refrigerant Pressure Sensor
INFOID:0000000005256854
REMOVAL
1. Discharge the refrigerant. Refer to
HA-37, "HFC-134a (R-134a) Service Procedure"
.
2. Disconnect the refrigerant pressure sensor harness connector
and remove the refrigerant pressure sensor from the condenser.
CAUTION:
Be careful not to damage the condenser fins.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
• Be careful not to damage the condenser fins.
• Replace the O-ring of the refrigerant pressure sensor with a new one, then apply compressor oil to it
for installation.
• After charging refrigerant, check for leaks.
LJIA0177E
2010 Pathfinder
EXPANSION VALVE
HA-55
< ON-VEHICLE REPAIR >
C
D
E
F
G
H
J
K
L
M
A
B
HA
N
O
P
EXPANSION VALVE
Removal and Installation for Front Expansion Valve
INFOID:0000000005256855
REMOVAL
1. Discharge the refrigerant. Refer to
HA-37, "HFC-134a (R-134a) Service Procedure"
.
2. Remove the front heater and cooling unit assembly. Refer to
VTL-18, "Removal and Installation"
.
3. Remove the front heater core and evaporator pipes grommet.
4. Remove the front expansion valve.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
• Replace the O-rings on then front expansion valve and the A/C refrigerant pipes with new ones, then
apply compressor oil to them for installation.
• After charging refrigerant, check for leaks.
Expansion valve bolts
: Refer to
A/C refrigerant pipe to expansion valve bolt
: Refer to
2010 Pathfinder
HA-56
< ON-VEHICLE REPAIR >
AMBIENT SENSOR
AMBIENT SENSOR
Removal and Installation
INFOID:0000000005256856
REMOVAL
1. Remove the front grille. Refer to
EXT-18, "Removal and Installation"
2. Disconnect the ambient sensor (1) electrical connector.
•
⇐
: Front
NOTE:
The ambient sensor is located behind the front grille, below the
hood latch.
3. Release the ambient sensor (1) clip and then remove the ambi-
ent sensor (1).
INSTALLATION
Installation is in the reverse order of removal.
AWIIA0262ZZ
2010 Pathfinder
HEATER PUMP
HA-57
< ON-VEHICLE REPAIR >
C
D
E
F
G
H
J
K
L
M
A
B
HA
N
O
P
HEATER PUMP
Removal and Installation
INFOID:0000000005256857
Heater Pump
NOTE:
Only the VQ40DE engine is equipped with a heater pump for the rear heater system.
REMOVAL
1. Partially drain the engine cooling system. Refer to
CO-12, "Changing Engine Coolant"
2. Disconnect the heater pump electrical connector.
3. Disconnect the two heater hoses.
4. Remove the heater pump from the bracket securing the heater pump to the cowl top.
CAUTION:
Do not disassemble the heater pump, replace the heater pump as an assembly.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
• The heater pump rubber mount must be fully seated on the bracket.
• Do not disassemble the heater pump, replace the heater pump as an assembly.
LBIA0414E
1.
Cowl top
2.
Heater pump electrical connector
3.
Heater pump
4.
Heater hose and clamp
5.
Heater hose and clamp
2010 Pathfinder
HA-58
< SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Service Data and Specification (SDS)
INFOID:0000000005256858
COMPRESSOR
OIL
REFRIGERANT
Make
ZEXEL VALEO CLIMATE CONTROL
Model
DKS-17D
Type
Swash plate
Displacement
175.5 cm
3
(10.7 in
3
) / revolution
Cylinder bore
×
stroke
30.5 mm (1.20 in) x 24.0 mm (0.94 in)
Direction of rotation
Clockwise (viewed from drive end)
Drive belt
Poly V
Name
NISSAN A/C System Oil Type S or equivalent
Capacity
With rear A/C
210 m (7.1 US fl oz, 7.4 Imp fl oz)
Without rear A/C
180 m (6.1 US fl oz, 6.3 Imp fl oz)
Type
HFC 134a (R-134a)
Capacity
With rear A/C
0.85
±
0.05 kg (1.87
±
0.11 lb)
Without rear A/C
0.70
±
0.05 kg (1.54
±
0.11 lb)
2010 Pathfinder
HAC-1
VENTILATION, HEATER & AIR CONDITIONER
C
D
E
F
G
H
J
K
L
M
SECTION
HAC
A
B
HAC
N
O
P
CONTENTS
HEATER & AIR CONDITIONING CONTROL SYSTEM
AUTOMATIC AIR CONDITIONER
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . . ..
How to Perform Trouble Diagnosis For Quick And
Accurate Repair . . . . . . . . . . . . . ....
INSPECTION AND ADJUSTMENT . . . . . .
Operational Check (Front) . . . . . . . . . .....
Operational Check (Rear) . . . . . . . . . .....
FUNCTION DIAGNOSIS . . . . . . . ...
FUNCTION INFORMATION . . . . . . . .
Component Part Location . . . . . . . . . .....
Symptom Table . . . . . . . . . . . . . ...
REFRIGERATION SYSTEM . . . . . . . ..
Refrigerant Cycle . . . . . . . . . . . . .
Refrigerant System Protection . . . . . . . .
AUTOMATIC AIR CONDITIONER SYSTEM . .
Control System Diagram . . . . . . . . . . .
Control System Description . . . . . . . . . .
Discharge Air Flow (Front) . . . . . . . . . ..
Switches And Their Control Function (Front) . . ..
Switches And Their Control Function (Rear) . . ...
DIAGNOSIS SYSTEM (HVAC) . . . . . . ..
CONSULT-III Function (HVAC) . . . . . . . ...
DIAGNOSIS SYSTEM (BCM) . . . . . . .
CONSULT-III Function (BCM - COMMON ITEM) .
CONSULT-III Function (BCM - AIR CONDITION-
ER) . . . . . . . . . . . . . . . . . . ..
SELF-DIAGNOSIS FUNCTION . . . . . . ..
A/C Auto Amp. Self-Diagnosis . . . . . . . .
A/C and AV Switch Assembly Self-Diagnosis . . .
A/C System Self-Diagnosis Code Chart . . . . ..
COMPONENT DIAGNOSIS . . . . . . .
MODE DOOR MOTOR . . . . . . . . . ..
System Description . . . . . . . . . . . . ..
Mode Door Motor (Front) Component Function
Check . . . . . . . . . . . . . . . . . ..
Mode Door Motor (Front) Diagnosis Procedure . ..
AIR MIX DOOR MOTOR . . . . . . . . ...
System Description . . . . . . . . . . . . ..
Air Mix Door Motor (Driver) Component Function
Check . . . . . . . . . . . . . . . . . ..
Air Mix Door Motor (Driver) Diagnosis Procedure .
Air Mix Door Motor (Passenger) Component
Function Check . . . . . . . . . . . . . .
Air Mix Door Motor (Passenger) Diagnosis Proce-
dure . . . . . . . . . . . . . . . . . . .
INTAKE DOOR MOTOR . . . . . . . . ...
System Description . . . . . . . . . . . . ..
Intake Door Motor Component Function Check . ..
Intake Door Motor Diagnosis Procedure . . . . .
BLOWER MOTOR CONTROL SYSTEM . . ..
System Description . . . . . . . . . . . . ..
Front Blower Motor Component Function Check .
Front Blower Motor Diagnosis Procedure . . . .
Front Blower Motor Component Inspection . . . .
Rear Blower Motor Description . . . . . . . .
Rear Blower Motor Component Function Check . .
Rear Air Control (Front) Diagnosis Procedure #1 .
Rear Air Control (Rear) Diagnosis Procedure #2 .
Rear Air Control (Rear) Diagnosis Procedure #3 .
Rear Air Control (Rear) Diagnosis Procedure #4 .
Rear Blower Motor And Relay Component Inspec-
tion . . . . . . . . . . . . . . . . . . ...
REAR AIR CONTROL SYSTEM . . . . . ...
Rear Air Control System Description . . . . . ...
Rear Air Control Component Function Check . . .
Rear Air Control (Front) Diagnosis Procedure . . .
Rear Air Control (Rear) Diagnosis Procedure . . .
MAGNET CLUTCH . . . . . . . . . . ...
2010 Pathfinder
HAC-2
System Description . . . . . . . . . . . . .
Magnet Clutch Component Function Check . . ...
Magnet Clutch Diagnosis Procedure . . . . . ..
WATER VALVE CIRCUIT . . . . . . . . ..
Water Valve Description (VK56DE) . . . . . ....
Water Valve Diagnosis Procedure (VK56DE) . . .
HEATER PUMP . . . . . . . . . . . . .
System Description (VQ40DE) . . . . . . . ...
Diagnosis Procedure (VQ40DE) . . . . . . . .
Component Inspection (VQ40DE) . . . . . . ..
AMBIENT SENSOR . . . . . . . . . . ...
Component Description . . . . . . . . . . ..
Ambient Sensor Diagnosis Procedure . . . . ....
Ambient Sensor Component Inspection . . . . .
IN-VEHICLE SENSOR . . . . . . . . . ...
Component Description . . . . . . . . . . ..
In-Vehicle Sensor Diagnosis Procedure . . . . .
In-Vehicle Sensor Component Inspection . . . ..
OPTICAL SENSOR . . . . . . . . . . ...
Component Description . . . . . . . . . . ..
Optical Sensor Diagnosis Procedure . . . . . ..
INTAKE SENSOR . . . . . . . . . . . ..
System Description . . . . . . . . . . . . .
Intake Sensor Diagnosis Procedure . . . . . ...
Intake Sensor Component Inspection . . . . ....
POWER SUPPLY AND GROUND CIRCUIT
FOR CONTROLLER . . . . . . . . . . ..
Component Description . . . . . . . . . . ..
A/C Auto Amp. Component Function Check . . ..
A/C Auto Amp Power and Ground Diagnosis Pro-
cedure . . . . . . . . . . . . . . . . . .
ECU DIAGNOSIS . . . . . . . . . .
AIR CONDITIONER CONTROL . . . . . .
A/C Auto Amp. Terminals Reference Values . . .
Wiring Diagram . . . . . . . . . . . . . ...
SYMPTOM DIAGNOSIS . . . . . . .
AIR CONDITIONER CONTROL . . . . . ..
Symptom Matrix Chart . . . . . . . . . . .
INSUFFICIENT COOLING . . . . . . . ...
Component Function Check . . . . . . . . ..
Diagnostic Work Flow . . . . . . . . . . .
Performance Chart . . . . . . . . . . . .
Trouble Diagnoses for Abnormal Pressure . . ...
INSUFFICIENT HEATING . . . . . . . ...
Component Function Check . . . . . . . . ..
NOISE . . . . . . . . . . . . . . . ..
Component Function Check . . . . . . . . ..
MEMORY FUNCTION DOES NOT OPERATE ..
Memory Function Check . . . . . . . . . ...
PRECAUTION . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . .
Working with HFC-134a (R-134a) . . . . . . .
Precaution for Service Equipment . . . . . .
MANUAL AIR CONDITIONER
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . .
How to Perform Trouble Diagnosis For Quick And
Accurate Repair . . . . . . . . . . . . .
INSPECTION AND ADJUSTMENT . . . . ..
Operational Check . . . . . . . . . . . .
FUNCTION DIAGNOSIS . . . . . . ...
FUNCTION INFORMATION . . . . . . . .
Component Part Location . . . . . . . . . .
Symptom Table . . . . . . . . . . . . . .
REFRIGERATION SYSTEM . . . . . . . .
Refrigerant Cycle . . . . . . . . . . . . ..
Refrigerant System Protection . . . . . . . ..
MANUAL AIR CONDITIONER SYSTEM . . .
Control System Diagram . . . . . . . . . ...
Control System Description . . . . . . . . ..
Discharge Air Flow . . . . . . . . . . . .
Switches And Their Control Function . . . . .
DIAGNOSIS SYSTEM (BCM) . . . . . . ...
CONSULT-III Function (BCM - COMMON ITEM) .
CONSULT-III Function (BCM - AIR CONDITION-
ER) . . . . . . . . . . . . . . . . . .
COMPONENT DIAGNOSIS . . . . . ..
MODE DOOR MOTOR . . . . . . . . . .
System Description . . . . . . . . . . . ...
Mode Door Motor (Front) Component Function
Check . . . . . . . . . . . . . . . . .
Mode Door Motor (Front) Diagnosis Procedure .
AIR MIX DOOR MOTOR . . . . . . . . ..
System Description . . . . . . . . . . . ...
Air Mix Door Motor Component Function Check ..
Air Mix Door Motor Diagnosis Procedure . . . ..
INTAKE DOOR MOTOR . . . . . . . . ...
System Description . . . . . . . . . . . ...
Intake Door Motor Component Function Check .
Intake Door Motor Diagnosis Procedure . . . ...
BLOWER MOTOR . . . . . . . . . . .
2010 Pathfinder
HAC-3
C
D
E
F
G
H
J
K
L
M
A
B
HAC
N
O
P
System Description . . . . . . . . . . . ...
Front Blower Motor Component Function Check ..
Front Blower Motor Diagnosis Procedure . . . .
Front Blower Motor Component Inspection . . ...
MAGNET CLUTCH . . . . . . . . . . ...
System Description . . . . . . . . . . . ...
Magnet Clutch Component Function Check . . .
Magnet Clutch Diagnosis Procedure . . . . . .
INTAKE SENSOR . . . . . . . . . . .
System Description . . . . . . . . . . . ...
Intake Sensor Diagnosis Procedure . . . . . ..
Intake Sensor Component Inspection . . . . ...
POWER SUPPLY AND GROUND CIRCUIT
FOR CONTROLLER . . . . . . . . . .
Component Description . . . . . . . . . . .
Front Air Control Component Function Check . ..
Front Air Control Power and Ground Diagnosis
Procedure . . . . . . . . . . . . . . . ..
ECU DIAGNOSIS . . . . . . . . . ...
AIR CONDITIONER CONTROL . . . . . ...
System Description . . . . . . . . . . . ...
System Operation . . . . . . . . . . . . .
Front Air Control Terminals Reference Values . .
Wiring Diagram . . . . . . . . . . . . . ..
SYMPTOM DIAGNOSIS . . . . . . .
AIR CONDITIONER CONTROL . . . . . ..
Symptom Matrix Chart . . . . . . . . . . .
INSUFFICIENT COOLING . . . . . . . ..
Component Function Check . . . . . . . . ..
Diagnostic Work Flow . . . . . . . . . . .
Performance Chart . . . . . . . . . . . .
Trouble Diagnoses for Abnormal Pressure . . ...
INSUFFICIENT HEATING . . . . . . . ...
Component Function Check . . . . . . . . ..
NOISE . . . . . . . . . . . . . . . ..
Component Function Check . . . . . . . . ..
PRECAUTION . . . . . . . . . . .
PRECAUTIONS . . . . . . . . . . . ...
Working with HFC-134a (R-134a) . . . . . . .
Precaution for Service Equipment . . . . . . .
2010 Pathfinder
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст