Nissan Rogue. Manual — part 1022
RSU-1
SUSPENSION
C
D
F
G
H
I
J
K
L
M
SECTION
RSU
A
B
RSU
N
O
P
CONTENTS
REAR SUSPENSION
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precautions for Suspension . . . . . . . . . ..
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting Chart . . . . . . . . . ..
PERIODIC MAINTENANCE . . . . . . ..
REAR SUSPENSION ASSEMBLY . . . . . .
Inspection and Adjustment . . . . . . . . . ....
WHEEL ALIGNMENT . . . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . . ..
Adjustment . . . . . . . . . . . . . . . ....
REMOVAL AND INSTALLATION . . . .
COIL SPRING . . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . ..
Removal and Installation - FWD . . . . . . . ...
Removal and Installation - AWD . . . . . . . .
REAR SHOCK ABSORBER . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disposal . . . . . . . . . . . . . . . . ...
REAR SUSPENSION ARM . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
LOWER LINK . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
UPPER LINK . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
REAR STABILIZER . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
UNIT REMOVAL AND INSTALLATION . ..
REAR SUSPENSION MEMBER . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation - FWD . . . . . . . ..
Removal and Installation - AWD . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
RSU-2
< PRECAUTION >
PRECAUTIONS
PRECAUTION
PRECAUTIONS
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT
PRE-TENSIONER"
INFOID:0000000011276527
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. Information necessary to service the system safely is included in the SR and SB section of
this Service Manual.
WARNING:
• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision which would result in air bag inflation, all maintenance must be performed by
an authorized NISSAN/INFINITI dealer.
• Improper maintenance, including incorrect removal and installation of the SRS, can lead to personal
injury caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag
Module, see the SR section.
• Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or har-
ness connectors.
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS
WARNING:
• When working near the Airbag Diagnosis Sensor Unit or other Airbag System sensors with the Igni-
tion ON or engine running, DO NOT use air or electric power tools or strike near the sensor(s) with a
hammer. Heavy vibration could activate the sensor(s) and deploy the air bag(s), possibly causing
serious injury.
• When using air or electric power tools or hammers, always switch the Ignition OFF, disconnect the
battery and wait at least three minutes before performing any service.
Precautions for Suspension
INFOID:0000000011276528
• When installing rubber bushings, the final tightening must be carried out under unladen conditions with tires
on ground. Spilled oil might shorten the life of rubber bushings. Be sure to wipe off any spilled oil.
- Unladen conditions mean that fuel, engine coolant and lubricants are full. Spare tire, jack, hand tools and
mats are in designated positions.
• After servicing suspension parts, be sure to check wheel alignment.
• Self-lock nuts are not reusable. Always use new ones when installing. Since new self-lock nuts are pre-oiled,
tighten as they are.
PREPARATION
RSU-3
< PREPARATION >
C
D
F
G
H
I
J
K
L
M
A
B
RSU
N
O
P
PREPARATION
PREPARATION
Special Service Tool
INFOID:0000000011276529
The actual shape of the tools may differ from those illustrated here.
Commercial Service Tool
INFOID:0000000011276530
Tool number
(TechMate No.)
Tool name
Description
—
(J-44372)
Pull gauge
Measuring ball joint swinging force
—
(J-49286)
Drift and Pull gauge
Measuring drift and pull
LST024
AWEIA0156ZZ
Tool name
Description
Power tool
Loosening nuts, screws and bolts
PIIB1407E
RSU-4
< SYMPTOM DIAGNOSIS >
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
SYMPTOM DIAGNOSIS
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
NVH Troubleshooting Chart
INFOID:0000000011276531
Use chart below to find the cause of the symptom. If necessary, repair or replace these parts.
×: Applicable
Reference
,
,
,
,
,
—
—
—
,
,
,
,
,
(FWD)
and
(A
W
D
)
(A
W
D
)
Possible cause and SUSPECTED PARTS
Imp
rop
er i
ns
ta
lla
tio
n,
lo
os
en
es
s
Sh
oc
k a
bs
o
rber
de
form
at
io
n, d
am
ag
e
or d
ef
lec
tion
Bus
h
in
g or mo
un
t de
te
riora
tio
n
Part
s interference
S
p
rin
g f
ati
gu
e
Su
sp
en
si
on
lo
os
en
es
s
In
co
rrec
t wh
ee
l a
lig
nm
en
t
S
tab
ili
ze
r fa
tig
ue
PROPELLER S
H
A
FT (A
W
D
)
DIFF
ERENTIAL (A
WD)
REAR A
XLE
TIRE
WHE
EL
DRIVE SHAFT (A
W
D
)
BRAKE
Symptom
REAR SUSPENSION
Noise
×
×
×
×
×
×
×
×
×
×
×
×
×
Shake
×
×
×
×
×
×
×
×
×
×
×
Vibration
×
×
×
×
×
×
×
×
×
Shimmy
×
×
×
×
×
×
×
×
×
Shudder
×
×
×
×
×
×
×
Poor quality ride or
handling
×
×
×
×
×
×
×
×
×
×
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст