Nissan Almera Tino V10 (2001 year). Manual — part 174
NLMA0036
Shown below are Pre-delivery Inspection Items required for the new vehicle. It is recommended that
necessary items other than those listed here be added, paying due regard to the conditions in each
country.
Perform applicable items on each model. Consult text of this section for specifications.
UNDER HOOD — engine off
Radiator coolant level and coolant hose connections for leaks
Battery fluid level, specific gravity and conditions of battery terminals
Drive belts tension
Fuel filter for water or dusts (Diesel only), and fuel lines and connections for leaks
Engine oil level and oil leaks
Clutch and brake reservoir fluid level and fluid lines for leaks
Windshield and rear window washer and headlamp cleaner reservoir fluid level
Power steering reservoir fluid level and hose connections for leaks
ON INSIDE AND OUTSIDE
Remove front spring/strut spacer (If applicable)
Operation of all instruments, gauges, lights and accessories
Operation of horn(s), wiper and washer
Steering lock for operation
Check air conditioner for gas leaks
Front and rear seats, and seat belts for operation
All moldings, trims and fittings for fit and alignment
All windows for operation and alignment
Hood, trunk lid, door panels for fit and alignment
Latches, keys and locks for operation
Weatherstrips for adhesion and fit
Headlamp aiming
Tighten wheel nuts (Inc. inner nuts if applicable)
Tire pressure (Inc. spare tire)
Check front wheels for toe-in
Install clock/voltmeter/room lamp fuse (If applicable)
Install deodorizing filter to air conditioner (If applicable)
Remove wiper blade protectors (If applicable)
UNDER BODY
Manual transmission/transaxle, transfer and differential gear oil level
Brake and fuel lines and oil/fluid reservoirs for leaks
Tighten bolts and nuts of steering linkage and gear box, suspension, propeller shafts and drive shafts
Tighten rear body bolts and nuts (Models with wooden bed only)
ROAD TEST
Clutch operation
Parking brake operation
Service brake operation
Automatic transmission/transaxle shift timing and kickdown
Steering control and returnability
Engine performance
Squeaks and rattles
ENGINE OPERATING AND HOT
Adjust idle speed
Automatic transmission/transaxle fluid level
Engine idling and stop knob operation (Diesel only)
FINAL INSPECTION
Install necessary parts (outside mirror, wheel covers, seat belts, mat, carpet or mud flaps)
Inspect for interior and exterior metal and paint damage
Check for spare tire, jack, tools (wheel chock), and literature
Wash, clean interior and exterior
: Not applicable to this model
PRE-DELIVERY INSPECTION ITEMS
MA-2
NLMA0004
General maintenance includes those items which should be checked during the normal day-to-day operation
of the vehicle. They are essential if the vehicle is to continue operating properly. The owners can perform the
checks and inspections themselves or they can have their NISSAN dealers do them for a nominal charge.
OUTSIDE THE VEHICLE
The maintenance items listed here should be performed from time to time, unless otherwise specified.
Item
Reference page
Tires
Check the pressure with a gauge periodically when at a service station,
including the spare, and adjust to the specified pressure if necessary. Check
carefully for damage, cuts or excessive wear.
—
Windshield wiper
blades
Check for cracks or wear if not functioning correctly.
—
Doors and engine
hood
Check that all doors, the engine hood, the trunk lid and back door operate
properly. Also ensure that all latches lock securely. Lubricate if necessary.
Make sure that the secondary latch keeps the hood from opening when the
primary latch is released.
When driving in areas using road salt or other corrosive materials, check for
lubrication frequently.
Tire rotation
Tires should be rotated every 10,000 km (6,000 miles).
INSIDE THE VEHICLE
The maintenance items listed here should be checked on a regular basis, such as when performing periodic maintenance, cleaning the
vehicle, etc.
Item
Reference page
Lamps
Make sure that the headlamps, stop lamps, tail lamps, turn signal lamps,
and other lamps are all operating properly and installed securely. Also check
headlamp aim.
—
Warning lamps and
chimes
Make sure that all warning lamps and buzzers/chimes are operating prop-
erly.
—
Steering wheel
Check that it has the specified play.
Check for changes in the steering conditions, such as excessive free play,
hard steering or strange noises.
Free play: Less than 35 mm (1.38 in)
—
Seat belts
Check that all parts of the seat belt system (e.g. buckles, anchors, adjusters
and retractors) operate properly and smoothly, and are installed securely.
Check the belt webbing for cuts, fraying, wear or damage.
UNDER THE HOOD AND VEHICLE
The maintenance items listed here should be checked periodically e.g. each time you check the engine oil or refuel.
Item
Reference page
Windshield washer
fluid
Check that there is adequate fluid in the tank.
—
Engine coolant level
Check the coolant level when the engine is cold.
Engine oil level
Check the level after parking the vehicle (on level ground) and turning off
the engine.
Brake and clutch
fluid levels
Make sure that the brake and clutch fluid levels are between the “MAX” and
“MIN” lines on the reservoir.
Battery
Check the fluid level in each cell. It should be between the “MAX” and “MIN”
lines.
—
GENERAL MAINTENANCE
MA-3
NLMA0046
Engine and Emission Control Maintenance
(QG18DE/SR20DE engine)
NLMA0046S01
Abbreviations: I = Inspect and correct or replace as necessary, R = Replace, A = Adjust, C = Clean, E = Check and correct the
engine coolant mixture ratio.
MAINTENANCE OPERATION MAINTENANCE INTERVAL
Perform either at number of kilometers
(miles) or months, whichever comes first.
km
×
1,000 1 10 20 30 40 50 60 70 80
Refer-
ence
page
(mile
×
1,000) (0.6) (6) (12) (18) (24) (30) (36) (42) (48)
Months — 6
12
18
24
30
36
42
48
Underhood and under vehicle
Torque of manifolds & exhaust tube nuts*1 I —
Intake & exhaust valve clearance*2 A
A
A
A
Drive Belts I*1 I*1 I I*1 I
Engine oil (Use API SE, SF, SG, SH or SJ
oil.)
★
R
R
R
R
R
R
R
R
Engine oil filter (Use Part No. 15208
65F01 or equivalent)
★
R
R
R
R
R
R
R
R
Engine coolant (Use Nissan genuine
engine coolant or equivalent in its quality.)
See NOTE (1)
E
R
Cooling system I
I
I
I
Fuel lines I I FE-5
Air cleaner filter (Viscous paper type)
★
R
R
Fuel filter See NOTE (2) FE-9
Positive crankcase ventilation (PCV) sys-
tem
I*1 I*1 I*1 I*1
Spark plugs (Conventional type)*3 R R
Spark plugs (Conventional type, For
leaded fuel)*1
I
R
I
R
I
R
I
R
Spark plugs (Conventional type, For
unleaded fuel)*1
I
I
I
R
I
I
I
R
Spark plugs (PLATINUM TYPE) Replace every 100,000 km (60,000 miles)
Ignition leads I I EC-816
EVAP vapor lines (With carbon canister) I I
Vacuum hoses & connections*1 I
I
I
I
Heated oxygen sensor (Exhaust gas sen-
sor)
I
I
NOTE:
Maintenance item with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
(1) Use Nissan genuine engine coolant or equivalent in its quality, in order to avoid possible aluminium corrosion within the
engine cooling system caused by the use of non-genuine engine coolant. After first replacement, replace every 40,000 km (24,
000 miles) or 24 months.
(2) Maintenance-free item. For service procedures, refer to FE section.
PERIODIC MAINTENANCE (EXCEPT FOR EUROPE)
Engine and Emission Control Maintenance (QG18DE/SR20DE engine)
MA-4
*1: Models without three way catalyst
*2: For models with three way catalyst, periodic maintenance is not required. However, if valve noise increases, check valve clearance.
*3: Models with three way catalyst
PERIODIC MAINTENANCE (EXCEPT FOR EUROPE)
Engine and Emission Control Maintenance (QG18DE/SR20DE engine) (Cont’d)
MA-5
Engine Maintenance (YD22DDTi engine)
=NLMA0046S02
Abbreviations:
I = Inspect and correct or replace as necessary, R = Replace, A = Adjust, D = Check filter and drain water.
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Perform either at number of kilome-
ters (miles) or months, whichever
comes first.
km
×
1,000
1
10
20
30
40
50
60
70
80
Reference
page
(mile
×
1,000)
(0.6)
(6)
(12)
(18)
(24)
(30)
(36)
(42)
(48)
Months
—
6
12
18
24
30
36
42
48
Underhood and under vehicle
Torque of manifolds & exhaust tube
nuts
I
—
Intake & exhaust valve clearance
See NOTE (1)
Drive belts
I
I
I
I
I
Engine oil (Use API CD, CE, CF,
CF-4 oil.)
★
See NOTE (5)
Replace every 15,000 km (9,000 miles) or 12 months
Engine oil filter (Use Eco filter or
equivalent)
★
See NOTE (2)
Replace every 15,000 km (9,000 miles) or 12 months
Engine coolant (Use Nissan genuine
engine coolant or equivalent in its
quality.)
See NOTE (3)
E
R
Cooling system
I
I
I
I
Fuel lines
I
I
Air cleaner filter (Viscous paper
type)
★
R
R
Fuel filter
★
D
D
D
R
D
D
D
R
Injection nozzles
See NOTE (4)
NOTE:
Maintenance item with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
(1) If valve noise increases, check valve clearance.
(2) Oil filter element assembly (part No. 15208 AD200) and O-ring seal (part No. 15226 AD200) are replacement parts.
(3) Use Nissan genuine engine coolant or equivalent in its quality, in order to avoid possible aluminium corrosion within the
engine cooling system caused by the use of non-genuine engine coolant. After first replacement, replace every 40,000 km (24,
000 miles) or 24 months.
(4) If engine power decreases, black exhaust smoke is emitted or engine noise increases, check injection nozzles and, if
necessary, replace injection nozzle assembly.
(5) Never use CG-4 oil.
PERIODIC MAINTENANCE (EXCEPT FOR EUROPE)
Engine Maintenance (YD22DDTi engine)
MA-6
Chassis and Body Maintenance
=NLMA0046S03
Abbreviations:
I = Inspect and correct or replace as necessary, R = Replace, A = Adjust, L = Lubricate
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference
page
Perform either at number of kilometers
(miles) or months, whichever comes
first.
km
×
1,000
1
10
20
30
40
50
60
70
80
(mile
×
1,000)
(0.6)
(6)
(12)
(18)
(24)
(30)
(36)
(42)
(48)
Months
—
6
12
18
24
30
36
42
48
Underhood and under vehicle
Brake & clutch fluid (For level &
leaks)
★
I
I
I
I
I
I
I
I
Brake fluid
★
R
R
Brake booster vacuum hoses, connec-
tions & check valve
I
I
Power steering fluid & lines (For level
& leaks)
I*1
I
I*1
I
I*1
I
I*1
I
Brake, clutch & exhaust systems
I
I
I
I
I
I
I
I
H·CVT fluid (For level and leaks)
I
I
I
I
I
I
I
I
H·CVT fluid
★
R
R
Manual transaxle gear oil (For level &
leaks)
I*1
I
I*1
I
I*1
I
I*1
I
Steering gear & linkage, axle & sus-
pension parts & drive shafts
★
I*2
I
I
I
I
Outside and inside
Wheel alignment (if necessary, rotate
& balance wheels)
I
I
I
I
Brake pads, rotors & other brake com-
ponents
★
I
I
I
I
I
I
I
I
Lock, hinges & hoods latch
★
L*1
L
L*1
L
L*1
L
L*1
L
Seat belts, buckles, retractors,
anchors & adjuster
I
I
I
I
Foot brake, parking brake & clutch
(For free play, stroke & operation)
I*1
I
I*1
I
I*1
I
I*1
I
Ventilation air filter
★
Replace every 12,000 km (7,500 miles) or 12 months
Supplemental air bag systems
See NOTE (1)
NISSAN Mobility System
See NOTE (2)
I
I
I
I
I
—
NOTE:
(1) Inspect at the first 10 years, and then every 2 years.
Maintenance item with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Condi-
tions”.
(2) Check expiration date of the tyre sealant bottle. Replace if necessary.
*1: Models except for Australia
*2: Models without three way catalyst
PERIODIC MAINTENANCE (EXCEPT FOR EUROPE)
Chassis and Body Maintenance
MA-7
Maintenance Under Severe Driving Conditions
=NLMA0046S04
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle
is mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-
formed on the following items as shown in the table.
SEVERE DRIVING CONDITIONS
NLMA0046S0401
A — Driving under dusty conditions
B — Driving repeatedly short distances
C — Towing a trailer or caravan
D — Extensive idling
E — Driving in extremely adverse weather conditions or in areas where ambient temperatures are either
extremely low or extremely high
F — Driving in high humidity areas or in mountainous areas
G — Driving in areas using salt or other corrosive materials
H — Driving on rough and/or muddy roads or in the desert
I — Driving with frequent use of braking or in mountainous areas
Driving condition
Maintenance item
Maintenance
operation
Maintenance
interval
Refer-
ence
page
A
.
.
.
.
.
.
.
.
Air cleaner filter
Viscous paper type
Replace
More frequently
A
B
C
D
.
.
.
.
.
Engine oil & oil filter (QG18DE/SR20DE
engine)
Replace
Every 5,000 km
(3,000 miles) or 3
months
A
B
C
D
.
.
.
.
.
Engine oil (YD22DDTi engine)
Replace
More frequently
Engine oil filter (YD22DDTi engine)
Every 7,500 km
(4,500 miles) or 6
months
A
.
.
.
E
.
.
.
.
Fuel filter (YD22DDTi engine)
Replace
Every 20,000 km
(12,000 miles) or
12 months
.
.
.
.
.
F
.
.
.
Brake fluid
Replace
Every 20,000 km
(12,000 miles) or
12 months
.
.
C
.
.
.
.
H
.
H·CVT fluid
Replace
Every 20,000 km
(12,000 miles) or
12 months
.
.
.
.
.
.
G
H
.
Steering gear & linkage, axle & suspen-
sion parts & drive shafts
Check
Every 10,000 km
(6,000 miles) or 6
months
A
.
C
.
.
.
G
H
I
Brake pads, rotors & other brake com-
ponents
Check
Every 5,000 km
(3,000 miles) or 3
months
.
.
.
.
.
.
G
.
.
Lock, hinges & hood latch
Lubricate
Every 5,000 km
(3,000 miles) or 3
months
A
.
.
.
.
.
.
.
.
Ventilation air filter
Replace
More frequently
PERIODIC MAINTENANCE (EXCEPT FOR EUROPE)
Maintenance Under Severe Driving Conditions
MA-8
NLMA0043
The following tables show the normal maintenance schedule. Depending upon weather and atmospheric
conditions, varying road surfaces, individual driving habits and vehicle usage, additional or more frequent
maintenance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
Maintenance Schedule for Petrol Engines
(Annual Mileage < 30,000 km/year)
NLMA0043S01
QG18DE/SR20DE ENGINES
NLMA0043S0101
Abbreviations: R = Replace I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION MAINTENANCE INTERVAL Reference pages
Perform on a kilometer basis, but on
an annual basis when driving less than
15,000 km (9,000 miles) per year
km x 1,000
(miles x 1,000)
Months
15
(9)
12
30
(18)
24
45
(27)
36
60
(36)
48
75
(45)
60
90
(54)
72
105
(63)
84
120
(72)
96
QG18DE SR20DE
Engine compartment and under vehicle
Engine oil (Use recommended oil)
★
R
R
R
R
R
R
R
R
Engine oil filter
(Use NISSAN genuine part or equiva-
lent)
★
R
R
R
R
R
R
R
R
Drive belts I
I
I
I
I
I
I
I
Cooling system I
I
I
I
I
I
I
I
Engine anti-freeze coolant
(Use genuine NISSAN Anti-Freeze
Coolant (L2N) or equivalent)
See NOTE (1) I R I LC-19 LC-59
Air cleaner filter
★
R R EM-18 EM-88
Intake and exhaust valve clearance
(non HLA models)
See NOTE (2) EM-42 —
Fuel and EVAP vapour lines I
I
I
I
Spark plugs Platinum tipped type [R] — EM-89
Conventional type R
R
R
R
Ignition leads I I — EC-816
PCV system I
I
I
I
Fuel filter See NOTE (3) FE-9 FE-9
NOTE:
(1) First replace at 90,000 km (54,000 miles)/60 months, then every 60,000 km (36,000 miles)/48 months. Perform “I” (Check-
ing the mixture ratio and correcting the mixture ratio if necessary) at the middle of replacement interval.
(2) Periodic maintenance is not required. However, if valve noise increases, check valve clearance.
(3) Fuel filter is maintenance-free. For service procedures, refer to FE section.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Petrol Engines (Annual Mileage < 30,000 km/year)
MA-9
CHASSIS AND BODY MAINTENANCE
=NLMA0043S0102
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
[
] = At the specified mileage only
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Refer-
ence
pages
Perform on a kilometer basis, but on
an annual basis when driving less
than 15,000 km (9,000 miles) in a
year.
km x 1,000
(miles x 1,000)
Months
15
(9)
12
30
(18)
24
45
(27)
36
60
(36)
48
75
(45)
60
90
(54)
72
105
(63)
84
120
(72)
96
Underhood and under vehicle
Headlamp aiming
I
I
I
I
I
I
I
I
Wheel alignment (if necessary, bal-
ance & rotate wheels)
I
I
I
I
I
I
I
I
Brake pads, rotors & other brake
components
★
I
I
I
I
I
I
I
I
Foot brake, parking brake & clutch
(for free play, stroke & operation)
I
I
I
I
I
I
I
I
Brake booster vacuum hoses,
connections, check valve
I
I
I
I
Brake & clutch, systems and fluid (for
level and leaks)
I
I
I
I
I
I
I
I
Brake fluid
★
R
R
R
R
Power steering fluid and lines (for
level and leaks)
I
I
I
I
I
I
I
I
Supplemental air bag systems
See NOTE (1)
Ventilation air filter
★
R
R
R
R
Manual transaxle gear oil (check for
leakage. Use genuine NISSAN XZ
gear oil or exact equivalent)
I
I
I
I
I
I
I
I
CVT fluid [for level and leaks or
replace. Use genuine NISSAN CVT
fluid (NS-1) or exact equivalent]
★
I
I
I
[R]
I
I
I
[R]
Steering gear & linkage, axle & sus-
pension parts, drive shafts, exhaust
system
★
I
I
I
I
NISSAN Mobility System
See NOTE (2)
I
I
I
I
I
I
I
—
Body corrosion
See NOTE (3)
NOTE:
(1) Inspect after 10 years, then every 2 years.
(2) Check expiration date of the tyre sealant bottle. Replace if necessary.
(3) Inspect once per year.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Petrol Engines (Annual Mileage < 30,000 km/year) (Cont’d)
MA-10
Maintenance Schedule for Diesel Engines
(Annual Mileage < 30,000 km/year)
=NLMA0043S02
YD22DDTI ENGINE
NLMA0043S0201
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference
pages
Perform on a kilometer basis, but
on an annual basis when driving
less than 20,000 km
(12,000 miles) per year.
km x 1,000
(miles x 1,000)
Months
20
(12)
12
40
(24)
24
60
(36)
36
80
(48)
48
100
(60)
60
120
(72)
72
Engine compartment and under vehicle
Engine oil (Use recommended
oil)
★
R
R
R
R
R
R
Engine oil filter (Use Eco filter or
equivalent)
★
See NOTE (1)
R
R
R
R
R
R
Drive belts
I
I
I
I
I
I
Cooling system
I
I
I
I
I
I
Engine anti-freeze coolant (Use
genuine NISSAN Anti-freeze
Coolant (L2N) or equivalent)
See NOTE (2)
I
I
Air cleaner filter
★
R
R
Intake & exhaust valve clearance See NOTE (3)
Fuel lines
I
I
I
Injection nozzles
See NOTE (4)
Fuel filter
★
R
R
R
NOTE:
(1) Oil filter element assembly and O-ring seal are replacement parts.
(2) First replace at 100,000 km (60,000 miles)/60 months, then every 60,000 km (36,000 miles)/36 months. After first replacement,
perform “I” (checking the mixture ratio and correcting the mixture ratio if necessary) at the middle of replacement interval.
(3) If valve noise increases, check valve clearance.
(4) If engine power decreases, black exhaust smoke is emitted or engine noise increases, check injection nozzles and if
necessary, replace injection nozzle assembly.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Diesel Engines (Annual Mileage < 30,000 km/year)
MA-11
CHASSIS AND BODY MAINTENANCE
=NLMA0043S0202
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference pages
Perform on a kilometer basis, but
on an annual basis when driving
less than 20,000 km (12,000 miles)
per year.
km x 1,000
(miles x 1,000)
Months
20
(12)
12
40
(24)
24
60
(36)
36
80
(48)
48
100
(60)
60
120
(72)
72
Underhood and under vehicle
Headlamp aiming
I
I
I
I
I
I
Wheel alignment (if necessary, bal-
ance & rotate wheels)
I
I
I
I
I
I
Brake pads, rotors & other brake
components
★
I
I
I
I
I
I
Foot brake, parking brake & clutch
(for free play, stroke & operation)
I
I
I
I
I
I
Brake booster vacuum hoses,
connections, check valve
I
I
I
Brake & clutch, systems and fluid
(for level and leaks)
I
I
I
I
I
I
Brake fluid
★
R
R
R
Power steering fluid and lines (for
level and leaks)
I
I
I
I
I
I
Supplemental air bag systems
See NOTE (1)
Ventilation air filter
★
R
R
R
R
R
R
Manual transaxle gear oil (check for
leakage. Use genuine NISSAN XZ
gear oil or exact equivalent)
I
I
I
I
I
I
Steering gear & linkage, axle &
suspension parts, drive shafts,
exhaust system
★
I
I
I
NISSAN Mobility System
See NOTE (2)
I
I
I
I
I
—
Body corrosion
See NOTE (3)
NOTE:
(1) Inspect after 10 years, then every 2 years.
(2) Check expiration date of the tyre sealant bottle. Replace if necessary.
(3) Inspect once per year.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Diesel Engines (Annual Mileage < 30,000 km/year) (Cont’d)
MA-12
Maintenance Under Severe Driving Conditions
(Annual Driving Distance < 30,000 km/year)
=NLMA0043S03
The maintenance intervals shown on the preceding pages are for normal operating conditions. If the vehicle
is mainly operated under severe driving conditions as shown below, more frequent maintenance must be per-
formed on the following items as shown in the table.
A — Driving under dusty conditions
B — Driving repeatedly short distances
C — Towing a trailer or caravan
D — Extensive idling
E — Driving in extremely adverse weather conditions or in areas where ambient temperatures are either
extremely low or extremely high
F — Driving in high humidity areas or in mountainous areas
G — Driving in areas using salt or other corrosive materials
H — Driving on rough and/or muddy roads or in the desert
I — Driving with frequent use of braking or in mountainous areas
J — Frequent off road use or driving in water
K — Sustained high speed driving
L — For models without Euro-OBD system
Driving condition
Maintenance
item
Maintenance
operation
Maintenance interval
A
B
C
D
.
.
.
.
.
.
.
.
Engine oil & engine oil filter
Petrol models
Replace
Every 7,500 km (4,500 miles) or 6
months
Diesel models
Replace
Every 10,000 km (6,000 miles) or
6 months
A
.
.
.
.
.
.
.
.
.
.
.
Air cleaner filter
Petrol models
Replace
Every 30,000 km (18,000 miles) or
24 months
Diesel models
Replace
Every 30,000 km (18,000 miles) or
18 months
A
.
.
.
E
.
.
.
.
.
.
.
Fuel filter
Diesel models
Replace
Every 20,000 km (12,000 miles) or
12 months
A
.
.
.
.
.
.
.
.
.
.
.
Ventilation air filter
Petrol models
Replace
Every 15,000 km (9,000 miles) or
12 months
Diesel models
Replace
Every 10,000 km (6,000 miles) or
6 months
.
.
.
.
.
F
.
.
.
.
.
.
Brake fluid
Petrol models
Replace
Every 15,000 km (9,000 miles) or
12 months
Diesel models
Replace
Every 20,000 km (12,000 miles) or
12 months
A
.
C
.
.
.
G
H
I
.
.
.
Brake pads, rotors & other brake system components
Petrol models
Inspect
Every 7,500 km (4,500 miles) or 6
months
Diesel models
Inspect
Every 10,000 km (6,000 miles) or
6 months
PERIODIC MAINTENANCE
Maintenance Under Severe Driving Conditions (Annual Driving Distance < 30,000 km/year)
MA-13
Driving condition
Maintenance
item
Maintenance
operation
Maintenance interval
.
.
.
.
.
.
G
H
.
.
.
.
Steering gear & linkage, axle & suspension parts, drive shafts,
exhaust system
Petrol models
Inspect
Every 15,000 km (9,000 miles) or
12 months
Diesel models
Inspect
Every 20,000 km (12,000 miles) or
12 months
PERIODIC MAINTENANCE
Maintenance Under Severe Driving Conditions (Annual Driving Distance < 30,000 km/year) (Cont’d)
MA-14
Maintenance Schedule for Petrol Engines
(Annual Mileage > 30,000 km/year)
=NLMA0043S04
QG18DE/SR20DE ENGINES
NLMA0043S0401
Abbreviations: R = Replace I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION MAINTENANCE INTERVAL
Reference
pages
Perform on a kilometer basis only.
km x 1,000
(miles x
1,000)
15
(9)
30
(18)
45
(27)
60
(36)
75
(45)
90
(54)
105
(63)
120
(72)
QG
18DE
SR
20DE
Engine compartment and under vehicle
Engine oil (Use recommended oil)
★
R
R
R
R
R
R
R
R
Engine oil filter (Use NISSAN genuine part or
equivalent)
★
R
R
R
R
R
R
R
R
Drive belts I
I
I
I
I
I
I
I
Cooling system I
I
I
I
Engine anti-freeze coolant (Use genuine
NISSAN Anti-Freeze Coolant (L2N) or equiva-
lent)
See NOTE
(1)
I R I LC-19 LC-59
Air cleaner filter
★
R R EM-18 EM-88
Intake & exhaust valve clearance (Non HLA
models)
See NOTE
(2)
EM-42 —
Fuel and EVAP vapor lines I I
Spark plugs
Platinum tipped type R — EM-89
Conventional type R
R
R
R
Ignition leads I — EC-816
PCV system R R EC-42 EC-576
Fuel filter
See NOTE
(3)
NOTE:
(1) First replace at 90,000 km (54,000 miles), then every 60,000 km (36,000 miles). Perform “I” (checking the mixture ratio and
correcting the mixture ratio if necessary) at the middle of replacement interval.
(2) Periodic maintenance is not required. However, if valve noise increases, check valve clearance.
(3) Fuel filter is maintenance-free. For service procedures, refer to FE section.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Petrol Engines (Annual Mileage > 30,000 km/year)
MA-15
CHASSIS AND BODY MAINTENANCE
=NLMA0043S0402
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Refer-
ence
pages
Perform on a kilometer basis only.
km x 1,000
(miles x 1,000)
15
(9)
30
(18)
45
(27)
60
(36)
75
(45)
90
(54)
105
(63)
120
(72)
Underhood and under vehicle
Headlamp aiming
I
I
I
I
Wheel alignment (if necessary, bal-
ance & rotate wheels)
I
I
I
I
Brake pads, rotors & other brake
components
★
I
I
I
I
Foot brake, parking brake & clutch
(for free play, stroke & operation)
I
I
I
I
Brake booster vacuum hoses,
connections, check valve
I
I
Brake & clutch, systems and fluid (for
level and leaks)
I
I
I
I
Brake fluid
★
R
R
Power steering fluid and lines (for
level and leaks)
I
I
I
I
Supplemental air bag systems
See NOTE (1)
Ventilation air filter
★
R
R
R
R
Manual transaxle gear oil (check for
leakage. Use genuine NISSAN XZ
gear oil or exact equivalent)
I
I
I
I
CVT fluid [for level and leaks or
replace. Use genuine NISSAN CVT
fluid (NS-1) or exact equivalent]
★
I
[R]
I
[R]
Steering gear and linkage, axle &
suspension parts, drive shafts,
exhaust system
★
I
I
NISSAN Mobility System
See NOTE (2)
I
I
I
I
I
I
I
—
Body corrosion
See NOTE (3)
NOTE:
(1) Inspect after 10 years, then every 2 years.
(2) Check expiration date of the tyre sealant bottle. Replace if necessary.
(3) Inspect once per year.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Petrol Engines (Annual Mileage > 30,000 km/year) (Cont’d)
MA-16
Maintenance Schedule for Diesel Engines
(Annual Mileage > 30,000 km/year)
=NLMA0043S05
YD22DDTI ENGINE
NLMA0043S0501
Abbreviations: R = Replace
I = Inspect: Correct or replace if necessary
MAINTENANCE OPERATION
MAINTENANCE INTERVAL
Reference
pages
Perform on a kilometer basis
only.
km x 1,000
(miles x 1,000)
20
(12)
40
(24)
60
(36)
80
(48)
100
(60)
120
(72)
Engine compartment and under vehicle
Engine oil (Use recommended
oil)
★
R
R
R
R
R
R
Engine oil filter (Use Eco filter or
equivalent)
★
See NOTE (1)
R
R
R
R
R
R
Drive belts
I
I
I
I
I
I
Cooling system
I
I
I
I
I
I
Engine anti-freeze coolant (Use
genuine NISSAN Anti-Freeze
Coolant (L2N) or equivalent)
See NOTE (2)
I
I
Air cleaner filter
★
R
R
Intake & exhaust valve clearance See NOTE (3)
Fuel lines
I
I
Injection nozzles
See NOTE (4)
Fuel filter
★
R
R
NOTE:
(1) Oil filter element assembly and O-ring seal are replacement parts.
(2) First replace at 100,000 km (60,000 miles), then every 60,000 km (36,000 miles). After first replacement, perform “I” (check-
ing the mixture ratio and correcting the mixture ratio if necessary) at the middle of replacement interval.
(3) If valve noise increases, check valve clearance.
(4) If engine power decreases, black exhaust smoke is emitted or engine noise increases, check injection nozzles and if
necessary, replace injection nozzle assembly.
★
Maintenance items with “
★
” should be performed more frequently according to “Maintenance Under Severe Driving Con-
ditions”.
PERIODIC MAINTENANCE
Maintenance Schedule for Diesel Engines (Annual Mileage > 30,000 km/year)
MA-17
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст