Daewoo Matiz (2003 year). Manual — part 185
6E – 14 STEERING WHEEL AND COLUMN
D15A704A
Assembly Procedure
Important: Position the alignment spacer on the lower
column shaft to install the spacer in the steering column
jacket easily.
1. Install the steering column shaft to the steering col-
umn.
D
Position the locking of the alignment spacer on the
groove of the steering column.
D
Install the washer.
D
Install the spring.
D
Install the washer.
D
Install the retaining ring.
2. Install the steering column to the vehicle. Refer to
“Steering Wheel” in this section.
STEERING WHEEL AND COLUMN 6E – 15
SPECIFICATIONS
GENERAL SPECIFICATIONS
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Application
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
Unit
ÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁ
Description
ÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
With Airbag
mm (in.)
ÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁ
380 (14.96)
ÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁ
Steering Wheel
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
Diameter
Without Airbag
mm (in.)
ÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁ
370 (14.57)
ÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁ
Steering Wheel
ÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁ
Free Play (Engine Stop)
mm (in.)
ÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁ
0
±
20 (0
±
0.79)
FASTENER TIGHTENING SPECIFICATIONS
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Application
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
N
S
m
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
Lb-Ft
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
Lb-In
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Steering Wheel Nut
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
23 – 33
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
17 – 24
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
–
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Steering Column Upper Nuts
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
15 – 20
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
11 – 15
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
–
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Steering Column Lower Nuts
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
15 – 20
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
11 – 15
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
–
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Intermediate Shaft Upper Pinch Bolt
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
21 – 29
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
16 – 22
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
–
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁÁ
Intermediate Shaft Lower Pinch Bolt
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
21 – 29
ÁÁÁÁÁÁ
ÁÁÁÁÁÁ
16 – 22
ÁÁÁÁÁÁÁ
ÁÁÁÁÁÁÁ
–
6E – 16 STEERING WHEEL AND COLUMN
SPECIAL TOOLS AND EQUIPMENT
SPECIAL TOOLS TABLE
D105A101
DW310–010
Steering Wheel Puller
SECTION 7A
HEATING AND VENTILATION SYSTEM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation
7A-2
. . . . . . . . . . . . . . . . . .
Heating and Ventilation Systems
7A-2
. . . . . . . . . . . .
Component Locator
7A-3
. . . . . . . . . . . . . . . . . . . . . . . .
Control Assembly
7A-3
. . . . . . . . . . . . . . . . . . . . . . . . .
Blower Module Assembly
7A-4
. . . . . . . . . . . . . . . . . . .
Air Distributor and Heater Module
Assembly
7A-5
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Informatin and Procedures
7A-6
. . . . . . .
Heater System
7A-6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Insufficient Heating or Defrosting
7A-6
. . . . . . . . . . . .
Blower Electrical
7A-10
. . . . . . . . . . . . . . . . . . . . . . . . .
Improper Air Delivery or No Mode Shift
7A-11
. . . . . .
Too Much Heat
7A-13
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls
7A-15
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blower Noise
7A-16
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions
7A-18
. . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service
7A-18
. . . . . . . . . . . . . . . . . . . . . . . . .
Control Assembly and Control Cables
7A-18
. . . . . . .
Blower Motor and Cooling Hose
7A-20
. . . . . . . . . . . .
Blower Resistor
7A-20
. . . . . . . . . . . . . . . . . . . . . . . . . .
Blower Motor Switch
7A-21
. . . . . . . . . . . . . . . . . . . . . .
Heater Hoses
7A-22
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater Module
7A-24
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Blower Module
7A-25
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Defroster Duct and Hoses
7A-26
. . . . . . . . . . . . . . . . .
Ventilation Duct
7A-27
. . . . . . . . . . . . . . . . . . . . . . . . . .
Unit Repair
7A-28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heater Core
7A-28
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications
7A-29
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications
7A-29
. . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications
7A-29
. . . . . . . . . .
Special Tools and Equipment
7A-30
. . . . . . . . . . . . . .
Special Tools Table
7A-30
. . . . . . . . . . . . . . . . . . . . . . .
Schematic and Routing Diagrams
7A-31
. . . . . . . . . .
Non-A/C Diagrams
7A-31
. . . . . . . . . . . . . . . . . . . . . . .
Air Flow Through Ducts (Non–A/C)
7A-32
. . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст