Hyundai Santa Fe (2006 year). Manual — part 137
AUDIO SYSTEM
BE -9
TROUBLESHOOTING
EABDCBC8
CUSTOMER COMPLAINT ANALYSIS CHECK SHEET
TROUBLE IN
ALL
TROUBLE OCCURS
TYPE OF TROUBLE
OTHERS
AM
FM
TAPE
CD
MP3
CD changer
AMP
Others
Always
Engine start
Engine Running
Cold
Warm
Sometimes
Most of the time
Engine off
Will not play
Tape speed not proper
Weak
Squealing noise
Eats tape
Display/illumination poor
Others (Describe) :
Customer complaint contents :
Have you checked customer's defects :
*
Using the customer complaint analysis check sheet for reference, ask the customer for as much detail as
possible about the problem.
CD skips & jumps
Tape/CD will not eject or insert
BT1G001A
BE -10
BODY ELECTRICAL SYSTEM
There are six areas where a problem can occur: wiring
harness, the radio, the cassette tape deck, the CD player,
and speaker. Troubleshooting enables you to confine the
problem to a particular area.
Turn ignition key to
ACC position
Turn on the radio or the
tape player
Verify customer com-
plaint or identify symptom
1) Place balance and fader control
to center position.
2) Set volume control to proper
position.
Radio
See CHART 2
Sound
See CHART 1
Cassette player
See CHART 3
Noise
See CHART 4
CD player
See CHART 5
Miscellaneous
Faint reception
See CHART 6
Poor volume
See CHART 7
Seek/scan
problem
See CHART 8
"Eating" tape
See CHART 9
LTIF001A
AUDIO SYSTEM
BE -11
CHART 1
Sound
1. Radio and tape player
have no sound at all.
All speakers
Illumination lights ?
Check audio
fuse (10A)
Are all connectors behind
radio and tape player prop-
erly connected ?
Is there voltage (12V) be-
tween terminal 11 of the
audio connector and body
ground ?
Are radio and player prop-
erly connected ?
Check connection between
output connector of radio
and car.
Replace radio unit
Connect
properly
Check
wire
Reinstall
properly
Replace
fuse
Check short
circuit
Check fuse of radio
unit.
No
Yes
Yes
Yes
No
No
No
O.K.
O.K.
Blown
Blown again
One speaker
Check speaker harness
Replace radio unit
Check speaker
connector
Temporarily install
another speaker.
Repair
Connect
correctly
Replace
speaker
O.K.
O.K.
O.K.
N.G.
N.G.
N.G.
LTJF001B
BE -12
BODY ELECTRICAL SYSTEM
2. Tape player OK but no sound from radio
Check that the antenna is
pluged into the radio.
Insert properly
Reinsert plug, O.K. ?
Does radio alone work ?
Does the condition get
better by using the outer
antenna (such as pillar
antenna)?
Replace radio
Inspect antenna plug
Replace radio
Inspect antenna and
antenna cable, and
replace if necessary
O.K.
Yes
Yes
O.K.
Not O.K.
No
No
Not O.K.
LTIF001C
CHART 2
Radio problem
Weak
Poor tone
Tune correctly. Still poor ?
Check for shorts in speaker
harness
Check for object lying on
speaker and rattling
Still poor ?
Check antenna and lead-in
for broken connectors.
Does the tester indicate an
open circuit ?
Is the broadcast quality the
cause of poor tone quality ?
Repair harness
Not O.K.
Remove object
Not O.K.
Replace antenna
Yes
Yes
The radio is not at fault
Check antenna
Check connection of
antenna plug
Does the condition get
better by using the outer
antenna (such as pillar
antenna)?
Replace antenna
Replace radio
No
Yes
Yes
OK
OK
Yes
No
BTIF001D
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст