Hyundai Santa Fe (2006 year). Manual — part 710
HA -218
HEATING, VENTILATION AND AIR CONDITIONING
1
2
3
4
6
9
10
12
13
14
15
16
17
18
19
20
21
22
23
24
*
* *
*
25
26
16 : Motor
17 : Motor
v
SCMHA6714L
4) Is the measured voltage within specifications?
YES
Check connectors for looseness, poor connection, bending, corrosion, contamination, deterioration, or damage.
Repair or replace as necessary and then go to "Verification of Vehicle Repair" procedure.
NO
Substitute with a known-good A/C Control Unit and check for proper operation.
If the problem is corrected, replace A/C Control Unit and then go to "Verification of Vehicle Repair" procedure.
VERIFICATION OF VEHICLE REPAIR
E9BA69FB
After a repair, it is essential to verify that the fault has been corrected.
1.
Connect scantool and select "Diagnostic Trouble Codes(DTCs)" mode and then clear DTC.
2.
Operate the vehicle and monitor the DTC on the scantool.
3.
Are any DTCs present?
YES
Go to the applicable troubleshooting procedure.
NO
System is performing to specification at this time.
Manual Transaxle
(M5GF2)
GENERAL
MANUAL TRANSAXLE SYSTEM
MANUAL TRANSAXLE
MANUAL TRANSAXLE SHIFT CONTROL SYS-
TEM
TRANSFER CASE ASSEMBLY
TRANSFER CASE
TRANSFER DRIVE GEAR
HYPOID GEAR
PINION SHAFT AND CASE
COUPLING ASSEMBLY
MT -2
MANUAL TRANSAXLE (M5GF2)
GENERAL
SPECIFICATION
ED0183A6
Engine type
μ 2.7
Manual transaxle type
M5GF2
1st
3.273
2nd
1.794
3rd
1.552
4th
1.176
5th
0.974
Gear ratio
Reverse
3.416
Final gear ratio
4.333
T/M oil capacity(ℓ )※
1.9 liter (2.0077US qt, 1.6718mp qt)
※ The quantity in the chart above is for the reference. The
actual filling quantity of the automatic transaxle fluid must
be set according to ’INSPECTION’ or ’REPLACEMENT’
procedure of the automatic transaxle fluid.
Recommended transaxle oil
SAE75W/85 or API GL-4
Check & Replenishment
Every one year or every 100,000km
Normal use
No service required
Private use
Severe use(※)
Replacement
Business use
Every 100,000 Km
※ Severe use(marked ’※’) is defined as:
1.
Driving on rough road(bumpy road, gravel road,
snowy road, unpaved road etc.).
2.
Driving on mountain road, ascent/descent.
3.
Repetition of short distance driving.
4.
More than 50% operation in heavy city traffic during
hot weather above 32 C(89.6 F).
5.
Police car, Taxi, Commercial type operation or trailer
towing, etc.
TIGHTENING TORQUE
Item
Nm
kgf.m
lb-ft
Oil drain plug
30~35
3.0~3.5
21.7~25.3
Oil filler plug
30~35
3.0~3.5
21.7~25.3
Back up lamp switch
30~35
3.0~3.5
21.7~25.3
Control shaft assembly
10~12
1.0~1.2
7.2~8.7
Select lever
43~55
4.3~5.5
31.1~39.8
Shift link assembly
43~55
4.3~5.5
31.1~39.8
Transaxle mounting bracket assembly
65~85
6.5~8.5
47.0~61.5
Transaxle and enging mounting bolt
65~85
6.5~8.5
47.0~61.5
GENERAL
MT -3
SERVICE STANDARD
Item
Specification [mm(inch)]
Differential end play
0.15T-0.20T (0.0059T~0.0079T)
Input shaft end play
0.05T-0 (0.0020T~0)
1st output shaft end play
0.05T-0.10T (0.0020T~0.0039T)
2nd output shaft end play
0.05T-0.10T (0.0020T~0.0039T)
1st gear end play
0.135T-0.435T (0.0053T~0.0171T)
2nd gear end play
0.230T-0.430T (0.0091T~0.0169T)
3rd gear end play
0.142T-0.472T (0.0056T~0.0186T)
4th gear end play
0.230T-0.430T (0.0091T~0.0169T)
5th gear end play
0.125T-0.305T (0.0049T~0.0120T)
Reverse gear end play
0.135T-0.345T (0.0053T~0.0136T)
LUBRICANTS
E71A8BF7
Item
Lubricant
Quantity
Transaxle input shaft splin
CASMOLY L9508
0.2 gr.
Transaxle case gasket
LOCTITE 587
As required
Concentric slave cylinder assembly
KLUBER 9R100
As reguired
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст