Daewoo Nubira. Manual — part 68
5C0 – 24
I
CLUTCH
DAEWOO V–121 BL4
Assembly Procedure
1. Apply clean clutch fluid to the piston and the cup.
2. Install the spring to the piston, and insert the as-
sembly into the cylinder body.
3. Compress the piston with a driver, then install the
snap ring with snap ring pliers.
4. Install the pushrod and the boot.
5. Install the brackets and the bolts.
6. Install the clutch release cylinder assembly. Refer
to”Clutch Master Cylinder Assembl” in this section.
CLUTCH 5C0 – 25
DAEWOO V–121 BL4
GENERAL DESCRIPTION
AND SYSTEM OPERATION
DRIVING MEMBERS
The driving members consist of two flat surfaces ma-
chined to a smooth finish. One of these is the rear face of
the engine flywheel, and the other is the pressure plate.
The pressure plate is fitted into a steel cover, which is
bolted to the flywheel.
DRIVEN MEMBERS
The driven member is the clutch disc with a splined hub
which is free to slide lengthwise along the splines of the in-
put shaft, but which drives the input shaft through these
same splines.
The driving and driven members are held in contact by
spring pressure. This pressure is exerted by a diaphragm
spring in the pressure plate assembly.
OPERATING MEMBERS
The clutch release system consists of the clutch pedal, the
clutch shaft, the fork, and the release bearing. When pres-
sure is applied to the clutch pedal, the fork pivots on its
shaft and the inner end pushes against the release bear-
ing. The bearing then pushes against the release levers in
the pressure plate assembly, thereby releasing the clutch.
SECTION : 9F
AUDIO SYSTEMS
CAUTION : Disconnect the negative battery cable before removing or installing any electrical unit or when a tool
or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable will help
prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless otherwise noted.
TABLE OF CONTENTS
SPECIFICATIONS
9F–1
. . . . . . . . . . . . . . . . . . . . . . . . . .
FASTENER TIGHTENING SPECIFICATIONS
9F–1
.
SCHEMATIC AND ROUTING DIAGRAMS
9F–2
. . . . .
AUDIO SYSTEM CIRCUIT
9F–2
. . . . . . . . . . . . . . . . . .
DIAGNOSIS
9F–3
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
STEREO CASSETTE AM/FM RADIO
9F–3
. . . . . . . .
SPEAKERS
9F–5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ANTENNA
9F–6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MAINTENANCE AND REPAIR
9F–8
. . . . . . . . . . . . . . .
ON–VEHICLE SERVICE
9F–8
. . . . . . . . . . . . . . . . . . . . .
STEREO CASSETTE AM/FM RADIO
9F–8
. . . . . . . .
FRONT DOOR SPEAKERS
9F–9
. . . . . . . . . . . . . . . . .
TWEETER SPEAKERS
9F–10
. . . . . . . . . . . . . . . . . . .
REAR SPEAKERS (NOTCHBACK)
9F–10
. . . . . . . . .
REAR SPEAKERS (HATCHBACK)
9F–11
. . . . . . . . . .
MAST ANTENNA
9F–12
. . . . . . . . . . . . . . . . . . . . . . . . .
ROOF ANTENNA
9F–13
. . . . . . . . . . . . . . . . . . . . . . . .
POWER ANTENNA MAST(NOTCHBACK)
9F–13
. . .
POWER ANTENNA MOTOR (NOTCHBACK)
9F–14
COMPACT DISC CHANGER
9F–15
. . . . . . . . . . . . . . .
GENERAL DESCRIPTION AND SYSTEM
OPERATION
9F–17
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
AUDIO SYSTEMS
9F–17
. . . . . . . . . . . . . . . . . . . . . . . .
AUDIO SECURITY SYSTEM
9F–17
. . . . . . . . . . . . . . .
FRONT AND REAR SPEAKERS
9F–17
. . . . . . . . . . .
TWEETER SPEAKERS
9F–17
. . . . . . . . . . . . . . . . . . .
MAST ANTENNA
9F–17
. . . . . . . . . . . . . . . . . . . . . . . . .
POWER ANTENNA
9F–17
. . . . . . . . . . . . . . . . . . . . . . .
ROOF ANTENNA
9F–17
. . . . . . . . . . . . . . . . . . . . . . . .
TAPE PLAYER AND CASSETTE CARE
9F–17
. . . . .
COMPACT DISC CARE
9F–17
. . . . . . . . . . . . . . . . . . .
SPECIFICATIONS
FASTENER TIGHTENING SPECIFICATIONS
Application
N
S
m
Lb–Ft
Lb–In
Antenna Cap Nut
7
–
62
Antenna Motor Nuts
7
–
62
Audio System Bolts
4
–
35
CD Changer Nuts
7
–
62
Mast Antenna Base Nut
4
–
35
Front Door Speaker Screws
4
–
35
Rear Speaker Screws
4
–
35
Roof Antenna Nut
10
–
89
9F – 2
I
AUDIO SYSTEMS
DAEWOO V–121 BL4
SCHEMATIC AND ROUTING DIAGRAMS
AUDIO SYSTEM CIRCUIT
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст