SsangYong Rexton. Manual — part 506
REAR BRAKE 4C-15
SSANGYONG Y200
3. Install the caliper to the brake disc.
Installation Notice
Tightening Torque
4 - 8 N•m
(35 - 71 lb-in)
4. Install the brake hose.
Notice: The washer should be replaced new part.
5. Tighten the air bleeder screw.
Installation Notice
Tightening Torque
7 - 13 N•m
(62 - 115 lb-in)
6. Bleed the brake system after replacement.
YAD4C260
YAD4C270
SSANGYONG Y200
4C-16 REAR BRAKE
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
;;;;;;;
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
yyyyyyy
DRUM BRAKE ASSEMBLY
1. Remove the tires
Notice:
•
Park the vehicle on the flat ground and fix the
vehicle not to move it.
•
Position the transmission in NEUTRAL.
2. Disconnect the brake pipe from the rear brake.
Notice: Be carefully to prevent the brake fluid loss
and contamination.
3. Insert the bolt (M8) to the service hole of the brake
drum and remove the brake drum.
4. Remove the service hole plug of the axle shaft.
YAD4C120
YAD4C290
YAD4C300
YAD4C310
REAR BRAKE 4C-17
SSANGYONG Y200
5. Remove the return spring.
(1) Disconnect the upper return spring.
(2) Disconnect the lower return spring.
(3) Disconnect the lever spring.
(4) Disconnect the adjuster lever from the adjuster.
6. Rotate the lining shoe hold down-washer in the
plug hole of the axle shaft flange and disconnect
the pin and the spring.
7. Disconnect the parking cable from the parking
lever.
YAD4C320
YAD4C330
YAD4C340
YAD4C350
SSANGYONG Y200
4C-18 REAR BRAKE
8. Disconnect the brake lining and adjuster lever.
9. Remove the wheel cylinder mounting bolt and
remove the wheel cylinder.
Inspection
1. Measure the inside diameter of the brake drum
and replace as needed.
I.D.
Ø 254 mm
Wear Limit
Ø 255.5 mm
Notice: Measure two more position.
2. Inspect the surface between the lining and brake.
Mark the brake drum inside using chalk and scrub
the shoe & lining assembly. If there is excessive
contact problem, replace the shoe & lining
assembly or the brake drum.
Notice: Clean any chalk mark after inspection
complete.
YAD4C360
YAD4C370
YAD4C380
YAD4C390
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст